Table of Contents
Advertisement
Advertisement
Table of Contents
Summary of Contents for RAMVAC Badger LF
- Page 1 Badger LF User Manual...
-
Page 2: Table Of Contents
Table of Contents Section I Introduction Classifications ......................2 Safety Information......................2 Explanation of Signs and Symbols................3 Specifications ....................... 3 Packaging........................4 Section II Installation Product Features......................5 Vacuum and Drain Plumbing ..................6 Drain Valve Plumbing Options.................. 7-9 Electrical ........................10 Muffler Installation.................... -
Page 3: Section I Introduction
Here’s what you need to do to insure the safety dental vacuum system. potential of this equipment is achieved: The main purpose of the Badger LF is to provide a positive displacement, oil-less dry vacuum • Make sure your equipment is installed ac-... -
Page 4: Explanation Of Signs And Symbols
Section I Introduction WARNING Explanation of Signs & Symbols Do not modify the Badger LF without = Caution permission from RAMVAC. Modification will void = Warning the warranty and could result in serious injury. = Biohazard NOTICE = Hot Surfaces... -
Page 5: Packaging
Lifting points Use 7/16" wrench to Lifting point remove nut and washer from both sides of pallet 5. Verify additional parts shipped with the Badger LF Vacuum Unit for use at installation: • Installation Kit • SlugBuster Starter Pack •... -
Page 6: Section Ii Installation
Section II Installation Product Features Exhaust Tank Inlet Tank Outlet Separation Tank Vacuum Gauge E2 Control Belt Guard Drain Check Valve Pump Motor Exhaust Drain Solenoid Valve Drain Power Conduit Whip Slide Valve www.DentalEZ.com www.DentalEZ.com 866-DTE-INFO (opt 4) -
Page 7: Vacuum And Drain Plumbing
- 1-1/2” PVC Schedule 40 with DWV fittings. - Min. slope ¼” per 10 ft (2 mm per 1m). - Use only RAMVAC supplied 1 -1/2” drain check valve. • Trap and Drain Branch -Trap and drain branch line 2 sizes larger than waste pipe. -
Page 8: Drain Valve Plumbing Options
Section II Installation Drain Valve Plumbing Options 27.25" 10" 80˚ www.DentalEZ.com www.DentalEZ.com 866-DTE-INFO (opt 4) - Page 9 Section II Installation Badger LF User Manual 20.5" 3.25" www.DentalEZ.com www.DentalEZ.com 866-DTE-INFO (opt 4)
- Page 10 Section II Installation 20.5" 3.25" www.DentalEZ.com www.DentalEZ.com 866-DTE-INFO (opt 4)
-
Page 11: Electrical
Section II Installation Badger LF User Manual Electrical WARNING WARNING This device should only be installed by licensed Electrical shock could occur as a result of electrical and plumbing contractors to all appli- improper grounding. This product must be cable federal, state or local building codes. -
Page 12: Muffler Installation
Section II Installation Muffler Installation Tools needed: • 5/16” nut driver or flathead screwdriver WARNING To prevent any chance of electrical shock, always disconnect power when indicated. 1. To install the muffler assembly, slide the assembly all the way down onto the pre-installed silencer. -
Page 13: Exhaust Plumbing
2. Locate inconspicuously for sight and sound. NOTICE 3. Locate to prevent exhaust from entering building. Run Dedicated Exhaust Lines for each RAMVAC unit installed. DO NOT connect to plumbing vents. Outside Wall NOTICE Support loosely. DO NOT allowing piping to touch ductwork. -
Page 14: Section Iii Operation
Section III Operation E2 Control Features • Maintenance Light – Yellow light is on when • Status Lights preventive maintenance is due. • Power Status – Green light is on when line • Provides 24v DC low voltage signal to the re- voltage is present. -
Page 15: Turning The System On/Off
