Ultra-safe US-96760-120 User Instruction Manual

1-800-850-5914
PHOENIX,
WWW.ULTR S FEUS .COM
MODEL:
__________________________
SIZE: ____________________
D TE: ____________________
WARNING
This product is part of a personal
fall arrest system. The user must
read and follow the Manufacturers
instructions for each component
of the system. These instructions
must be provided to the user of
this product. The user must read
and understand these instructions
before using this product. The
manufacturers instructions must
be followed for proper use and
maintenance of this product.
Alteration or misuse of this
product, or failure to follow
instructions, may result in serious
injury or death. If you have
questions on the use, care, or
suitability of this product for your
application, please
ULTRA-SAFE.
USER INSTRUCTION M NU L
MODEL: US-96760-120
DESCRIPTION:
Z US
This Owner's Manual should be used as part
of an employee training program as required
by OSH , and is intended to meet the
manufacturer's instructions as required by
NSI Z359.1
DESCRIPTION: The US-96760 Lifeline System
is designed for use as an anchoring means for
up to 4 persons, used where fall protection
and horizontal mobility are required. Per
OSHA regulations, horizontal lifelines shall be
designed, installed, and used under the
supervision of a qualified person as part of a
complete personal fall arrest system with a
minimum safety factor of 2. Qualified person
is defined as follows:
contact
"..one who, by possession of a recognized
degree, certificate, or professional standing,
or who by extensive knowledge, training, and
experience, has successfully demonstrated
his ability to solve or resolve problems
relating to the subject matter, the work, or the
project."
Refer to applicable national standards,
including ANSI Z359.1, local, state and federal
(OSHA 1910.66 & 1626.502) requirements, for
additional information on personal fall arrest
systems.
4 Person Horizontal System - Steel
SYSTEM REQUIREMENTS: The US-96760
Lifeline System is designed for use with only
ULTRA-SAFE approved components and sub
systems. Substitutions or replacements made
with
subsystems may jeopardize compatibility of
equipment and may affect the safety and
reliability of the complete system
Anchorage points for this system must be
capable of sustaining a static load in the
direction applied by the personal fall arrest
system of at least 5,000 lbs. Anchorages- must
be
deformations. When more than 1 personal fall
arrest system is attached to the same
structure, the strength requirements stated
above must be multiplied by the number of
personal fall arrest systems attached to the
structure.
LIMIT TIONS:
• Maximum of 240' system span with
• Maximum of 4 users (max 310#
1
non-approved components
rigid enough to prevent
maximum 60' intermediate
Span must be reduced
distance is inadequate to prevent
striking of lower floor.
each) at any point along system.
or
large
span.
if fall
313HS4