Summary of Contents for DELSOL DSBQ25
- Page 1 DELSOL G RILL INSTALLATION, USE & CARE MANUAL Models DSBQ25 DSBQ32R P/N: 18930C DSBQ40R...
- Page 2 A special message… Congratulations on your purchase of DELSOL gas barbecue grill. DELSOL is committed to making outdoor cooking products you’ll be proud to own for years. This manual gives you easy to follow instructions for installing, operating and maintaining your DELSOL grill. We recommend reading this manual carefully before your first use to ensure safety, proper care and operation.
- Page 3 – DELSOL G IMPORTANT SAFETY INFORMATION RILL WARNING! Read this manual carefully and completely before using your grill to ensure proper operation, proper installation, proper servicing and to reduce the risk of fire, burn hazard and/ or other injury. D A N G E R D A N G E R S’il y a une odeur de gaz:...
- Page 4 Without the drip pan, hot grease and debris could leak downward and produce a fire hazard. 13. The pressure regulator and hose assembly supplied with the DELSOL Gas Grill must be used. Replacement pressure regulators and hose assemblies must be those specified by DELSOL.
-
Page 5: Table Of Contents
– DELSOL G TABLE OF CONTENTS RILL GETTING STARTED…………………………………………………………………… ….. GAS REQUIREMENTS o GAS SAFETY REQUIREMENT……………………………………………... o LP GAS HOOKUP………….………………………………………………… o PORTABLE LP CONNECTION………….………………………………….. o NATURAL GAS INSTALLATION………………………………………….. o LEAK TEST…………………………………………………………………… BURNER FLAME / AIR SHUTTER ADJUSTMENT............LOCATING THE GRILL o CLEARANCE TO COMBUSTIBLE CONSTRUCTION……………………... - Page 6 – DELSOL G GETTING STARTED RILL 1. Remove all packaging materials, labels and protective plastic film. DO NOT LEAVE UNIT UNDER THE SUN WITH PROTECTIVE PLASTIC FILM ON FOR A LONG PERIOD OF TIME AS IT WILL BECOME DIFFICULT TO REMOVE THE FILM.
- Page 7 – DELSOL G GETTING STARTED RILL 5. Get familiar with the knobs and burners identification below. DSBQ25 DSBQ32R Grill Rotisserie Grill Grill Burner Burner Burner Burner Sear Zone (Opt) DSBQ40R Rotisserie Grill Grill Burner Burner Burner Infrared Rotisserie Burner located on the rear panel Straight Burner (Standard) located underneath the above the grates.
-
Page 8: L.p. Gas Safety Requirement
– DELSOL G GAS SAFETY REQUIREMENTS RILL Each appliance is set and tested at the factory for the type of gas supply to be used. Identify the type of gas, either Natural Gas or LP gas and make sure that the marking on the data plate (rating plate) matches the gas being supplied to the grill. -
Page 9: Lp Gas Hookup
– DELSOL G LP GAS HOOK-UP RILL DELSOL grill for the use of LP gas comes equipped with its own regulator, which MUST NOT ” flare be removed. Install the factory-supplied hose and regulator assembly as shown. Connect the end of the hose to the grill coupling using a ¾” open wrench. Do not apply pipe sealant to the ”... -
Page 10: Portable Lp Connection
SUPPLIED WITH GRILL BASE AND ENSURE THAT THE TANK IS SECURED PROPERLY. DELSOL grill for use of LP gas comes equipped with its own regulator, which MUST NOT be removed. 1) To install the gas cylinder, place the cylinder onto the Convertible Gas provided cutout. -
Page 11: Natural Gas Installation
– DELSOL G NATURAL GAS INSTALLATION RILL The installation must conform with local codes or, in the absence of local codes, with either the national Fuel Gas Code, ANSI Z223.1/NFPA 54, or CAN/CGA-B149.1, Natural Gas Installation Code or CAN/CGA-B149.2, Propane Installation Code. - Page 12 Do not use any replacement regulator other than that specified by DELSOL. Use only pipe sealants that are approved for use with Natural and LP gases. An installer-supplied gas shutoff valve must be installed in an accessible...
