1. Manuals
  2. Brands
  3. Air Lift Manuals
  4. Test Equipment
  5. 75687
  6. Installation manual

Air Lift 75687 Installation Manual

Scion tc rear application
Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
Kit 75687
Scion tc
rear application
INSTALLATION GUIDE
For maximum effectiveness and safety,
please read these instructions completely
before proceeding with installation.
Failure to read these instructions can result in an
incorrect installation.

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 75687 and is the answer not in the manual?

Questions and answers

Summary of Contents for Air Lift 75687

  • Page 1 Kit 75687 Scion tc rear application INSTALLATION GUIDE For maximum effectiveness and safety, please read these instructions completely before proceeding with installation. Failure to read these instructions can result in an incorrect installation.

  • Page 3: Table Of Contents

    Tools List ............3 Installing the Air Lift Performance Kit . . . . . . . . . . . . . . 4 Preparing the Vehicle .

  • Page 4: Introduction

    Air Lift Company reserves the right to make changes and improvements to its products and publications at any time. For the latest version of this manual, contact Air Lift Company at (800) 248-0892 or visit our website at www.airliftcompany.com.

  • Page 5: Installation Diagram

    Stock Bushing Sleeve ......2 Stock Upper Mount ......2 Stock Top Bushing ......2 Stock Top Washer ......2 18495 M10 X 1.5”, Nyloc Nut ......2 Missing or damaged parts? Call Air Lift customer STOP! service at (800) 248-0892 for a replacement part. MN-717...

  • Page 6: Installing The Air Lift Performance Kit

    Air Lift Performance Installing the Air Lift Performance Kit PREPARING THE VEHICLE 1. Remove the tonneau cover and floor matting from the trunk compartment. Fold the rear seats flat. 2. Unclip the plastic tabs on the tie hooks on the floor behind the rear seat. Remove the bolts underneath the clip and remove deck floor.
  • Page 7 Air Lift Performance 3. Unbolt the lower shock mount and remove bolt (fig. 3) fig. 3 4. Inside the trunk, unthread the three upper mount nuts (fig. 4). fig. 4 5. Clear the shock eye from its mount toward the stabilizer bar end link and remove the assembly.

  • Page 8: Stock Upper Mount Removal And Install

    Air Lift Performance STOCK UPPER MOUNT REMOVAL AND INSTALL 1. Secure the shock assembly into a coil spring compressor and compress the spring. 2. Insert a hex wrench into the end of the shock rod, unthread nut from rod. 3. Slowly remove pressure from the assembly and remove upper bracket, bushings, bushing sleeve and washers.

  • Page 9: Aligning The Vehicle

    Air Lift Performance fig. 5 ALIGNING THE VEHICLE 1. Using the control system, set the vehicle height to the new custom ride height. 2. If the new custom ride height is lower than stock, we recommend loosening all pivot points (bolts, nuts) on any control arm, strut arm or radius rod that contains bushings.

  • Page 10: Before Operating

    2. Next, completely deflate and reinflate the air bags 2-3 times. This procedure will purge any trapped air in the dampers and allow for maximum performance. For ride performance and the most versatility, Air Lift recommends setting the strut dial (if equipped) to position 6 or higher.

  • Page 11: Installation Checklist

    If a heat shield was included in the kit, install it. If there is no heat shield, but one is required, call Air Lift customer service at (800) 248-0892.  Fastener test — Recheck all bolts for proper torque.

  • Page 12: Product Use, Maintenance And Servicing

    4. Look for a kink or fold in the air line. Reroute as needed. If the preceding steps do not solve the problem, it is possibly caused by a failed air spring — either a factory defect or an operating problem. Please call Air Lift at (800) 248-0892 for assistance. MN-717...

  • Page 13: Frequently Asked Questions

    Q . Will installing air springs increase the weight ratings of a vehicle? No. Adding air springs will not change the weight ratings (GAWR, GCWR and/or GVWR) of a vehicle. Exceeding the GVWR is dangerous and voids the Air Lift warranty. Q . How long should air springs last? If the air springs are properly installed and maintained they can last indefinitely.

  • Page 14: Warranty & Returns Policy

    Reinstall by hand tightening as much as possible and then use a wrench for an additional two turns. 2. If the preceding steps have not resolved the problem, call Air Lift customer service at (800) 248-0892. Replacement Part Information If replacement parts are needed, contact the local dealer or call Air Lift customer service at (800) 248-0892.
  • Page 15 Air Lift Company, for all Air Lift Performance products, except its Air Lift Performance 3H™ and 3P™ systems, warrants to the original purchaser for a period of one year from the date of original purchase that the Air Lift Performance damper kits will be free from defects in workmanship and materials for the normal expected life of the part when used on cars and trucks as specified by Air Lift Company and under normal operating conditions, subject to the requirements and exclusions set forth below.
  • Page 16 Thank you for purchasing Air Lift Performance products! Air Lift Performance • 2727 Snow Road • Lansing, MI 48917 or PO Box 80167 • Lansing, MI 48908-0167 Toll Free (800) 248-0892 • Local (517) 322-2144 • Fax (517) 322-0240 • www.airliftperformance.com...

Table of Contents