70GS-66E SERVICE MANUAL SEJB70GS66E00 Issued: Tent 24 Jan 2001 DA-100 CHASSIS PAL I SYSTEM COLOUR TELEVISION 70GS-66E MODEL In the interests of user safety (required by safety regulations in some countries) the set should restored to its original condition and only parts identical to those specified should be used.
Page 2
70GS-66E SERVICE MANUAL UPDATE LOG SHEET Technical Report No. Application Cause / Solution Part No. Page No. Data /Serial No. Technical Bulletin No. Use this page to keep any special servicing information as Technical Report (Bulletin), Technical Information, etc. If only part number changes are required, just change part number directly the part number in the Parts Listing Section.
70GS-66E IMPORTANT SERVICING NOTES Only qualified service personnel are allowed to carry out maintenance and repair of this receiver. SERVICING OF HIGH VOLTAGE SYSTEM AND CRT It is important that the static charge is removed from the high voltage system when carrying out work on the receiver.
70GS-66E ADJUSTMENT PROCEDURES All adjustments to this chassis, except for focus, are carried out in the service mode. • • • • • SERVICE MODE The service mode is provided to enable the engineer to correctly set up the receiver to the CRT fitted in the set.
Page 6
70GS-66E The following geometry adjustments can be carried out. Detailed instructions on how to execute these are given on the following pages Horizontal Vertical • Horizontal Shift • Vertical Amplitude • E-W Width • S Correction • Pin Phase • Vertical Shift •...
Page 7
70GS-66E Lower Corner Correction Adjust the Lower Corner Correction so that the picture is centred. The effect of this adjustment is shown in figure 7. • When the volume up button is pressed, side pincushion changes from pincushion to barrel shape.
Page 8
70GS-66E • When the volume down button is pressed the top and bottom scanning decreases and the centre scanning increases. • Press the stand-by button on the remote control to store. Vertical Shift Adjust the Vertical Shift so that the picture is centred.
Page 9
5. If another NVM value has to be changed, use the channel down button to select the page or position and repeat as necessary. Note: DO NOT change any NVM data, unless you have been advised to do so by a Sharp representative. If data is incorrectly changed, serious damage may occur to the receiver. Contrast Adjustments Three types of contrast levels can be varied as listed below: •...
Page 23
Hasta INFO 961 MOTHER BOARD K I T P 7 B M N 24-11-2000 Hasta INFO 960 21-11-2000 Hasta INFO 947 FECHA 15-01-2001 14-11-2000 Hasta INFO 937 SHARP ESCALA 03-11-2000 Hasta INFO 916 70GS66E MODELO ELECTRONICA ESPANA S.A. FECHA REVISIONES...
Page 26
BC547 (VD) +3,3V C7001 R7004 1000uF 6,3V GN0242 TENTATIVE-REV-00 REALIZADO VERIFICADO APROBADO NOMBRE CODIGO POWER SUPPLY P W B F 7 B M N 3,3V ESCALA FECHA 30-10-2000 SHARP 30-10-2000 Hasta INFO 859 70GS66E MODELO REVISIONES ELECTRONICA ESPANA S.A. FECHA...
Page 27
(TQ) (TQ) (1%) (1%) TENTATIVE REV-00 REALIZADO VERIFICADO APROBADO NOMBRE CODIGO Modulo PFC P W B F 7 B M N FECHA 08-01-2001 22-11-2000 HASTA INFO 953 SHARP ESCALA 18-10-2000 HASTA INFO 879 70GS66E MODELO ELECTRONICA ESPANA S.A. FECHA REVISIONES...
Page 28
70GS66E CCABA1336BMV1 CABINET SET+ELEC ASS 70GS66E S -- 70GS66E CCABB1083BMV0 REAR CABINET S AQ BB 70GS66E CINS-6937BMV0 INS SET 70GS66E S -- 70GS66E CPAKC5448BMV0 PACKING SET S -- 70GS66E DLAB-2448BMV0 LABELS SET FOR B LINE MODELS S -- 70GS66E DSETU7240CJX7 ADJUST MOTHER SET 70GS66E S CD CX 70GS66E...