Badger LF User Manual Turning the System On/Off Vacuum Level The vacuum level of the Badger LF is factory set NOTICE at 7 inch Hg (when all HVEs and SEs are closed). Make sure all HVEs and saliva ejectors are Do not increase vacuum level above 12 inch Hg. -
Page 16: Section Iv Care
SlugBuster. routinely and clean when dirty. Powder 6 Pack: six 40 oz. containers of 1. Just before turning off the RAMVAC, rinse vac- 900146 SlugBuster (makes 480 gallons of solution) uum lines first with hot water - approximately... -
Page 17: Cleaning The Vacuum Unit
Section IV Care Badger LF User Manual Cleaning the Vacuum Unit Pump Head Exchange CAUTION NOTICE Some parts/components on the A detailed instruction sheet will be sent with vacuum unit get hot during operation. the replacement pump. Provide the equipment ample time to NOTE: Inspect pump head every 1,000 hours. -
Page 18: Section V User Service Information
Section V User Service Information TROUBLESHOOTING Symptom Possible Cause(s) Corrective Action Tank drain check valve blocked open Clean tank drain check valve Clogged vacuum line Locate and remove clog Low or No Vacuum Vacuum controller stuck open Repair and replace vacuum controller (motor running okay) Vacuum leaks Locate and fix leak... -
Page 19: Section Vi Electrical Connections
Section VI Electrical Connections Badger LF User Manual Vacuum Power Motor (230v 1 phase) Ground L1 - BLACK L2 - RED GROUND - GREEN/YELLOW www.DentalEZ.com www.DentalEZ.com 866-DTE-INFO (opt 4) -
Page 20: Section Vii System Schematics
Section VII System Schematics Vacuum devices Breaker Disconnect Remote 2” Dedicated Switch Exhaust to outside Tank Drain www.DentalEZ.com www.DentalEZ.com 866-DTE-INFO (opt 4) -
Page 21: Section Viii Parts List/Diagrams
Section VIII Parts List/Diagrams Badger LF User Manual Rotate clockwise and lift to access filter Regular Maintenance Kit Recommended Part/Kit Name Part /Kit No. Maintenance Interval Rotate clockwise and Belt 39" 8801-003 Every 5 Years lift to access filter Filter Set... -
Page 22: Mechanical Replacement Parts Kits
Cover Kit Part/Kit Name Part/Kit No. See chart to right NEW Pump Kit 8801-006 Rear Pump Fan 8801-013 Re-manufactured Pump Kit 8801-006RM Cover Kit Motor Kit 8801-014 Muffler Kit 8801-029 RAMVAC Green 004288 Touch-up Paint www.DentalEZ.com www.DentalEZ.com 866-DTE-INFO (opt 4) -
Page 23: Electrical Replacement Parts Kits
Section VIII Parts List/Diagrams Badger LF User Manual Electrical Replacement Parts Kits Part /Kit Name Part/Kit No. Tank Float Kit 004612SP Complete E2 Control Kit 8801-019 E2 Control Board Kit 8801-015 E2 LED Display Kit 8801-016 E2 Hour Meter 8801-020... -
Page 24: Limited Warranty
We are not responsible for shipping damages. We will, however, help you file a claim with the freight carrier. Written repair estimates are available. DentalEZ warrants the Badger LF to be free of defects in material and workmanship, under normal usage under the following terms. Warranty Period 2 years or 4,000 hours (whichever comes first) for the Dental Vacuum System excluding normal wear parts, which includes all filters and belts. -
Page 25: Emc Information
Immunity of the RAMVAC Badger LF. The RAMVAC Badger LF should not be used adjacent to or stacked with other equipment and that if adjacent or stacked use is necessary, the RAMVAC Badger LF should be observed to verify normal operation in the configuration in which it will be used. - Page 26 GUIDANCE AND MANUFACTURER’S DECLARATION – ELECTROMAGNETIC IMMUNITY The Badger LF is intended for use in the electromagnetic environment specified below. The customer or the user of the Badger LF should assure that it is used in such an environment.
- Page 27 2500 Highway 31 South Bay Minette, Alabama 36507 866-DTE-INFO (opt 4) www.dentalez.com © DentalEZ® Alabama, Inc. Printed in USA PN: 7717-001C August, 2017...
Need help?
Do you have a question about the Badger LF and is the answer not in the manual?
Questions and answers