Summary of Contents for Chase Doors DuraShield Series
- Page 1 DuraShield Installation Manual Chain Hoist – Inside Standoff – Da-lite Springtube CHAIN HOIST INSIDE STANDOFF GENERAL MOUNTING DIAGRAM Chase Doors Inc. 800-543-4455 8/12 DuraShield Installation Manual RB0371 Page 1...
- Page 2 DuraShield Installation Manual Chain Hoist – Inside Standoff – Da-lite Springtube Chase Doors Inc. 800-543-4455 8/12 DuraShield Installation Manual RB0371 Page 2...
- Page 3 CLEAR OPENING HEIGHT ( FLOOR TO HEADER ) CLEAR OPENING WIDTH ( INSIDE OF TRACKS ) CLEAR OPENING WIDTH PLUS 9" ( OUTSIDE OF TRACKS ) Door dimension drawing Chase Doors Inc. 800-543-4455 8/12 DuraShield Installation Manual RB0371 Page 3...
- Page 4 The inside mounting dimension of the T Brackets is Clear Opening Width + 11 inches, centered on the opening. T BRACKET MOUNTING TO DOOR HEADER DIMENSIONS COW + 11" 6" Right side shown, Left side opposite Chase Doors Inc. 800-543-4455 8/12 DuraShield Installation Manual RB0371 Page 4...
- Page 5 DO NOT REMOVE CURTAIN STRAPS YET! Install and tighten the shaft set screws on the Cradle Bracket. REAR OF CURTAIN ROLL TO WALL MINIMUM DIMENSION 1 5/8" Chase Doors Inc. 800-543-4455 8/12 DuraShield Installation Manual RB0371 Page 5...
- Page 6 The slotted tabs on the top of the track are bent outward at an angle. Bend the rear until it reaches the wall and bend the front to approximately the same angle. Insert the end of the curtain into the track. Chase Doors Inc. 800-543-4455 8/12...
- Page 7 Install the Stop Block mechanism on the chain as shown on page 5. Position it so that the door will not roll up higher than the Clear Opening Height. Leave the curtain in the fully opened position. Chase Doors Inc. 800-543-4455 8/12...
- Page 8 T Brackets to properly adjust the roll to wall clearance. RELATIONSHIP OF ROLL TUBE TO GUIDE TRACK ENTRY CURTAIN CURTAIN CURTAIN FULLY CLOSED HALF OPENED FULLY OPENED Chase Doors Inc. 800-543-4455 8/12 DuraShield Installation Manual RB0371 Page 8...
- Page 9 Brush seal mounted on bottom face of door Top side brush seal and fasteners 9. Installation of Optional Roll Cover - Center the roll cover over the roll. Fasten securely to the wall. Chase Doors Inc. 800-543-4455 8/12 DuraShield Installation Manual RB0371...
- Page 10 Guide Track with installed Velcro and the installer attaches it to the wall in an appropriate manner Make sure end user is familiar with operation and has all manuals Chase Doors Inc. 800-543-4455 8/12 DuraShield Installation Manual RB0371...
- Page 11 DuraShield Installation Manual Chain Hoist – Inside Standoff – Da-lite Springtube Chase Doors Inc. 800-543-4455 8/12 DuraShield Installation Manual RB0371 Page 11...