Allen Sports 322DN Instructions

W W W W : : : :
ARNING ARNING ARNING ARNING B B B B
IKES IKES IKES OR IKES OR OR RACK OR RACK RACK FALLING RACK FALLING IN FALLING FALLING IN IN IN ROAD ROAD CAN ROAD ROAD
ANY ANY ANY VEHICLE ANY VEHICLE ON VEHICLE VEHICLE ON ON WHICH ON WHICH IT IT IT IT CAN WHICH WHICH CAN CAN CAN NOT NOT NOT NOT BE BE PROPERLY BE BE PROPERLY MOUNTED PROPERLY PROPERLY
Use this rack only on rear mounted external spare tires. Make sure that spare tire is securely attached and that the
•
tire is fully inflated.
Never use rack on spare tires mounted on any type of trailer, RV, or on the front of vehicle.
•
Never carry more than 2 bicycles (
• MAX MAX MAX MAX CAPACITY
remain visible. Bikes must be securely tied to rack. Use bike tie-downs, or additional straps if necessary.
Drive conservatively, especially over bumps. Never use off-road.
•
Do not use if any part of the rack is damaged, worn, or missing. Contact R. A. Allen Co., Inc. for replacement parts.
•
S S S S / A / A / A / A
A. A. A. A.
ETTING ETTING UP ETTING ETTING UP UP UP SSEMBLING SSEMBLING SSEMBLING SSEMBLING
The 322DN ships with the bottom foot uninstalled. Please follow the steps below
to assemble your rack and get ready to ride. Note:
for assembly.
S S S S R R R R
ETTING UP ETTING UP ACK ACK
ETTING ETTING UP UP ACK ACK
It is easiest to assemble the rack with the carry arms
in a set-up position. Please follow 1-3 below.
1. Unfold rack and lay it on its side with Carry
Arms [A] [A] perpendicular to Middle Section [B]. [A] [A]
2. Pull up on Set Up Pins [D] [D] [D] [D] to install into hole on
Carry Arm. Note: Note: Note: Note: Use caution not to pinch your Use caution not to pinch your Use caution not to pinch your Use caution not to pinch your
fingers. fingers. fingers. fingers.
3. Flip rack over and repeat on other side.
I I I I B B B B F F F F R R R R
NSTALLING NSTALLING OTTOM OTTOM OOT ON OOT ON ACK ACK
NSTALLING NSTALLING OTTOM OTTOM OOT OOT ON ON ACK ACK
[A] [A]
[A] [A]
[D] [D]
[D] [D]
[D] [D] [D] [D]
[B] [B] [B] [B]
[E] [E] [E] [E]
[C] [C] [C] [C]
[F] [F]
[F] [F]
CAN CAUSE CAN CAN CAUSE SERIOUS CAUSE CAUSE SERIOUS SERIOUS ACCIDENTS SERIOUS ACCIDENTS ACCIDENTS ACCIDENTS RESULTING RESULTING IN RESULTING RESULTING
MOUNTED MOUNTED AS MOUNTED AS AS AS DESCRIBED DESCRIBED IN DESCRIBED DESCRIBED IN THIS IN IN THIS THIS INSTRUCTION THIS INSTRUCTION SHEET INSTRUCTION INSTRUCTION
: 70 LB : 70 LB : 70 LB : 70 LB) - no tandems, mopeds, or recumbents. Car tail lights must
CAPACITY CAPACITY CAPACITY
R R R R : : : :
ACK ACK ACK ACK
Note: Two 7/16" wrenches needed
Note: Note:
[B]. [B]. [B].
