Table of Contents
Advertisement
Quick Links
HE PARAMOTORES
Wo
rkshop, Installation Instructions
an
d Operator's Manual
For information ONLY.
Without commitment to advise modifications
Tel. / Fax. + 34 918738835 - Mob. + 34 666454408
E-mail: paramotores.he@terra.es - Web:
Con
fid
encial HE Paramotores
For:
R 220 E
Version Edi
HE Paramotores S.L.
C/ Constitución – Nave Nº 6
28511 Valdilecha
Prov. Madrid – España
www.paramotores-he.com
Página 1
ngine
tio
n: V01
21/03/2007
Advertisement
Table of Contents
Related Manuals for HE PARAMOTORES R 220
Summary of Contents for HE PARAMOTORES R 220
- Page 1 HE PARAMOTORES rkshop, Installation Instructions d Operator’s Manual For: R 220 E ngine Version Edi n: V01 For information ONLY. Without commitment to advise modifications HE Paramotores S.L. C/ Constitución – Nave Nº 6 28511 Valdilecha Prov. Madrid – España Tel.
- Page 2 © HE Paramotores S.L. C/ Co nstitución – Nave Nº 6 28511 Valdilecha Prov. Madr id –...
-
Page 3: Re Peating Symbols
Introduction gratulations on choos ing the R220 engine. HE Paramotores engine type R220 has been developed excl usively for use in paramotoring, ch must only be run mounted with specific propellers, usin g adequate oil type and fuel. You also comply with all the flying rules in your country. -
Page 4: General Precaution And Safety Information For Engine In Stallation
Engine assembly If t he frame of the chassis was specially prepa red to receive the HE Paramotores R220 engine, n 2 s teel plats with two holes each are welded on the two frame tubes. The engine is tigh tened into position with four 8mm bolts and four lock nuts. -
Page 5: Fitting Of The Spark Plug
Installation and connection of the carburettor C eck that all the gaskets are properly fitted onto the laminar entry box and carburettor inst allation plat. Con idencial HE Paramotores Página 5 21/03/2007... -
Page 6: Installation Of The Righetti Ridolfi Air Filter / Silencer
Remove the transport plug from the carburettor. it carburettor into carburettor socket and secure with hose clamp in vertical position. he R220, connect the outlet hose of the fuel pump with fuel inlet on carburettor ote: each time this operation is conducted make sure to use a new set of gaskets. f. -
Page 7: Ignition Unit
The exhaust system xhaust system is designed as resonance system with an af ter muffler and represents a system with engine. encial HE Paramotores Página 7 21/03/2007... -
Page 8: Fuel As Media For Engine Operation
Make sure that the fuel will not splash onto hot eng ine components or equipment. Risk of fi re and explosion! arning: Pay attention to the safety advice of the paramot or manufacturer! Confidencial HE Paramotores Página 8 21/03/2007... - Page 9 Attention: Don’t spill fuel. Absorb spilled fuel with appropriate drying agent and ensure logical disposal. tention: Ensure that no contamination enters the fuel tank and the carburettor. Attention: Unleaded fuel has a limited storage life. Store only the quantity of fuel in a con iner which will be needed in the near future.
- Page 10 These adjustments can be different on the basis of weather conditions flight altitudes. Once you have found the perfect mixture do not change it unless you nge flight place or climate conditions, since registe r screws can be damaged by continuous ustments. Confidencial HE Paramotores Página 10 21/03/2007...
- Page 11 Once you have found the correct tension, do not adjust it any more. In case of bts please contact your paramotor dealer - or HE Paramotores. iii. Propeller Quant./...
- Page 12 Characteristics and Operating limits R 220 Cycle 2 strokes Tota l displaceme 218 c.c. 65 mm. Stro 52 mm. pressio n ratio 10:1 k rpm 7.480 rpm ling by air Pist of light alloy wi th 2 pist on ring of cast iron...
-
Page 13: Engine Start And Operation
– allow it to warm up for at least a minute ore revving it. e. Stopping the engine ss the Kill switch button for more then 3 seconds. arning: If not, you engine will restart. fidencial HE Paramotores Página 13 21/03/2007... -
Page 14: Running In Procedure For The Engine
Warning: Never engine with an empty fuel tank. Note: To start with do not operate your engine for longer periods then stated above. ote: You must run-in the engine before flying. Note: Do not rev. up for five minutes while running-in. nfidencial HE Paramotores Página 14 21/03/2007... -
Page 15: Maintenance
Check that nothing can come loose in flight because if anythi ng hits the propeller it will be a danger for the paramotor, the pilot and other peop Confidencial HE Paramotores Página 15 21/03/2007... -
Page 16: Preservation Of Engine And Equipment
Apply oil on exh aust systems to prevent corrosion. In case the engine is not used for a long time, act like this: mpty the fuel t ank, included the fuel lines and the carburettor Confidencial HE Paramotores Página 16 21/03/2007... -
Page 17: Troubleshooting
15, modified in the external di ameter with a lathe. Remove encrustments from the decompressor and by reassembling it, tighten it at 2 Kg/M or 20 Nm with a dynamometric wrench. SOM FINAL IMPORTANT ADVICE Confidencial HE Paramotores Página 17 21/03/2007... - Page 18 HE Par amotores as manu facturer, warrants directly or through their authorized HE Paramotores distributors from the date of sale to the first consumer, every HE Paramotore s R220 engine, sold as new and unused, and delivere d by an...
- Page 19 Note: Use of gear reduction not designed by HE Pa ramotores. Note: Use of propeller not referenced by HE Paramotores. Note: Losses incurred by the paramotor engine owner other then the parts labour, such as, but not limited to, mo...
- Page 20 Where licable this warranty is expressly in lieu of all other expressed or implied rranties of HE Paramotores, its distributors and selling distributors, including warranty of merchantability or fitness for any particular purpose; otherwise implied warranty is limited to the duration of this warranty.
- Page 21 User assumes all risks of use. And acknowledges by this use that he knows this engine is subject to sudden stoppage. Confidencial HE Paramotores Página 21 21/03/2007...
-
Page 22: Warranty Registration Card
–no: ……………………. Date of purchase: …………………. arran ty expires: ……………………………………………………… ller: … …………………………………………………………………… ………………………………………………………………… Buyer: …… I have read and understood the operator’s manual in its entire carefully followed described break-in procedure. ……………………………. Signature: Date: encial HE Paramotores Página 22 21/03/2007... - Page 23 –no: ……………………. Date of purchase: …………………. arran ty expires: ……………………………………………………… ller: … …………………………………………………………………… Buyer: ……………………………………………………………………… I have read and understood the operator’s manual in its entire carefully followed described break-in procedure. ……………………. Signature: Date: ……… Confidencial HE Paramotores Página 23 21/03/2007...
- Page 24 Reporting In case of a malfunc tion or a defect the form below should be filled out and should be sent to the responsible HE Paramotor authorized distributor. Confidencial HE Paramotores Página 24 21/03/2007...
- Page 25 Notes: _____________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ __________________________________________________________________________ ____ Confidencial HE Paramotores Página 25 21/03/2007...