EuroGames Bumper Car Series Operation And Maintenance Handbook

Table of Contents

Quick Links

OPERATION AND MAINTENANCE HANDBOOK

EUROGAMES S.r.l. - Ed. 2015-06 -

No part of this document can be reproduced or transmitted to third parties by any means or in any form (either electronic or mechanical,

including photocopying, recording or data saving) for purposes other than the personal use without prior written authorisation of EuroGames

S.r.l.

Via degli scavi, 41 - 47122 Forlì (ITALY)

Tel. +39 0543 796665 Fax. +39 0543 722727

www.eurogames.it - info@eurogames.it

"BUMPER CAR"

"MINI BUMPER CAR"

Translation of the original instructions

Table of Contents

Need help?

Do you have a question about the Bumper Car Series and is the answer not in the manual?

Questions and answers

Summary of Contents for EuroGames Bumper Car Series

Page 1 No part of this document can be reproduced or transmitted to third parties by any means or in any form (either electronic or mechanical, including photocopying, recording or data saving) for purposes other than the personal use without prior written authorisation of EuroGames...
Page 3: Table Of Contents
Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR INDEX SCOPE OF THE MANUAL ....................... 4 GENERAL SAFETY PRECAUTIONS ....................5 DESCRIPTION OF THE MACHINE ....................6 SERIES AND MODELS........................6 TECHNICAL FEATURES ........................6 MANUFACTURER .........................
Page 4: Scope Of The Manual
Draws the attention to important general messages which affect neither safety nor the machine efficiency. If, after the reading, you are unsure about anything, contact Eurogames who will assure you a prompt and careful assistance to get the best performance and highest efficiency from your machine.
Page 5: General Safety Precautions
For this reason, any information of this manual could not match the technical features of the product itself completely. Eurogames S.r.l. does not incur in any obligation as far as updatings are concerned which will be included in future printings of this manual.
Page 6: Description Of The Machine
Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR 3. DESCRIPTION OF THE MACHINE The Automatic Games of the Eurogames “Bumper Car” series consist of a mini-vehicle fitted with a circular inflatable rubber dinghy. The Automatic Games manufactured by Eurogames develops a play, socialization, amusement, physical and psychic formation function.
Page 7: Manufacturer
Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR Technical data Height by Height Width Length Weight * Model open room (cm) (cm) (cm) (cm) (cm) SPACE BUMPER ~ 180 ICE BUMPER ~ 180 HYPER BUMPER...
Page 8: Functioning
Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR 9. FUNCTIONING The Automatic Games of the “Bumper car” series have been designed to be used in public places like game-halls, commercial centres, amusement parks, fun-fairs and public gardens with specific tracks for these vehicles.
Page 9 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR Preliminary operations Before starting the machine, carefully follow the steps below: Mounting and connecting the battery Follow these instructions as described and in the indicated sequence: 1.
Page 10 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR 3. Position the first battery 1 (Fig.2). ATTENTION It is possible to install 80 Ah batteries inserting the spacers B or 120 Ah batteries by removing the spacer B.
Page 11 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR Setting the speed The maximum speed must be set as a function of the size of the play area and of the type of players. Program the digital timer to set up the maximum speed (see “DIGITAL TIMER” section).The real race speed is adjustable by pushing more or less down the joysticks (Fig.4).
Page 12: Testing
Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR TESTING For the manufacturing, tests, controls and inspections of its Automatic Games, Eurogames adopts the criteria established by the international standards ISO 9000 for Quality Systems.
Page 13 ATTENTION All the Automatic Games of the “Bumper Car” series have an automatic system that varies gradually the speed with the aim to not allow sudden accelerations (it is an Eurogames’ exclusive). 5. If user has more than 6 years, but it is a minor must be followed visually by the parent or an adult who is responsible for the entire race time.
Page 14 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR Functions of the joysticks The “Bumper Car” Automatic Game is equipped with two joysticks placed at the right and left side of the driving position (Fig.7).
Page 15: Eg09 Timer
Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR EG09 TIMER Directions for Use The timer device displays the current remaining game time and the percentage of battery charge. If you press any of the three selection buttons (-, ENTER, +) it turns on the display light.
Page 16 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR “Main Menu” parameters The parameters included in the main menu are the following: (some are not modifiable) Time=000s Bat85% Time to end of game and battery charge level.
Page 17 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR Protected Menu” parameters The parameters included in the protected menu are the following: (some are not modifiable) T.Counter=000000 Total coins counter. This counter cannot be reset (read only).
Page 18 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR Pot1=128 -> +000 Joystick pot. control 1 reading value. Pot2=128 -> +000 Joystick pot. control 2 reading value. Pot Min=092 Pot. minimum value. See Joystick calibration procedure on User’s Manual.
