Summary of Contents for Penner Bathing Spas Aqua-Aire Premier
Page 1
Cascade Aqua-Aire ® Premier Bathing Systems Parts Breakdown & Assemblies Side Entry – Side Entry High Seat – End-opening – Swivel Lift Tub Premier Standard Premier Elite 360020-1P 360020-1EP Cabinet Styles: Standard and Elite Premiers 360748P Revision “E” 8/17/2016 Penner Patient Care 101 Grant Street Aurora.
Table of Contents Rada 320 Mixing Valve Service Component Breakdown & Removal ..............4 Mixing Valve Adjustment ............................5 Mixing Valve Adjustment Rada 222 ........................6 Checking for the correct dilution of disinfection ....................7 Electrical Box Standard and Elite Premier ......................8 Timer Adjustments Explanation ..........................
Page 3
Controls Deck - Elite PremierLeft Side Access Views - Elite Premier (Right Hand) ..........24 Right Side Lower Access View - Elite Premier (Right Hand) ................. 25 Hoses - Elite Premier ............................. 26 Solenoid Identification - Elite Premier ........................26 Control Panel Elite Premier View From Behind ....................
Mixing Valve Adjustment To Adjust the High Temperature Limit: 1. Remove the temperature knob screw using a 3 mm hexagonal wrench (supplied). Remove the temperature knob. 2. Pull off the white polymer hub which may inadvertently remain attached to the inside of the temperature control handle.
Mixing Valve Adjustment Rada 222 (Currently applicable only in Minnesota) 350151MN Rada Cartridge 222 1. Remove the handle screw, temperature handle cap, temperature handle, and indicator trim using 3mm hex key. 2. Pull off the temperature hub. 3. Using the temperature hub, rotate the spindle until required maximum blend temperature is obtained at discharge point (clockwise = decrease temperature).
Checking for the correct dilution of disinfection 1. Check to see if a container of disinfectant has been installed. Assure that the disinfectant tube is inserted into the container and connected to the injector with black metering tip. See the drawing of the injector below for location of the metering tip.
Jets (Bottom View) 360650 - Tee - Air Jet (Washer Included) 360655 - Elbow – Air Jet (Washer Included) 350133 - Jet *This is the same Part Number for all Air Jets (Complete Assembly) Shown with cap removed. Inside Spring and Check Valve can be easily removed and cleaned.
Plumbing Drain and Overflow 360187 - G reen pipe 1 1/2" ID flex 16“ Temperature Probe Assembly - See Below Tub Drain assembly - See Below Temperature Probe Temp Probe from Temperature Readout 360637 - Temp Probe Nut ...
Penner Manufacturing, Inc. Swivel lift tub Calibration Procedure It is very important that you use an absolutely accurate 25 lb. weight. If not, you will have variations in your patient weighing. Requirements: Calibrated 25lb. weight. To enter the calibration mode, first press and hold the “ON / ZERO” pad. While holding the “ON / ZERO”...
Solenoids and Identification - Standard Premier Systems have the solenoid connections marked with the colors indicated below to easily identify correct connection and to improve communications in the field for service when diagnosing solenoid problems. Tub Disinfect - Yellow Reservoir Fill - Grey ...
Controls Deck - Elite Premier 350495 - Air Transmitter (7 ea) 350535M-SER -Thermometer Display (3 ea) 350217 - Cap - Sporocide Dispenser Pump (Other parts of the pump are the same as in 350200) 350151 - R eplacement Valve Cartridge 350151MN - Cartridge for Rada 222 (Minnesota Only) ...
Left Side Access Views - Elite Premier (Right Hand) Cabinet Lid Cabinet TV Window Door Left Access to Vacuum Breakers, Solenoids, and Electrical Box Left Access to Blower and Air Manifold Right Side Lower Access View - Elite Premier (Right Hand) Right Side Lower Access Opening.
Control Panel Elite Premier View From Behind 350200 - Dispenser Pump 350190CH - 78" Double Spiral Hose - SS (Is connected to 350185 on page 26) This hose is tied up as indicated during shipping then hangs freely. ...
Cabinet Access Doors - Standard Premier 350890 - Door Lock 1 ¼ (3 ea on the front doors and 1 ea on the tv door) 350894 - Door Lock 15/16 (4 ea -- 2 ea on each end panel)
Page 32
Your Penner distributor and his personnel are trained to provide in-service instruction and maintenance information on your Cascade bath system. If you have any questions about the operation or maintenance of your Cascade bath system, please contact your Penner distributor. For your nearest Penner distributor, contact Penner Patient Care, Inc.