. Electrical Parts List…………………………………………..…..8-1 . Revision List……………………………………………………...9-1 CLASS 1 Copyright 2007 Philips Consumer Electronics B.V. Eindhoven, The Netherlands LASER PRODUCT All rights reserved. No part of this publication may be reproduced, stored in aretrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips.
Technical Specifications Hard Disk Capacity: DVDR 3588 H: 160GB Video Recording HDD recording enhancements: Instant Replay, Time Shift Buffer Recording System: PAL / NTSC Extra Hard Disk Technology: Pause Live TV, Simultaneous Compression formats: MPEG2 Record and Playback, Direct Record to HDD Modes of Record Quality File Copying/Archiving: High Quality:...
Safety instructions, Warnings, Notes Safety instructions 1. General safety 2.Laser safety Safety regulations require that during a repair: This unit employs a laser. Only qualified service personnel may . Connect the unit to the mains via an isolation remove the cover, or attempt to service this device (due to transformer.
Page 4
Warnings 1.General 2. Laser . All ICs and many other semiconductors are . The use of optical instruments with this product, will increase susceptible electrostatic discharges (ESD). eye hazard. Careless handing during repair can reduce life . Only qualified service personnel may remove the cover or drastically.
Mechanical and Dismantling Instructions Dismantling Instruction The following guidelines show how to dismantle the recorder. Step1:Remove the 9pcs of screws around the top Step2: If it is necessary to dismantle Loader or Front Panel, It cover, then remove top cover. (Figure 1) should be remove the front door assembly first.
Page 6
Mechanical and Dismantling Instructions Dismantling Instruction Step3: Dismantling Loader. First, disconnect the 2 connectors If the tray can’t open in normal way, you can make it then remove the 4pcs of screws at both sides of the loader. through the instruction as figure 3. (Figure 4) Note: Make sure to operate gently otherwise it would be damaged...
Page 7
Mechanical and Dismantling Instructions Dismantling Instruction Step4: If it is necessary to dismantle Front Panel It Step5: Dismantling the Front Panel: Disconnect the 6 connectors, should be dismantling Hard Disk. first .Dismantling and remove the 3pcs of screws on the bottom of the cabinet, then release the snaps on both sides of the front panel, finally gently Hard Disk: first disconnect the 2 connectors, then pull the panel out from the set.
Page 8
Mechanical and Dismantling Instructions Dismantling Instruction Step6: Dismantling Main Board, first disconnect the 3 Step7: Remove 4pcs of screws on the back of the cabinet, then connectors , then remove the relative screws. dismantling the OUTPUT Board. (Figure 8) (Figure 7) CON13 CON12 CON11...
Page 9
Mechanical and Dismantling Instructions Dismantling Instruction Step 9: Dismantling Power Board, first disconnect the 3 connectors, then remove the 2pcs of screws. (Figure 11) CON16 CON15 CON14 家电维修资料网,免费下载各种维修资料...
:TCL SZ Team & the File System name. For more information, please visit us at 2) Burn the data onto a blank CDR WWW.philips.com/support B. Procedure for software upgrade: 1) Power up the set and insert the prepared Upgrade CDR.
Trouble shooting chart No display on VFD, and buttons do not work No display on VFD, and buttons do not work Check every supply voltage on main board is Refer to Power supply board part normal Check-22Vstb(-22V),5 Fix the connection JP4 on front board Vstb(+5v) voltage on the power and front and CN6 on power board...
Page 12
Trouble shooting chart No audio output No audio output Check whether the audio signal is right from the U12.44 and Check the U12 power supply U12.45 Replace the U12 Check whether the audio Check the U12 power supply signal is right from the (U17.4=-12V and U17.8=12V) U11.7 and U11.1 Replace the U17...
Page 13
Trouble shooting chart Remote control does not work Remote control does not work Check whether the remote Replace the battery for remote controller’s battery controller exhausted or not. Check the U1 power Check the VCC net no front board supply is OK,U1.3 is about 5V Replace U1.