-
Page 13: Leak Test
Check to ensure that flexible hoses do not have any cuts and wear that may affect the safety before each use. Only the factory supplied hose and regulator must be used. Use only replacement regulator and hose assemblies specified by DELSOL. LEAK TEST 1) Prepare a leak testing solution of sudsy water by mixing in a spray bottle with half liquid soap and half water. -
Page 14: Burner Flame / Air Shutter Adjustment
– DELSOL G BURNER FLAME / AIR SHUTTTER ADJUSTMENT RILL Each grill burner is tested and adjusted at the factory prior to shipment; however, variations in the local gas supply may make it necessary to adjust the burners. The flames of the straight burners should be visually checked. -
Page 15: Locating The Grill
– DELSOL G LOCATING THE GRILL RILL This gas appliance is designed and certified for outdoor use only. Do not locate this grill under overhead combustible surfaces. Do not operate the grill inside a building, garage, recreation vehicle or any enclosed area. When choosing an area, consider exposure to wind, proximity to traffic paths and length of gas supply line. -
Page 16: Grill
– DELSOL G GRILL CUT-OUT DIMENSIONS RILL The island must be made out of non-combustible material. In an event it is combustible, the use of an insulating jacket is required. -
Page 17: Assembly Instructions
– DELSOL G ASSEMBLY INSTRUCTIONS RILL DELSOL Grill is produced fully assembled and tested in the factory and requires no major assembly in the field. For the purpose of safe shipping and transit, some parts such as the briquette trays and rotisserie components are wrapped inside the grill and require minor assembly. -
Page 18: Rotisserie
– DELSOL G ASSEMBLY INSTRUCTIONS RILL OPTIONAL DELSOL ROTISSERIE KIT ASSEMBLY (DSRS-KIT) 1. Install the bracket as shown in figure 1. 2. Install the rotisserie motor as shown as shown in figure 2. The motor socket hole will line up with the notch of the rear hood. -
Page 19: Operating Instructions
– DELSOL G OPERATING INSTRUCTIONS RILL BEFORE LIGHTING THE GRILL DO NOT ATTEMPT TO LIGHT THE GRILL IF YOU SMELL GAS. WARNING! IT IS CRITICAL THAT THE GAS BURNERS ARE PROPERLY INSTALLED WITH THEIR ORIFICES INSIDE THE BURNERS AIR SHUTTERS. If not properly installed, gas may leak outside of the burner that could lead to fire, potential damage to your grill, bodily injury or death. -
Page 20: Match Lighting Instructions
– DELSOL G OPERATING INSTRUCTIONS RILL Match/BBQ Lighter Lighting Instructions: If spark igniter will not light the burners, the burners can be lit manually using a lit long match, taper or BBQ lighter. Push and turn the knob counter-clock-wise to the biggest flame marking on the bezel. -
Page 21: Using The Rotisserie Burner
– DELSOL G OPERATING INSTRUCTIONS RILL USING THE ROTISSERIE BURNER (For DSBQ32R & DSBQ40R Units) The Rotisserie system rotates the food in front of infrared burner heat for even cooking and juicier taste. 1. Install the rotisserie motor on the motor bracket and plug it in to proper voltage. -
Page 22: Grilling In Windy Condition
– DELSOL G GRILLING IN WINDY CONDITIONS RILL Outdoor grills produce more heat than interior kitchen ranges. That is how they sear and grill steaks and other food. These high performance burners require a constant steady supply of fresh air to mix with fuel. -
Page 23: Stainless Steel
– DELSOL G CLEANING & MAINTENANCE RILL STAINLESS STEEL DELSOL grill is made of all stainless steel. It is non-rusting and non-magnetic. Never clean the stainless steel when it is hot. After the initial grilling use, certain areas of the grill may discolor. -
Page 24: U-Burner & Sear Zone Burner
– DELSOL G CLEANING & MAINTENANCE RILL BURNERS Burners are made of heavy gauge stainless steel and can be soaked in water and cleaned with a wire brush. Check every port hole for clogs. Use a wire pin to clean out clogged ports. -
Page 25: Trouble Shooting Guide
RILL BEFORE CALLING FOR SERVICE: If your DELSOL grill does not function properly, use the following troubleshooting guide before contacting your dealer for service. The troubleshooting guide may save the cost of a service call and the inconvenience of being without your grill. -
Page 26: Exploded View
– DELSOL G EXPLODED VIEW RILL... -
Page 27: Replacement Parts List
REPLACEMENT PARTS LIST – DELSOL G RILL Item DSBQ DSBQ DSBQ DSBQ DSBQ DSBQ TE Part No. Description 25G-L 25G-N 32R-L 32R-N 40R-L 40R-N S15353 Thermometer S13216 Thermometer, Bezel S12362 Tube, Handle, 25 S12355 Tube, Handle, 32 S12361 Tube, Handle, 40... - Page 28 REPLACEMENT PARTS LIST – DELSOL G RILL Item DSBQ DSBQ DSBQ DSBQ DSBQ DSBQ TE Part No. Description 25-L 25-N 32R-L 32R-N 40R-L 40R-N S12618 Nipple, ½ Close, BI S15351 NG Regulator S15352 LP Regulator S13876 Match Holder S15145-NG Rotis Valve, NG...
-
Page 29: Limited Product Warranty
422-0091 or 562-802-3391. Be prepared to furnish the following information: Purchaser’s name, model and serial number of the grill, date of purchase and the accurate description of the problem. DELSOL will not pay for service calls for correcting an installation problem. Owner shall be responsible for proper installation, providing normal care and maintenance, providing proof of purchase upon request and making the grill accessible for service. -
Page 30: Warranty Registration Card
HOW TO OBTAIN SERVICE For service, please contact your DELSOL dealer or call DELSOL Grills direct at (562)802-3488 or fax (562) 802-3391 Mailing address: DELSOL Grills 13259 166 Street Cerritos, CA 90703 Please provide: Model number Serial Number ... - Page 31 Here Place Postage Here Customer Service ATTN: Warranty Department 13259 166 Street Cerritos, CA 90703...
Need help?
Do you have a question about the DSBQ25 and is the answer not in the manual?
Questions and answers