Summary of Contents for RADWAG DJ-04
- Page 1 Antistatic Ionizer DJ-04 Ionizer DJ-05 Ionizer USER MANUAL IMMU-48-04-11-18-EN www.radwag.com...
- Page 2 NOVEMBER 2018...
-
Page 3: Table Of Contents
Contents GENERAL INFORMATION TECHNICAL SPECIFICATIONS BASIC SAFETY PRECAUTIONS MECHANICAL DESIGN OF DJ-04 and DJ-05 IONIZERS UNPACKING 5.1. Unpacking START-UP 6.1. Operation MAINTENANCE, SERVICE, RECYCLING 7.1. Maintenance 7.2. Service 7.3. Recycling DECLARATION OF CONFORMITY... -
Page 4: General Information
1. GENERAL INFORMATION Antistatic ionizer is a device that removes excess of ions, both positive (cations) and negative (anions), from the sample, weighing device's components and the environment. Ionization is an operation aiming to neutralize electric charge of air molecules in order to restore quasi-balance of positive and negative ions. -
Page 5: Basic Safety Precautions
3. BASIC SAFETY PRECAUTIONS WARNING Air ionizer must be operated as an accessory of electronic balances, exclusively. The ionizer cannot be used with other devices. Under no circumstances should the ionizer be used in a hazardous area where there is any risk of explosion. The air ionizer is not intended to be operated in EX zones. - Page 6 The ionizer when not operated must be disconnected from the mains. Any repairs to be done must be carried out by service authorized by RADWAG. CAUTION It is forbidden to connect ionizer that is broken to the mains – this may result with either electrocution or fire.
-
Page 7: Mechanical Design Of Dj-04 And Dj-05 Ionizers
4. MECHANICAL DESIGN OF DJ-04 and DJ-05 IONIZERS The ionizer comprises two modules (see the figure below) and power supply: 1 – ionizing unit, 2 – high-voltage generator, 3 – power supply. 5. UNPACKING 5.1. Unpacking Unpack the device, remove protective foam, next carefully remove the antistatic ionizer from the box and place it at its workstation. -
Page 8: Maintenance, Service, Recycling
7.1. Maintenance Power supply housing and ionizing unit can be cleaned using cloth soaked with alcohol- based substance. 7.2. Service Only authorized RADWAG service points are allowed to disassembly, repair and modify the ionizer. It is recommended to: • subject the ionizer to technical inspection after 500 hours of operation, •... -
Page 9: Declaration Of Conformity
8. DECLARATION OF CONFORMITY...