Download
Share
Print this page
  1. Manuals
  2. Brands
  3. AG SPRAY Manuals
  4. Ultrasonic Jewelry Cleaner
  5. TR500PHS
  6. Owner's manual

AG SPRAY TR500PHS Owner's Manual

500 gallon poultry house cleaner
Hide thumbs

Advertisement

Quick Links

Download this manual
OWNER'S MANUAL
TR500PHS
500 Gallon Poultry House Cleaner
1

Advertisement

loading
Need help?

Need help?

Do you have a question about the TR500PHS and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for AG SPRAY TR500PHS

  • Page 1 OWNER’S MANUAL TR500PHS 500 Gallon Poultry House Cleaner...
  • Page 2 Also, the TR500PHS is built with a boom jet nozzle that will clean the ceiling and is located on the very back and in the center of the sprayer so that it is easy to change the direction of the spray.
  • Page 3 Before starting work, analyze the area to determine the best – and safest – operating procedure. Plan your travel straight forward, whenever possible. Avoid sharp turns at high speeds. TR500PHS comes equipped with slip resistant steps for use when loading water or chemicals. Always use them when mounting or dismounting.

  • Page 4: Operating Procedures

    The Diaphragm Pump requires 20 h.p. min. Your tractor should have 25-30 horsepower available on the PTO shaft. It also needs to have the ability to stop the TR500PHS when full of water. A small tractor is more maneuverable in a poultry house. We recommend using a tractor with a 45 to 60 HP available on the PTO.
  • Page 5 PTO COMPONENTS COMPLETE PTO SHAFT ASSEMBLY DS13854037 Part # YOKE AND TUBE ASSEMBLY - FEMALE YOKE AND BAR ASSEMBLY - MALE...
  • Page 6 Pre-Start Conditions A. Check that the tank is full if using water only, half full if you are to add chemicals. B. Check that the PTO shaft and attached pump shaft turns freely by hand (DO NOT attach PTO shaft or operate the pump if the pump does not turn freely by hand because it may be locked up and may cause serious injury).
  • Page 7 TR500PHS Specifications 500 Gallon Polyethylene Tank It comes with: A. Large fill cap for easy fill and chemical mixing B. Rectangular sump with the tank drained through the strainer drain...
  • Page 8 Spray Booms All nozzles have individual valve cutoffs for differing spray patterns. Center vertical boom – cluster nozzle (20 GPM with a 20 ft. radius range) creates a circular spray pattern generally used to clean the rafters, but in the inverted position and at reduced pressure (100 psi) can be used to disinfect the floor.

  • Page 26: Pressure Regulator

    Pressure Regulator...