Summary of Contents for Generac Power Systems DF 2.2
Page 1
Owner’s Manual DF 2.2 Dust Suppression System For technical assistance contact: Register your Generac product at: www.generacmobileproducts.com WWW.GENERAC.COM Technical Support 1-888-GENERAC 1-800-926-9768 (1-888-436-3722) SAVE THIS MANUAL FOR FUTURE REFERENCE...
Page 2
Individual operating habits and usage may contribute to the need for additional maintenance or service. WARNING CANCER AND REPRODUCTIVE HARM www.P65Warnings.ca.gov. (000393a) Owner’s Manual for DF 2.2 Dust Suppression System...
Table of Contents Section 1: Introduction and Safety Section 4: Maintenance and Troubleshooting Introduction ..............1 Read This Manual Thoroughly ........1 Daily Walk-Around Inspection ........9 How to Obtain Service ..........1 General Maintenance ...........9 Inspecting the Unit ............9 Safety Rules ..............1 Preparing for Service ...........9 Safety Symbols and Meanings ........1 Cleaning the Unit ............9 General Hazards ............2...
(000182a) CAUTION Equipment or property damage. Do not block air intake or restrict proper air flow. Doing so could result in unsafe operation or damage to unit. (000229) Owner’s Manual for DF 2.2 Dust Suppression System...
Equipment damage. Do not attempt to start or operate a unit in need of repair or scheduled maintenance. Doing so could result in serious injury, death, or equipment failure or damage. (000291) Owner’s Manual for DF 2.2 Dust Suppression System...
Page 8
Introduction and Safety This page intentionally left blank. Owner’s Manual for DF 2.2 Dust Suppression System...
Specifications are subject to change without notice. Refer to the product specification sheet for complete list. Component Locations 008844 008843 Figure 2-1. Component Locations Start Button Lifting Hook Water Connection Socket Nozzles Tilting Blower Handle Stop Button Water Filter Forklift Pockets Tilting Blower Knob Water Tap Owner’s Manual for DF 2.2 Dust Suppression System...
Table 1 - Recommended Shore Power Cable Size and Length Suggested Power Cables and Lengths 50 ft. (15.2 m) 10/3—(L5-20P – L5-20R) 100 ft. (30.5 m) 12/3—(5-15P – 5-15R) Owner’s Manual for DF 2.2 Dust Suppression System...
Personal injury. Only use water from controlled, reliable sources. Uncontrolled water could contain bacteria. Inhaling mist containing bacteria could result in death, or serious injury. (000584) 008852 Figure 3-2. Starting the Unit Owner’s Manual for DF 2.2 Dust Suppression System...
If wet, dry the unit thoroughly before starting. • Inspect condition of electrical cords. DO NOT use the unit if insulation is cut or worn through. • Verify the wheels and locking caster are present and in serviceable condition. Owner’s Manual for DF 2.2 Dust Suppression System...
ASD. Possible Cause Solution Problem Fan Doesn’t work Plug not correctly connected Verify plug is seated fully in socket. Nozzle Cleaning. Uneven water jet Dirty or clogged nozzles Clean nozzles. See Owner’s Manual for DF 2.2 Dust Suppression System...