(Figure 5) to the chassis. Discard the rear bumper. REAR BUMPER HEX HEAD BOLT Figure 5. Rear Bumper Removal DIS185SSI4F AIR COMPRESSOR — HOSE REEL INSTALLATION INSTRUCTIONS P/N EE60468 — REV. #0 (04/16/18) — PAGE 4...
Page 5
(Figure 7) on the fuel tank side of the air compressor. Disconnect the tail light and set it and the rubber seal aside. TAIL LIGHT RUBBER SEAL Figure 7. Tail Light Removal DIS185SSI4F AIR COMPRESSOR — HOSE REEL INSTALLATION INSTRUCTIONS P/N EE60468 — REV. #0 (04/16/18) — PAGE 5...
Page 6
#2–8 on the battery side of the air compressor. DO NOT remove the battery-side tail light! The battery-side electrical wiring can be accessed by opening the cabinet door. DIS185SSI4F AIR COMPRESSOR — HOSE REEL INSTALLATION INSTRUCTIONS P/N EE60468 — REV. #0 (04/16/18) — PAGE 6...
Page 7
Figure 12. Bumper Stop Installation 2. If installing the dual hose reel kit (P/N MQPDUALREEL50), repeat step #1 on the battery side of the air compressor. DIS185SSI4F AIR COMPRESSOR — HOSE REEL INSTALLATION INSTRUCTIONS P/N EE60468 — REV. #0 (04/16/18) — PAGE 7...
Page 9
7. If installing the dual hose reel kit (P/N MQPDUALREEL50), repeat steps #1–6 with the left pivot base (P/N 59273) on the battery side of the air compressor. DIS185SSI4F AIR COMPRESSOR — HOSE REEL INSTALLATION INSTRUCTIONS P/N EE60468 — REV. #0 (04/16/18) — PAGE 9...
M4-0.7 × 12 mm screws (P/N 28922-083) and two M4 hex nuts (P/N 32664) PIVOT BASE See Figure 22. P/N 59272 Figure 23. Reel Mount Installation DIS185SSI4F AIR COMPRESSOR — HOSE REEL INSTALLATION INSTRUCTIONS P/N EE60468 — REV. #0 (04/16/18) — PAGE 10...
Page 11
(P/N 59275). Align the pin in the center of the reel (Figure 25). mount lock latch with the hole in the reel mount. See Figure 25. DIS185SSI4F AIR COMPRESSOR — HOSE REEL INSTALLATION INSTRUCTIONS P/N EE60468 — REV. #0 (04/16/18) — PAGE 11...
(P/N 59290) inside the storage compartment as shown in Figure 36. If installing the dual hose reel kit (P/N MQPDUALREEL50), place three ballast plates inside the storage compartment. DIS185SSI4F AIR COMPRESSOR — HOSE REEL INSTALLATION INSTRUCTIONS P/N EE60468 — REV. #0 (04/16/18) — PAGE 15...