R R R R P P P P
ACK ACK ACK ACK ARTS ARTS ARTS ARTS
A—C A
ARRY RM
B—M S
IDDLE ECTION
C—B F
OTTOM OOT
D—S U P
ET P INS
E—B S B
OTTOM TRAP OLTS
F—B S B
OTTOM TRAP RACKETS
I I I I B B B B F F F F
NSTALLING NSTALLING NSTALLING NSTALLING OTTOM OTTOM OTTOM OTTOM OOT OOT OOT OOT
P B S B
ASS OTTOM TRAP OLTS
B F
THROUGH THE OTTOM OOT
[C]
AND TIGHTEN THE NYLON
INSERT LOCK NUTS USING
. T
WRENCHES HE THREADED
ENDS OF THE BOLTS SHOULD
FULLY PASS THROUGH THE NYLON
LOCKING INSERTS ON THE NUTS
TO ENSURE THAT THE BOLTS ARE
. T B
PROPERLY SECURED HE OT-
S B [F]
TOM TRAP RACKETS
SHOULD BE LOCATED ON THE
M S
INSIDE OF THE IDDLE ECTION
[B] .
AS SHOWN TO THE LEFT
— — — —
IN BODILY IN IN BODILY INJURY BODILY BODILY INJURY INJURY INJURY DO DO DO DO NOT NOT NOT NOT USE USE USE USE RACK RACK ON RACK RACK ON ON ON
. . . .
SHEET SHEET SHEET
I I I I R R R R
B. B. B. B.
NSTALLING NSTALLING NSTALLING NSTALLING ACK ACK ACK ON ACK
1. O
NLY USE RACK ON REAR MOUNTED EXTERNAL SPARE TIRES INSTALLED ON STANDARD AU-
. NEVER
TOMOBILES AND TRUCKS
SPARE TIRE IS SECURELY AT-
TACHED AND FULLY INFLATED
2. B ,
EFORE INSTALLING REMOVE
ANY SPARE TIRE COVERS THAT
MAY BE DAMAGED BY RACK
3. C
OMPLETELY HOOK
/
FOOT CARRY ARM ASSEMBLY
[A] [A] [A] [A]
OVER THE TOP OF SPARE
. P
TIRE OSITION RACK WITH
CARRY ARMS INCLINED
SLIGHTLY UPWARDS
HIGH ENOUGH TO KEEP TAIL
.
LIGHTS VISIBLE
4. B
OTTOM FOOT ASSEMBLY
MUST BE HELD AGAINST THE
TIRE IN A FULLY EXTENDED
. T
POSITION HE BOTTOM
ONLY
FOOT SHOULD
—NEVER
AGAINST THE TIRE
.
ON RIM
5. C
OMPLETELY HOOK BOTTOM
HOOKS TO A METAL EDGE
,
BELOW BUMPER OR AT THE
[E]
BOTTOM OF THE REAR DOOR
6. O
PENING REAR DOOR SLIGHTLY CAN MAKE IT EASIER TO ATTACH BOTTOM HOOKS
7. I
F THERE IS NO METAL EDGE AT THE BOTTOM OF REAR DOOR
. A
BELOW THE BUMPER LTERNATIVELY
.
BUMPERS
8. C
OMPLETELY TIGHTEN BOTTOM STRAPS BY PULLING ON FREE END OF STRAPS UNTIL ELASTIC
PORTION OF STRAPS ARE COMPLETELY STRETCHED
M M M M o o o o d d d d e e e e l l l l 3 3 3 3 2 2 2 2 2 2 2 2 D D D D N N N N I I I I n n n n s s s s t t t t r r r r u u u u c c c c t t t t i i i i o o o o n n n n s s s s
C C C C : : : : Use Allen 322DN only in accordance with local motor
AUTION AUTION
AUTION AUTION
vehicle and traffic regulations.
To avoid damage to rear door or trunk, do not open trunk or
•
rear door when hooks or rack are in place.
Install rack and load bicycles only at a safe distance away
•
from moving traffic.
Rack should only come in contact with vehicle spare tire.
•
Make sure that all of rack and bicycles are kept at a safe dis-
•
tance from road and hot exhaust.
Remove rack from car when not in use
•
V V V V : : : :
ON ON ON EHICLE EHICLE EHICLE EHICLE
NEVER NEVER NEVER
USE RACK ON TRAILERS OR
.
.
TOP
AND
[C] [C]
[C] [C]
REST
.
,
THE STRAPS CAN BE LOOPED AROUND BAR STYLE
.
English - Page 1 V.18.1
RV' . M
S AKE SURE THAT
.
,
LOOK FOR A METAL EDGE