Advertisement

Quick Links

INSTRUCTION MANUAL
S700M MANUAL WORKSTATION
° Warranty
° Safety
° Operation
Sept 2015, Rev. 4.0
° Service Parts
° Troubleshooting Guide
° Contact Information
.
BECCA INC
1
Instruction Manual S700M
Manual Workstation

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the S700M and is the answer not in the manual?

Questions and answers

Summary of Contents for Becca S700M

  • Page 1 INSTRUCTION MANUAL S700M MANUAL WORKSTATION ° Warranty ° Service Parts ° Safety ° Troubleshooting Guide ° Operation ° Contact Information Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 2: Table Of Contents

    17-18 Control Head ......................Control Head Plumbing ..................Pump ........................Carbon Exhaust Unit ..................... PARTS DESCRIPTION ....................23-24 OPTIONAL TURBO700 INFORMATION……………………………………………. ………… 25-26 WARRANTY INFORMATION / TECHNICAL ASSISTANCE ......... Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 3: Warranty Information

    During months 1 through12 BECCA will repair or replace any component including labor that is found to be defective in material or workmanship as determined by BECCA factory certified service technician. For...
  • Page 4: Spray Gun Cleaner Specifications

    SPRAY GUN CLEANER SPECIFICATIONS SPECIFICATION FOR S700M MANUAL POWER CLEAN™ WORKSTATION SPRAY GUN CLEANER SPECIFICATIONS U.S. UNITS METRIC UNITS Weight 260 Lbs. 118 Kg Height 58" 1,450 mm Width 25" 625 mm Length 26" 650 mm Work Table Height 15"...
  • Page 5: Safety And Warning

    3. Check your equipment immediately to ensure that it is free of transport damage. Report any transport damage to the carrier without delay for possible claim procedures. Becca Recycling Technologies Inc. is not responsible for damage to equipment after it leaves our warehouse.
  • Page 6: General Safety Rules

    Cleaner. If in doubt, DO NOT plug in the unit. Using an air line with pressure less than the pressure specified on the nameplate is harmful to the pump. Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 7: Unit Use And Care

    Only trained repairmen should attempt (°) ALL REPAIRS, electrical or mechanical. Contact the nearest Becca repair service facility. Use only Becca replacement parts, any other parts may create a hazard.
  • Page 8 SAFETY IS A COMBINATION OF THE OPERATOR’S COMMON SENSE, THINK SAFETY! KNOWLEDGE OF THE SAFETY AND OPERATING INSTRUCTIONS AND ALERTNESS AT ALL TIMES WHEN THE UNIT IS BEING USED. Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 9: Introduction

    – The main air supply valve controls the air for the Spray Gun Cleaner. This valve should remain closed when not using the Spray Gun Cleaner. Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 10 You can also clean parts or spray guns with “Power Pistol” valve (e). When turning this valve on the POWERPISTOL will be activated helping to clean hard to reach areas. Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 11 Instruction Manual. When the CLEAN SOLVENT container becomes empty, exchange it with the one in the recycler compartment. Starting the distillation cycle will refill the pail again and again. Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 12 It is strictly forbidden to operate the Spray Gun Cleaner when even only one of these symbolic labels is missing from the point where the Manufacturer placed it.  Always use BECCA GENUINE REPLACEMENT PARTS during repair and maintenance. Sept 2015, Rev. 4.0...
  • Page 13: Troubleshooting Guide

    - The Pump is not Operating Manual Spray Nozzle is not - Check the nozzle by removing and operating. - Manual Spray Nozzle is clogged. blowing out debris (reverse direction) Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 14 825258K – Filtration Recycling System Cartridge Replacement Kit (50 & 100 Series Models) Solvent Models Only: 825244K – Filtration Recycling System Cartridge Replacement Kit (Solvent – Not 50 or 100 Series) Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 15: Maintenance Schedule

    Semi-Annually Change out “Used Solvent” Container. - Replace filter (824588) in back panel. - Replace Extractor/Dryer Compressed air filters (824016) - Replace BECCA Protect™ Maintenance Coating (ECP 831004) - Review Ground Clamp (823079) Annually - Replace Manual Flow Brush (824610) - Review &...
  • Page 16: Optional Solventwash Filter Change Instructions

    Housing before flowing out of the selected function. 7. Used Filters (are Hazardous until proven different) should be allowed to dry and then dispose per local jurisdiction requirements. You are ready to use your system! Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 17: Schematic Of Unit

    SCHEMATIC OF UNIT FLAMABLE FLAMABLE LIQUIDE LIQUIDE Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 18: Schematic Of Unit

    SCHEMATIC OF UNIT (cont’d) Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 19: Control Head

    … … … … … … … … … … … … … … … … … … … … … … … … … Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC … … Manual Workstation … …...
  • Page 20: Control Head Plumbing

    SCHEMATIC OF UNIT (cont’d) “USED” “CLEAN” Solvent Hose Solvent Hose (Black Nylon) (White Nylon) LEGEND Air - Blue Polyurethane Tube Solvent - White or Black Nylon Tube Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 21 SCHEMATIC OF UNIT (cont’d) Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 22: Carbon Exhaust Unit

    SCHEMATIC OF UNIT (cont’d) Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 23: Pump

    823152 PUSH-IN FITTING 824014 PRESSURE GAGE “Y” PUSH-IN FITTING 824557 Multiple Locations 824561 PRESSURE GAGE 824562 REGULATOR 824558 PUSH-IN FITTING Multiple Locations 823111 ELBOW 824549 PUMP 824549-R REBUILT PUMP Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 24 OPTIONAL CARBON EXHAUST UNIT OPTIONAL 824450-R CARBON REPLACEMENT UNIT OPTIONAL ACCESSORIES ECP - 5GAL 5 GALS / 20 LITERS SOLVENT CONTAINER BECCA PROTECT FILM 30” x 200’ Roll – PEEL ECP - 831004 AWAY FILM 832700K Decal Kit for S700M Sept 2015, Rev.
  • Page 25: Optional Turbo700 Information

    USED solvent to pre- clean and CLEAN solvent to Rinse Longer periods will cause rapid usage of the ‘Clean Solvent’. Note: (Pump system will move 1 gallon of solvent per minute) Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 26 FUME EXTRACTOR/HOSE AIR PURGE VALVE 824547 HOSE CLEANER USED/CLEAN SOLV VALVE 824636 CHECK VALVE ¼ » NPT FEMALE “T” 824637 ¼” NPT x 3/8” TUBE “T” 823134 All Other #’s SEE MAIN SCHEMATIC Sept 2015, Rev. 4.0 Instruction Manual S700M BECCA INC Manual Workstation...
  • Page 27: Warranty Information / Technical Assistance

    WARRANTY INFORMATION / TECHNICAL ASSISTANCE The Warranty of your system begins with the Certified Start-up by your local BECCA Distributor. Make sure this is completed and you receive a copy of the Certified Start-up document. For more information, prices or technical assistance, contact your local BECCA distributor or call / fax our BECCA Care™...

Table of Contents