Prince Castle Product Holding Bin Operation Manual

Hide thumbs

Table Of Contents

Table of Contents

Quick Links

Operation

Manual

Pan and Cover

Power On/Off Switch

LIMITED WARRANTY

This product is warranted to be free from defects in material and/or

workmanship for a period of 2 years from date of original installation, not

to exceed 30 months from the date of manufacture.

Any component which proves to be faulty in material and/or workmanship

will be replaced or repaired (at the option of Prince Castle, Inc.) without

cost to the customer for parts and labor. This warranty covers on-location

service (i.e. trip charges and/or mileage). Travel mileage is limited to 100

miles (200 Kilometers) round trip (one trip warranty) from an authorized

service agency or its sub-service agency.

This warranty is subject to the following exceptions/conditions:

• Use of any non-genuine Prince Castle parts voids this warranty.

• All labor to be performed during regular work hours. Overtime premium

(the incremental amount) will be charged to the customer.

• Damage caused by carelessness, neglect and/or abuse (e.g.,

dropping, tampering or altering parts, equipment damaged in shipment,

by fire, flood or an act of God) is not covered under this warranty.

• All problems due to operation at voltages other than that specified on

equipment nameplates are not covered by this warranty. Conversion to

correct voltage is the customer's responsibility.

• This equipment must be serviced by Prince Castle Authorized Service

Agency or a Prince Castle Service Technician during the warranty

period.

Note: When connected to the kitchen minder, the transfer and

daypart function is disabled on the button bar.

541-531revD-EN

Product Identification

Button Bar

PRINCE CASTLE

LOGO Button

LED Timers (tri-color)

(qty. 8, each side)

Temperature Control Panel

Product Identification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Cleaning. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Programming . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 – 9

CastleNet

Factory Presets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Exploded View and Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

355 East Kehoe Blvd. • Carol Stream, IL 60188 USA

Telephone: 630-462-8800 • Toll Free: 1-800-PCASTLE

Fax: 630-462-1460 • www.princecastle.com

Product Holding Bin

Upper Pan Displays

(qty. 4, each side)

Transfer Button

Lower Pan Displays

(qty. 4, each side)

TRANSFER

UP and DOWN

Arrow Buttons

Pan Buttons (qty. 8)

MENU/ENTER Button

TABLE OF CONTENTS

Communications Network . . . . . . . . . . . . . . . . . . . . . . .

DHB-BK41/43

BKFT (Breakfast) LED

BKFT

REG

ENTER

REG (Regular Menu) LED

Table of Contents

Summary of Contents for Prince Castle Product Holding Bin

Page 1 Installation ..........will be replaced or repaired (at the option of Prince Castle, Inc.) without Operation .
Page 2: Safety Information
Retro Bun Timer Prince Castle reserves the right to change specifications and product design without notice. Such revisions do not entitle the buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Printed in USA 10/10 © 2010...
Page 3: Operation
Product Holding Bin DHB-BK41/43 Operation Turn power On/Off switch to ON position. Press all PAN buttons. Load pan covers (if used) onto pan racks and insert racks into the unit. Allow 30 minutes for heaters to reach operating The PAN displays will show the BKFT (Breakfast) or REG temperature.
Page 4: Setting The Temperature
Product Holding Bin DHB-BK41/43 Operation (continued) To shut down the unit, turn the power On/Off switch to OFF. NOTE: To load preset times/menus: A. Turn power switch to OFF. B. Press and hold both the UP and DOWN Arrow buttons.
Page 5: Calibrating Heaters
CASTLE LOGO button for 5 seconds. The Program LED will light. Press the UP or DOWN Arrow button until the desired setpoint Press the PRINCE CASTLE LOGO button to save the new temperature is displayed. setpoint value. Repeat steps 2 – 5 to change the setpoint for any other heater.
Page 6: Selecting Breakfast And Regular Menus
When scrolling, menu numbers appear in this display. Programming the Menus Press and hold the PRINCE CASTLE LOGO button (on the Press and hold the MENU/ENTER button. The display next to button bar) until all the displays show PROG and the PAN the MENU/ENTER button will show the menu choices.
Page 7: Changing The Hold And Cook-More Times
A. The SET PRODUCT TIME menu is used to change the Hold and Cook-More times. B. Press and hold the PRINCE CASTLE LOGO button, then immediately press and hold the MENU/ENTER button until the display shows one of the programming menus.
Page 8: Changing Product Names
A. The EDIT PRODUCT NAME menu is used to change a default product name to one of your own choosing. B. Press and hold the PRINCE CASTLE LOGO button, then immediately press and hold the MENU/ENTER button until the display shows one of the programming menus.
Page 9: Product Linking
A. The SET MAXIMUM TRANSFER TIME menu is used to set the amount of time allowed to make a product transfer from one pan to another. B. Press and hold the PRINCE CASTLE LOGO button, then immediately press and hold the MENU/ENTER button until the display shows one of the programming menus.
Page 10: Castlenet ® Communications Network
Communications Network ® Telephone jack plugs are located on the back of the unit. Connect The Prince Castle DHB-BK Bins, Retro Bun Timer, and New Bun the units using the cables provided as shown here. ® Cabinet Timers can be inter-connected to form the CastleNet Communication Network.
Page 11: Factory Presets
Product Holding Bin DHB-BK41/43 Factory Presets Product Menu Details Product Display Name Hold Minutes Cook-More Minutes Eggs EGGS Biscuits BISC Sausage SAUS French Toast FR-T Fish FISH Chicken Crisp CRSP Chicken Patty CHKN Chicken Tenders TEND Burgers BURG Whoppers WHPR...
Page 12: Troubleshooting
Product Holding Bin DHB-BK41/43 Troubleshooting PROBLEM PROBABLE CAUSE SOLUTION Display flashes Open relay. Circuit inoperable. Replace power circuit board. Display flashes Shorted relay. Circuit inoperable. Replace power circuit board. Open heater. Test heater resistance (150.2 Ohms). Replace heater if necessary.
Page 13: Exploded View And Parts List
Product Holding Bin DHB-BK41/43 Exploded View and Parts List Ref. Part No. Description Ref. Part No. Description 542-154S Heater Assy Kit (Upper) 541-802S Main PCB Kit 542-153S Heater Assy Kit (Lower) 78-184S Lighted Rocker Switch 88-600-200S Fuse Kit (Pkg of 10) (Fuse on Main PCB)
Page 14: Wiring Diagram
Product Holding Bin DHB-BK41/43 Wiring Diagram SPKR MAIN2 MAIN1 INPU T MAIN EXTRA TIMER EXTRA EXBB AUX2 AUX1 UPPER HEATER GRN/YEL LOWER SPKR HEATER GRN/YEL IN/WHT OUT/BLK EXTRA/BLU UPPER SPKR HEATER GRN/YEL LOWER HEATER GRN/YEL RIBBON J16 0 UPPER CABLE...

This manual is also suitable for:

Dhb-bk41/43