Advertisement
Quick Links
Do not use this boiler if any part has been under water. Immediately call a qualified service technician to
inspect the boiler and to replace any part of the control system and any gas control which has been under
water.
Should overheating occur or the gas supply fail to shut off, do not turn off or disconnect the electrical supply to
the pump. Instead, shut off the gas supply at a location external to the appliance.
INFORMATION
SERIES ODVB
GAS FIRED HOT WATER HEATING BOILER
WARNING: If the information in this manual is not
followed exactly, a fire or explosion may result causing
property damage, personal injury or loss of life.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not use
any phone in your building.
•
Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
•
If you cannot reach your gas supplier, call the
fire department.
Installation and service must be performed by a
qualified installer, service agency or the gas
supplier.
USER'S
MANUAL
ECR International
2210 Dwyer Avenue, Utica NY 13504-4729
Phone: (315) 797-1310 • Fax: (866) 432-7329
e-mail: info@ecrinternational.com
web site: www.ecrinternational.com
P/N 37616001, Rev. B [3/2011]
Advertisement
Related Manuals for Olsen ODVB Series
Summary of Contents for Olsen ODVB Series
- Page 1 USER'S INFORMATION MANUAL SERIES ODVB GAS FIRED HOT WATER HEATING BOILER WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
-
Page 2: Safety Symbols & Warnings
INSTRUCTIONS FOR OPERATION AND MAINTENANCE OF GAS FIRED HOT WATER HEATING BOILER RETAIN FOR FUTURE REFERENCE Olsen Boilers recommends all boiler maintenance be SAFETY SYMBOLS & WARNINGS performed by a trained heating technician. The following defined symbols are used throughout... -
Page 3: Lighting Instructions
LIGHTING INSTRUCTIONS 4. This appliance is equipped with an ignition device WARNING which automatically lights the pilot. Do not try to light the pilot by hand. Before lighting any type of pilot burner (standing or intermittent), make certain the 5. Remove jacket front panel. hot water boiler and system are full of water to minimum pressure of 12 lbs. -
Page 4: General Instructions
LIGHTING INSTRUCTIONS To Turn Off Gas To Appliance Note Some gas control knobs cannot be turned 1. Set the thermostat to lowest setting. from "PILOT" to "OFF" unless knob is pushed in slightly. DO NOT FORCE. 2. Turn off all electric power to the appliance if service is to be performed. - Page 5 GENERAL INSTRUCTIONS Before seasonal start up it is advisable to have a certified Place a sheet of heavy paper or similar material in service agency check the boiler for soot and scale in the the bottom of the combus8. tion chamber and brush flues, clean the burners and check the gas input rate to down the flue passageways.
- Page 6 GENERAL INSTRUCTIONS Figure 4 - Burners, Burner Orifices Figure 5 - Boiler Front with Safety Switch VENT PIPE ADAPTER JACKET FRONT BURNERS PANEL COMBUSTION CHAMBER BURNER DOOR (REMOVED) GAS VALVE ORIFICES BURNERS VALVE BURNER ROLL-OUT SAFETY SWITCH Figure 6 - Burner Flame Figure 7 - Burners Pilot Flame 3/8”...
- Page 7 NOTES...
- Page 8 NOTES ECR International 2210 Dwyer Avenue, Utica NY 13504-4729 Phone: (315) 797-1310 • Fax: (866) 432-7329 e-mail: info@ecrinternational.com web site: www.ecrinternational.com Date of Installation: Boiler Model #: Installed By:...
Need help?
Do you have a question about the ODVB Series and is the answer not in the manual?
Questions and answers