Page 19 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR Connectors description Fig. 9 J1 - DESCRIPTION J2 - DESCRIPTION J1.1 DO NOT USE J2.1 Turn Lamp output 12/24v J1.2 Ground J2.2 Pot. 1 input J1.3 Speaker output J2.3...
Page 20: Wiring Diagram
Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR WIRING DIAGRAM Fig. 10...
Page 21: Remote Controller Eg-Tel8
Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR REMOTE CONTROLLER EG-TEL8 Keyboard description Key [START] [STOP]: These buttons can Start and Stop all the enabled products at the same time. For safety reason the Stop command is sent immediately.
Page 22: Remote Controller Eg09Tel
Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR REMOTE CONTROLLER EG09TEL Functions This remote control unit allow the remote configuration of products that mount the “EG09 Digital Timer”. “Wireless Coin”, “Start”, “Stop” or “game End” commands can be sent to all the products or to a single product.
Page 23 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR [PROG]: This button enable or disable the programming mode. ATTENTION Enter programming mode only when the machine is not in use. Using the remote control to check or alter parameter settings while the machine is in use may result in incorrect configurations and anomalous functioning.
Page 24 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR “Hyper Bumper” gaming system configuration To configure the “Hyper Bumper” gaming system (normally contained in the monitor casing) select the value 32 under “Device Selected” and press the [PROG] button. The configuration parameters will appear on the display.
Page 25: Battery Charger
Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR BATTERY CHARGER Technical features The battery charger consists of a painted, fireproof casing containing one to ten groups of the following elements: electric transformer, electronic card, power plug and power cord, to recharge a single “Bumper car”...
Page 26 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR To recharge the batteries of the “Bumper car” series Automatic Games, operate as it follows:  Act on selector (E) in relation to battery type to be recharged:...
Page 27: Maintenance
Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR The battery charger should not be tampered or modified by the user. The EuroGames  products meet the established standards. Repair works should be carried out only by specialized and authorized technicians.
Page 28: Cleaning
Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR CLEANING This operation must be carried out daily when the “Bumper car” is in the parking area. With a wet sponge or cloth and, if necessary, suitable house detergents clean only the external surface of the “Bumper car”, then dry.
Page 29 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR Changing the rubber dinghy To change the rubber dinghy do as follows: 1. Deflate the rubber dinghy removing the cap A and pushing on the red B valve (Fig. 20a). Push on the rubber dinghy to deflate it easier.
Page 30: Hyper Bumper" Display Contrast Setting
Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR Adjusting of the body’s supporting rubber blocks In some points of the frame are present the rubber blocks E (Fig.21). These have the aim to avoid the direct contact between the body and the iron frame.
Page 31: Joystick Calibration
Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR JOYSTICK CALIBRATION Enter the “Protect” menu.   Use the “+”button to scroll to the “Pot1” option. Keeping the Joystick 1 (right) in the centre position, ensure the value returned on the display is above 118 and below 138.
Page 32: Spare Parts Tables
Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR SPARE PARTS TABLES...
Page 33 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 34 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 35 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 36 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 37 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 38 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 39 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 40 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 41 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 42 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 43 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 44 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 45 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 46 Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 47 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR...
Page 48: Troubleshooting
Eurogames SRL – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR TROUBLESHOOTING 1 - The “Bumper Car” does not work. a - ensure the micro switch of the coin box is well connected and in efficient working order;...
Page 49: Warranty
Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR WARRANTY Eurogames S.r.l. offers a warranty of one year from the purchase date stated in the sale  document. The Manufacturer undertakes to make good by repair or replacement at its option any defect in ...
Page 50 : 25 February 2013 Signature of the legal representative of the company Eurogames S.r.l. Eurogames S.r.l. via degli Scavi, 41 Forlì (Italy) – Tel. 0543 796665 - Fax. 0543 722727 – Web Site: www.eurogames.it - E-mail: info@eurogames.it - P. I: 03624290403...
Page 51 Eurogames Srl – Operation and maintenance handbook – BUMPER CAR & MINI BUMPER CAR Via degli scavi, 41 - 47122 Forlì (ITALY) Tel. +39 0543 796665 Fax. +39 0543 722727 www.eurogames.it - info@eurogames.it...

This manual is also suitable for:

Mini bumper car Space bumper Ice bumper Hyper bumper