Advertisement
ATTENTION: PLEASE READ AND UNDERSTAND ALL INSTRUCTIONS AND WARNINGS BEFORE ASSEMBLING, INSTALLING OR USING THIS PRODUCT.
Danger of explosion. Do not use this product for storing or
transporting flammables, explosives, hazardous materials, or
hazardous waste, such as containers of gasoline, solvents, gun
powder, dynamite, propane tanks, acetylene tanks and cutting
torches. This product is only intended and safe for use in storing
and transporting small tools, equipment and other similar materials.
Any modifications made to, or unintended use of this product,
could create a hazardous condition that can cause death, serious
personal injury or property damage.
Approximate Assembly and Installation Time:
60-80 min. (1 to 1.3 hours) depending on number of shelf
units and van equipment installation experience.
TOOLS REQUIRED
• Electric Drill
• Drill Bits: 13/32", 5/16", 1/8"
• Open End Wrenches: (2) 7/16", 9/16"
• 1" Hole Saw
D
A
IF YOU HAVE ANY QUESTIONS, PLEASE CONTACT US TOLL-FREE AT .800.456.7865
INSTALLATION MANUAL
DANGER
E
E
E
JUMBO VAN SHELVING
These instructions are to be followed using the parts and fasteners
supplied for proper installation. Any modifications or improper
installation of this product will create a hazardous condition that
can cause property damage, serious personal injury or death.
Any modification or unintended use of this product shall immediately
void all manufacturers warranties. Manufacturer disclaims all liability
for injuries to persons or property resulting from any modification
to, or unintended use of this product.
8380
8320
8381
8385
8332
8383
8391
8342
8384
8394
8352
8390
8395
8393
2
2
2
0
0
2
8
12
12
2
2
2
2
3
3
#32-0162
#32-0162
#32-0163
D
A
B
C
PAGE
WARNING
– NOTICE –
8345
8957
Parts List
8958
8959
2
A
Floor Mounting Brackets
0
B
Center Supports
0
C
Shelf Dividers
2
D
End Panels
0
E
Shelves
Bolt Kit
#32-0183
24-0245 REV. A 07/06
Advertisement
Table of Contents
Related Manuals for Weather Guard JUMBO VAN SHELVING
Summary of Contents for Weather Guard JUMBO VAN SHELVING
- Page 1 INSTALLATION MANUAL JUMBO VAN SHELVING ATTENTION: PLEASE READ AND UNDERSTAND ALL INSTRUCTIONS AND WARNINGS BEFORE ASSEMBLING, INSTALLING OR USING THIS PRODUCT. DANGER WARNING These instructions are to be followed using the parts and fasteners supplied for proper installation. Any modifications or improper installation of this product will create a hazardous condition that Danger of explosion.
- Page 2 BOLT KIT #32-062 BOLT KIT #32-063 BOLT KIT #32-083 NOTE: Depending on your application you may end up DESCRIPTION with extra hardware after installation is complete. QTY. QTY. QTY. Mounting Straps Mounting Strap Angles 1/4" Lock Washers 1/4-20 Blind Fasteners 1/4-20 x 5/8"...
- Page 3 CAUTION WARNING All floor mounting bolts near the fuel tank area should be installed Prior to drilling, so as not to cut or puncture fuel tanks, fuel lines, from the underside of the vehicle, to guard against the fuel tank brake lines, electric wires, etc., check behind or underneath drilling being punctured in the event of a collision.
- Page 4 Place the unit into your selected position in the van, as close to the wall as possible. Mark the four floor mounting holes where the Floor Mounting Bracket comes in contact with the floor ribs. NOTE: 60" & 69" SHELF UNITS: Center Support Legs have been added to these units to strengthen these shelves because of their length.
- Page 5 Three (3) Mounting Straps and Mounting Strap Angles are provided. The Mounting Straps can be bent to any shape and/or used with the Mounting Angles. The Mounting Straps should be attached to the upper portion of the shelf unit in a manner that would minimize movement of the unit both front to rear and side to side.
- Page 6 Make sure the Blind Fastener and Installation Tool do not turn during installation. Blind Fastener WEATHER GUARD ® products are protected by one or more of the following trademarks: U.S. 842268, 1661625, 1663369, 2228051, 2362167; Canada - 282725; U.K. - 1400720; N.Z. - 296049; Aus.- 761964 IF YOU HAVE ANY QUESTIONS, PLEASE CONTACT US TOLL-FREE AT .800.456.7865...
Need help?
Do you have a question about the JUMBO VAN SHELVING and is the answer not in the manual?
Questions and answers