Related Manuals for KBi KrankingKART
Summary of Contents for KBi KrankingKART
- Page 1 KrankingKART ™ Professional Jump-Start Unit (With capacitor power) Operation Manual Revision Date: 3/12 KOLD-BAN INTERNATIONAL, LTD., 8390 PINGREE ROAD, LAKE IN THE HILLS, IL 60156-9637 U.S.A. (847) 658-8561 FAX (847) 658-9280 www.koldban.com...
- Page 2 ACTION THIS CART IS POWERED BY A SUPER CAPACITOR. THIS CAPACITOR OR CAPACITORS ARE VERY POWERFUL AND SHOULD BE TREATED WITH RESPECT. THE LARGE 120-KILOJOULE SIZE IS CAPABLE OF 28,000-WATTS OF POWER. FOR THIS REASON WE ISSUE THE FOLLOWING "WARNING" AND "CAUTION". WARNING Eye protection (wear safety glasses) is recommended when performing any procedures with or on the capacitor cart...
- Page 3 TABLE OF CONTENTS INTRODUCTION OPERATION MAINTENANCE STORAGE...
- Page 4 INTRODUCTION: This cart is designed to be an auxiliary power source for jump starting vehicles. The capacitor stores power and discharges this power when you need it. Following are some of its' features: • Long service life, 500,000 + cycles. •...
- Page 5 OPERATION: There are several models of capacitor carts which all use the following steps. You should check the operation label on your cart for specifics. Check the capacitor's state of charge by rocking the voltmeter switch to the Left and holding.
- Page 6 24 volts on a 24 volt unit in a couple of days if the cart is not used (at the green/amber band). The voltage will hold there for several weeks, this is normal. The KrankingKART unit will operate sufficiently at this voltage.
- Page 7 Transmitter and than immediately engage starter. • The engine should crank immediately. When the engine starts and is running on its' own, the KrankingKART will remain active for a total of 30 seconds to charge the capacitor. • If the engine does not start in 12-seconds of cranking time there may be other vehicle problems unrelated to battery power.
- Page 8 There is NO maintenance required. STORAGE • If the cart is not used for a month or more please charge the KrankingKART to the operating voltage prior to storage. If the KrankingKART is stored at a low voltage (6- volts or less) for an extended period of time its' service life will be reduced.
-
Page 9: Limited Warranty
The exclusive remedy for any product found to be defective under this warranty is limited to the repair or replacement of the defective product without charge, and KBI shall not be liable for any consequential or incidental damages, including labor charges.