Table of Contents
Advertisement
Quick Links
IN DECK CIRCULATION/FILTRATION UNIT
18 North Dollins Ave, Orlando, FL 32805 Tel/Fax: 855-996-6900
INSTALLATION MANUAL
PP2 Ozone System
(No Filter Cartridge)
PP3 Ozone System
(With Filter Cartridge)
PERFECT POOL OZONE GENERATOR
!
NOTE TO INSTALLER:
GIVE THIS MANUAL TO OWNER
OPERATOR AFTER INSTALLATION
nspdevelopment.com
Advertisement
Table of Contents
Summary of Contents for Perfect Pool PP2
- Page 1 INSTALLATION MANUAL PP2 Ozone System (No Filter Cartridge) PP3 Ozone System (With Filter Cartridge) PERFECT POOL OZONE GENERATOR IN DECK CIRCULATION/FILTRATION UNIT NOTE TO INSTALLER: GIVE THIS MANUAL TO OWNER OPERATOR AFTER INSTALLATION nspdevelopment.com 18 North Dollins Ave, Orlando, FL 32805 Tel/Fax: 855-996-6900...
-
Page 2: Safety Precautions
Be sure the mounting surface is able to support the load of the controller. Use all mounting hoels to secure the unit. There are no customer servicable components inside the Perfect Pool Ozone Generator. Only qualified electricians should open the unit for installation. All connections should enter an approved conduit method. -
Page 3: Mounting Instructions
DU E TO THE DESIRED WATER RESISTANT SEAL OF THE ENCLOSURE, DO NOT REMOVE ANY KNOCKOUTS UNLESS THAT HOLE WILL HAVE A CONDUIT INSTALLED. IF A KNOCKOUT IS ACCIDENTALLY REMOVED, STEPS MUST BE TAKEN TO RESEAL THE OPENEING OR THE PERFECT POOL OZONE GENERATOR WILL BE DAMAGED. MOUNTING PAD MOUNT 1. -
Page 4: Unit Overview
INSTALLATION MANUAL UNIT OVERVIEW ON / OFF Switch 120 VAC WHITE: NEUTRAL BLACK: LINE GREEN: GROUND Mounting Holes (4 total) EXTERIOR VIEW INTERIOR VIEW NOTE: Components may change as Unit model changes Switch 120VAC Ozone / Power Air Out to Filter Pump Internal Wiring Ballast... - Page 5 INSTALLATION MANUAL IN DECK FILTER MODULE INSTALL INSTRUCTIONS There are 3 key installation points that must be adhered to for proper operation. 1. The In deck filter module must be installed at a level of where the pool water is equal to the bottom of the BLACK COUPLER.
- Page 6 INSTALLATION MANUAL IN DECK FILTER MODULE INSTALL INSTRUCTIONS THERE ARE 4 CONNECTION ON FILTER BASE 1 1/2" Inlet fitting - this is located in the direct center of the Filter BAse 1 1/2” Return fitting located on the extreme outside of filter base. There are 2—1”...
- Page 7 INSTALLATION MANUAL TUBING & DIFFUSER INSTALL INSTRUCTIONS Run 1” conduit from In Deck Filter to equipment pad or wherever Generator is located. Make sure to use “sweep” fitting—no 90 degree elbows should be used as replacement of tubing would be very difficult. Run Tube from In Deck Filter to Oxone Generator and attach to Check Valve located inside Ozone Generator.
- Page 8 INSTALLATION MANUAL Service Instructions FILTER ASSEMBLY The cartridge filter and the diffuser itself will need cleaning from time to time. The cartridge filter is removed by the following steps. 1. Turn Ozone Generator off using on/off switch on unit 2. On the inside of the In Deck Filter module - remove the diffuser and 90 degree wall fitting.
- Page 9 Insert new ozone bulb assembly and reinstall going from steps 4 to 1. TROUBLESHOOTING GUIDELINES There can be only 3 areas to check if you think your Perfect Pool PP2 or PP3 is not operating correctly: The Ozone Generator air pump (1) - the ozone bulb assembly (2) or the Ozone Diffuser In most all cases utilizing a small vial of Phenol Red dye (#2) available at any pool store or store selling pool chemicals.
-
Page 10: Product Registration
PP-3 IN-DECK OZONATION & FILTRATION MODULE + OZONE GENERATOR SERIAL NO. : NSP Development will ship you 1 FREE Ozone Diffuser upon the registration of your Perfect Pool unit. This will allow for instant ozone diffuser swap outs when cleaning is necessary without have to wait. -
Page 11: Limited Warranty
LIMITED WARRANTY (herein referred to as NSP Development “the Company”), warranties its products, to be free from defects in material and/or workmanship, under normal condition, use and service, for a period of ONE(1) year from the date of sale for use. This specific warranty is for parts only and specifically excludes all labor charges associated with warranty items. TERMS AND CONDITIONS: This warranty only applies when the Company’s products are properly wired and installed together as a system;...