Specific Operation Warnings - NorthStar 49162 Owner's Manual

To avoid fatal accident

Stop the engine before refueling and be careful not to spill fuel. Spilled fuel may ignite.

Do not refuel the engine near flammable objects to avoid fire.

Do not run the engine in enclosed areas to prevent carbon monoxide poisoning.
To protect the operator

When fatigued from operation, stop the machine and take break.

Hearing protection is required as this machine creates a noise emission while 1 m (3 feet) away
from the equipment.
To avoid injury or damage

The compactor is only to be operated by authorized persons who:
-
are at least 18 years of age.
-
are physically and mentally able to operate the plate compactor.
-
are properly trained in the operation and the maintenance of the compactor by the owner or
its authorized representative.
-
are assessed to be able to carry out their duties reliably.

Do not operate the compactor when any condition endangers the safety of the operator. Correct
the condition before operating the compactor.

Do not operate the compactor while under the influence of medication or alcohol.

The operator must monitor the immediate area all the times. Do not operate the compactor if a
person is in the immediate area because cracked and bounced rock may cause injury. Also
monitor other objects within 20m in case of lighting.

The compactor can only be operated under adequately stable conditions.

The operator must turn off the compactor completely as described in this manual before leaving
the operating position. Also, the compactor must be secured against unauthorized use.

The engine must be turned off and secured against re-starting by pulling out the spark plug before
maintenance and servicing.

The compactor has to be inspected by an authorized service technician on a regular basis (at
least once a year). The compactor generates mechanical heat so do not touch the engine, muf-
fler or other parts during the operation, which may cause a burn. Please wait until the compactor
cools down before inspecting components.

The operator must be fully equipped with safety equipment including a helmet, safety gloves,
safety shoes, safety glasses, a mask, and hearing protection before operating the compactor.

Do not insert a hand or finger between the pulley cover and engine during operation as it will
break the hand or finger.

Sprinkle the water on the working area to avoid dust before operating but NEVER operate the
compactor if the working area is too wet because it may damage the life cycle of the product.

Lift the plate compactor by a proper lifting crane when moving it on and off a truck. Lifting the
compactor by hand may cause personal injury due to its heavy weight.

Securely fasten the compactor for transportation. Insecure fastening of the compactor may cause
damage or injury during transportation.

Do not transport the plate compactor by motor vehicle with fuel in its fuel tank.
Note: Refer to the instruction manual of the engine if there is a problem or a question about it before
or during its operation.

Specific Operation Warnings

Page 9 of 28