Page 29
70GS66E DUNTK7240 (PW) QCNCM0672FCZZ CONN B2P3-VH JST S AA AB 70GS66E DUNTK7240 (RG0000 QPLGN0441CEZZ PLUG 4PIN S AA AA 70GS66E DUNTK7240 (SP0000 QPLGN0441CEZZ PLUG 4PIN S AA AA 70GS66E DUNTK7240 QCNW-2869BMZZ AV/FRONT QIRE DOUBLE WINDOW S AH AU 70GS66E DUNTK7240 (YA0000 QSOCN1285CEZZ SOCKET...
Page 30
70GS66E DUNTK7240 C 0352 RC-FZ4104BMNJ POL FILM C 100nF 50V 5% ECQ-V PANASONIC S AA AA 70GS66E DUNTK7240 C 0353 RC-FZ4104BMNJ POL FILM C 100nF 50V 5% ECQ-V PANASONIC S AA AA 70GS66E DUNTK7240 C 0354 VCCCTV1HH101J CERAM C 100PF 50V 2125SMD S AA AA 70GS66E DUNTK7240...
Page 31
70GS66E DUNTK7240 C 0507 VCKYTV1HB472K CERAM C 4,7NF 50V 2125SMD S AA AA 70GS66E DUNTK7240 C 0508 VCCCTV1HH561J CERAM C 560PF 50V 2125SMD S AA AA 70GS66E DUNTK7240 C 0509 VCEAGA1EW227M ELEC C 220UF 20% 25V S AA AA 70GS66E DUNTK7240 C 0510 VCKYTV1HF104Z...
Page 32
70GS66E DUNTK7240 C 0735 VCKYTV1HB272K CERAM C 2,7NF 50V 2125SMD S AA AB 70GS66E DUNTK7240 C 0737 VCKYTV1CF105Z CERAM C 1UF 16V 2125SMD S AA AB 70GS66E DUNTK7240 C 0738 VCCCTV1HH560J CERAM C 56PF 50V 2125SMD S AA AA 70GS66E DUNTK7240 C 0739 VCEAGA1CW227M ELEC C 220UF 20% 16V...
Page 33
70GS66E DUNTK7240 D 0504 RH-DX0551BMZZ DIODE LL4148 TFK SMD S AA AA 70GS66E DUNTK7240 D 0506 RH-DX0551BMZZ DIODE LL4148 TFK SMD S AA AA 70GS66E DUNTK7240 D 0507 RH-EX0554BMZZ ZENER DIODE TZMC12 TFK SMD S AA AA 70GS66E DUNTK7240 D 0508 RH-DX0551BMZZ DIODE LL4148 TFK SMD S AA AA...
Page 34
70GS66E DUNTK7240 FV 0001 QPLGN0241CEZZ PLUG S AA AA 70GS66E DUNTK7240 FV 0002 QPLGN0241CEZZ PLUG S AA AA 70GS66E DUNTK7240 IC 050 RH-IX1786BMZZ C.I. TDA 7480L THOMSON S AD AL 70GS66E DUNTK7240 IC 0201 RH-IX1671BMZZ IC TDA4470-MFL TEMIC SMD S AF AQ 70GS66E DUNTK7240 IC 0202...
Page 35
70GS66E DUNTK7240 L 0204 RCILP0229BMZZ COIL SMD 610NH LQN1HR61J S AA AD 70GS66E DUNTK7240 L 0205 RCILP0229BMZZ COIL SMD 610NH LQN1HR61J S AA AD 70GS66E DUNTK7240 L 0301 VP-DF100K0000 PEAK COIL 10UH 10% S AA AA 70GS66E DUNTK7240 L 0315 VP-CF3R3K0000 PEAK COIL 3.3UH 10% S AB AB...
Page 36
70GS66E DUNTK7240 Q 1007 VS2SC2412KQ-1 TRT 2SC2412 ROHM S AA AA 70GS66E DUNTK7240 Q 2401 VS2SC2412KQ-1 TRT 2SC2412 ROHM S AA AA 70GS66E DUNTK7240 R 0203 VRS-TV1JD102J 2125 1KOHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7240 R 0204 VRS-TV1JD102J 2125 1KOHM 5% 1/10W SMD S AA AA 70GS66E...
