GARDEN MASTER Bio-Logic Elite 7100 Owner's Manual

Aerated wastewater treatment system

Hide thumbs

Table Of Contents

Table of Contents

Quick Links

garden

Master

Waste Water

Treatment System

Owner's Manual

Table of Contents

Summary of Contents for GARDEN MASTER Bio-Logic Elite 7100

Page 1 garden Master Waste Water Treatment System Owner’s Manual...
Page 2 Thank you for purchasing the Garden Master “Elite” Aerated Wastewater Treatment System (AWTS). Your Garden Master AWTS is fully automatic in operation and requires little owner intervention to ensure years of service. It is useful that the owner/operator of the system understand some of the broad concepts of the system operation.
Page 3: Table Of Contents
garden Contents Master Pre Installation Information ....................1 Installation Instructions ......................2 Excavation Dimensions ......................3 Electrical Circuit Details ...................... 4 System Operation........................5 Monitoring Process ......................... 6 Service & Support ........................7 Maintaining your Gardenmaster ..................8 Conserving Water ........................9 Fault Finding ..........................
Page 4: Pre Installation Information
The specific purpose of your Garden Master AWTS is to ensure that all waste water is correctly treated before it is returned to the water cycle. Domestic Waste Water By statutory requirement all water used in a domestic situation is required to be collected and treated before it is returned to the water cycle.
Page 5: Installation Instructions
Ensure the Excavation is solid and level. Screed a 50mm base of crusher dust or sand. Place the Garden Master 7100 into the excavation, lifting only using the 4 x swift lift lugs located in the bottom of the tank.
Page 6: Excavation Dimensions
garden Excavation Detail for your AERATED Master TREATMENT SYSTEM PLEASE NOTE: Please ensure that a minimum of 50mm of tank plus lids is above ground. Wastewater Australia Pty Ltd ABN: 84 134 670 796 321 New England Highway Rutherford NSW 2320 Telephone: 1800 480 322 | Email: mail@gardenmaster.com.au www.gardenmaster.com.au...
Page 7: Electrical Circuit Details
Be sure to return the alarm to “NORMAL” after the alarm has reset. Alarm Panel: If the alarm panel is more than 30 metres away from the Garden Master control box use shielded cable for SW to alarm panel to avoid any induced voltage from active cable.
Page 8: System Operation
garden System Operation of your AERATED Master TREATMENT SYSTEM Primary Chamber Influent enters the chamber via the source whereby scum and solids capable of settling are separated from the raw influent. Primary treated effluent flows through a transfer port to the aeration tank. This tank will also act as a storage chamber for sludge returned via the Clarification Chamber.
Page 9: Monitoring Process
Irrigation - Designated Land Application System Your Garden Master AWTS has been designed to treat the effluent to achieve the best possible quality water before discharge back into the environment. The designated irrigation area is an integral part of your Garden Master system and is designed to accommodate the predicted flow rate of wastewater at the time of system approval.
Page 10: Service & Support
TREATMENT SYSTEM Garden Master Servicing Garden Master are committed to servicing and supporting you long after your tank has been installed. For your system to maintain its high-level performance, NSW Health requires that it is serviced every three months. During this service, our team provides comprehensive checks and tests to ensure you get the most out of your system.
Page 11: Maintaining Your Gardenmaster
Maintenance of your AERATED Master TREATMENT SYSTEM Because your Garden Master is fully automatic there is no need for the owner to be concerned. However there are some simple precautions to observe. DO’s DON’Ts • • Do not use harsh cleaners such as bleaches and Avoid using strong acids, alkalis, oils and chemicals anti-bacterial products.
Page 12: Conserving Water
garden Conserving Water with your AERATED Master TREATMENT SYSTEM Water conservation is very important for septic systems because continual saturation of the soil can affect the quality of the soil and its ability to naturally remove toxics, bacteria, viruses, and other pollutants from the wastewater.
Page 13: Fault Finding
Master TREATMENT SYSTEM To ensure the most effective operation of your Garden Master AWTS system you should familiarise yourself with the contents of this manual. The Garden Master AWTS has been designed to include additional safety margins and minor mishaps and normal household usage will not usually affect the operation of the system.
Page 14: The House Alarm
The alarm light will only be displayed if a fault is located. In the unlikely event that this occurs, press the switch in the centre of the plate to mute the alarm buzzer. The light will continue to stay on until a Garden Master technician rectifies the problem.
Page 15: Planting In Irrigation Area
garden Irrigation Area for your AERATED Master TREATMENT SYSTEM Your irrigation / disposal area will operate more efficiently and have less wet areas if covered with vegetation. The following is a list of some of the plants and shrubs that are suitable for planting in wet conditions.
Page 16 For your family friendly wastewater system Call 1800 480 322 www.gardenmaster.com.au 321 New England Highway Rutherford, NSW 2320 Fax : 02 4932 1055 Email: mail@gardenmaster.com.au...