Page 14
Trouble shooting chart Can’t read disc or can’t open the tray Can’t read disc or can’t open the disk door Check whether Check the connection of the 4PIN cable DVD loader running is from CN6 on the Power Board. normal Check 40pin cable from main board Fix the connection the 40pin cable connection to the loader is normal...
Page 15
Trouble shooting chart No VFD display No VFD display Check whether the voltage Fix the connection power board +5Vstb on the front board is CN6& front board JP4 normal work or not. Check whether Check DC5V to AC 3V switch circuit voltage between F1&VFD F2 is AC3V...
Page 16
Trouble shooting chart Fan don’t work Fan don’t work Check on Power board Check R8 on Power board whether CN.1 is +11V Check cable Replace the cable connection fan to Power board CN1 Replace Fan 家电维修资料网,免费下载各种维修资料...
Page 17
PHILIPS 3588 BLOCK DIAGRAM CVBS COXIAL MONO/IF TUNER BUFFER BUFFER MIC IN MIC IN WM8776 AUDIO ADAC REAR R/L IN PT2399 ECHO FRONT R/L IN PT2259 VOLUME TUNER_CVBS LOAD DMN8652 R_CVBS DVD_CVBS TS5V330 F_CVBS 1394 POWER EEROM FORNT FLASH DDR*2 PANEL KEY IR &...
Page 18
DVDR3588H/93 WIRING DIAGRAM 3501 L=80MM CON3 40-DR3588-MAC2G VIDEO IN AV IN 40-DR3345-OPA1X YUV/CVBS/INPUT L/R INPUT AUDIO-DIG AUDIO AUDIO CVBS VIDEO TV TUNER AV-OUPUT-BOARD VIDEO 4558 CON4 3502 L=80MM AUDIO BUFFER 40-DR3588-PWC1G 3503 L=380MM Main Board AC220V +12V AC220V -12V 3.3V POWER board 3.3V...
Page 38
6-20 6-20 Main Board Print-layout (Top Side) for DVDR3588H/93 家电维修资料网,免费下载各种维修资料...
Page 39
6-21 6-21 Main Board Print-layout (Bottom Side) for DVDR3588H/93 家电维修资料网,免费下载各种维修资料...
Page 40
DVDR3588H/93 Packing View PAC-1 PAC-2 Rear panel label PAC-3 PAC-5 PAC-4 REMARKS: ACCESSORIES IN GIFT BOX POLY BAG PAC-8: AUDIO/VIDEO CABLE PAC-9: REMOTE CONTROL PAC-6: BATTERY PAC-7: RF CABLE PAC-14: SERVICE GUARANTEEN PAC-15: QC PASS LABEL PAC-10: USER MANUAL PAC-11: USER MANUALCHINESE PAC-12: WARRANTY CARD PAC-13: SERVICE HOTLINE 家电维修资料网,免费下载各种维修资料...
Page 41
DVDR3588H/93 Ex p loded View 家电维修资料网,免费下载各种维修资料...
Page 42
DVDR3588H/93 Exploded View Note: Position 14,15,16,17,19,20,21,23,24,27 are supplied as an Front Panel Assembly, and the assembly no.is A1 Position 20,21 are supplied as an Front Panel Assembly, and the assembly no.is A2 家电维修资料网,免费下载各种维修资料...
Page 43
MECHANICAL PARTS LIST Products marked with a have special characteristics importantant PRODUCT SAFETY NOTE: to safety. Before replacing any of these components, read carefully the product safety notice in this service manual.Don't degrade the safety of the product through improper serviceing. MECHANICAL PARTS LIST Pos.
Page 44
MECHANICAL PARTS LIST Products marked with a have special characteristics PRODUCT SAFETY NOTE importantant to safety. Before replacing any of these components, read carefully the product safety notice in this service manual.Don't degrade the safety of the product through improper serviceing. MECHANICAL PARTS LIST Pos.
REVISION LIST Version 1.0 * Initial release Version 1.1 * Page 3-1: Add additional information to point C2 * Addition of Top views for Output board & Power board 家电维修资料网,免费下载各种维修资料...