Page 37
70GS66E DUNTK7240 R 0362 VRS-TV1JD472J 2125 4.7KOHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7240 R 0363 VRS-TV1JD472J 2125 4.7KOHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7240 R 0372 VRS-TV1JD103J 2125 10KOHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7240 R 0373 VRS-TV1JD103J...
Page 38
70GS66E DUNTK7240 R 0515 VRS-TV1JD122J 2125 1,2KOHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7240 R 0516 VRS-TV1JD102J 2125 1KOHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7240 R 0517 VRS-TV1JD153J 2125 15KOHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7240 R 0518 VRN-VV3DB1R0J...
Page 39
70GS66E DUNTK7240 R 0727 VRD-RA2HD181J RES 180 OHM 5% 1/2W S AA AA 70GS66E DUNTK7240 R 0728 VRD-RA2HD181J RES 180 OHM 5% 1/2W S AA AA 70GS66E DUNTK7240 R 0730 VRS-VV3AB820J MET OX RES 82 OHM 5% 1W S AA AA 70GS66E DUNTK7240 R 0733...
Page 40
70GS66E DUNTK7240 R 1038 VRS-TV1JD101J 2125 100 OHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7240 R 1039 VRS-TV1JD101J 2125 100 OHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7240 R 1040 VRS-TV1JD101J 2125 100 OHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7240 R 1041...
Page 41
70GS66E DUNTK7241 C 1814 VCKYPB3DE472Z C DE1110-1E472Z2K MURATA S AA AC 70GS66E DUNTK7241 C 1815 VCKYTV1HF473Z CERAM C 47NF 50V 2125SMD S AA AA 70GS66E DUNTK7241 C 1820 VCCCTV1HH100D CERAM C 10PF 50V 2125SMD S AA AA 70GS66E DUNTK7241 C 1821 VCCCTV1HH100D CERAM C 10PF 50V 2125SMD S AA AA...
Page 42
70GS66E DUNTK7308 C 6006 VCCCTV1HH151J CERAM C 150PF 50V 2125SMD S AA AA 70GS66E DUNTK7308 C 6007 VCKYTV1EF334Z CERAM C 330NF 25V 2125SMD S AA AB 70GS66E DUNTK7308 C 6008 VCKYTV1EF334Z CERAM C 330NF 25V 2125SMD S AA AB 70GS66E DUNTK7308 C 6009 VCCCTV1HH151J...
Page 43
70GS66E DUNTK7308 C 6078 VCKYTV1HF223Z CERAM C 22NF 50V 2125SMD S AA AA 70GS66E DUNTK7308 C 6079 VCKYTV1HF223Z CERAM C 22NF 50V 2125SMD S AA AA 70GS66E DUNTK7308 C 6081 VCCCTV1HH121J CERAM C 120PF 50V 2125SMD S AA AA 70GS66E DUNTK7308 C 6090 VCKYTV1HF104Z...
Page 44
70GS66E DUNTK7308 D 6012 RH-DX0551BMZZ DIODE LL4148 TFK SMD S AA AA 70GS66E DUNTK7308 D 6015 RH-EX0579BMZZ ZENER DIODE TZMB3V9 TFK SMD 2% S AA AA 70GS66E DUNTK7308 FB 6201 VRS-TQ2BD000J 3216 0 OHM 5% 1/8W SMD S AA AA 70GS66E DUNTK7308 FB 6202...
Page 45
70GS66E DUNTK7308 R 6027 VRS-TV1JD392J 2125 3.9KOHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7308 R 6028 VRS-TV1JD472J 2125 4.7KOHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7308 R 6029 VRS-TV1JD182J 2125 1,8KOHM 5% 1/10W SMD S AA AA 70GS66E DUNTK7308 R 6030 VRS-TV1JD152J...
Page 46
70GS66E DUNTK7334 Q 7002 RH-TX0106BMZZ TRT BC547 S AA AB 70GS66E DUNTK7334 R 7001 VRN-VV3LB2R7J MET FILM R 2.7 OHM 5% 3W S AA AC 70GS66E DUNTK7334 R 7002 VRD-RA2BE331J RES 330 OHM 5% 1/8W S AA AA 70GS66E DUNTK7334 R 7003 VRD-RA2BE221J RES 220 OHM 5% 1/8W...