Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Crescent SC2000
Summary of Contents for Crescent SC2000
- Page 1 SC2000 Operator manual - English www.crescentindustrial.co.uk...
-
Page 2: Table Of Contents
DRAINING THE ECOFLEX SYSTEM............................25 FUSE CHECK/REPLACEMENT ..............................25 SAFETY FUNCTIONS ..............................25 EMERGENCY PUSH-BUTTON ..............................25 ANTI-SKID SAFETY SYSTEM ..............................25 DRIVER’S SEAT MICROSWITCH ..............................25 ELECTROMAGNETIC BRAKE ..............................25 TROUBLESHOOTING ..............................26 SCRAPPING .................................. 27 9100000383 - SC2000 01/2015... -
Page 3: Introduction
Electronic battery charger Manual, to be considered as integral part of this Manual – Spare Parts List (supplied with the machine) – SPARE PARTS AND MAINTENANCE Centers. Only original spare parts and accessories must be used. CHANGES AND IMPROVEMENTS SC2000 - 9100000383 01/2015... -
Page 4: Operation Capabilities
VISIBLE SYMBOLS ON THE MACHINE WARNING! Carefully read all the instructions before performing any operation on the machine. WARNING! Do not wash the machine with direct or pressurized water jets. WARNING! 9100000383 - SC2000 01/2015... -
Page 5: Symbols That Appear On This Manual
– Do not smoke while charging the batteries. – To avoid any unauthorized use of the machine, remove the magnetic smart key (or ignition key). – Do not leave the machine unattended without being sure that it cannot move independently. SC2000 - 9100000383 01/2015... - Page 6 – Do not wash the machine with direct or pressurised water jets, or with corrosive substances. – The machine must be disposed of properly, because of the presence of toxic-harmful materials (batteries, etc.), which are subject to standards that require disposal in special centres (see Scrapping chapter). 9100000383 - SC2000 01/2015...
-
Page 7: Machine Description
17. Dumping recovery tank assembly Brush deck 18. Recovery tank cover 19. Can holder Solution valve 20. Battery charger cable housing and document holder A) Open valve 21. Battery charger cable (*) B) Closed valve Optional for BASIC version P100859 SC2000 - 9100000383 01/2015... - Page 8 38. EcoFlex detergent canister (*) 29. Recovery water tank cover (open) 39. Electronic component compartment cover 30. Squeegee vacuum hose 40. Lifted recovery tank assembly and driver’s seat 31. Squeegee support wheel Optional for BASIC version P100860 9100000383 - SC2000 01/2015...
-
Page 9: Control Panel
M) Battery charging with on-board battery charger (*) 49. Reverse gear activation/deactivation lever N) EcoFlex system drain activation (*) 50. EcoFlex activation/deactivation lever (*) 52. Magnetic smart key • Blue = User key • Yellow = supervisor key Optional for BASIC version P100861 SC2000 - 9100000383 01/2015... -
Page 10: Accessories/Options
USB port – Filling hose For further information concerning the optional accessories, contact an authorised Retailer. TECHNICAL DATA Model SC2000 53 B SC2000 53 B FULL PKG Solution tank capacity 70 litres Recovery tank capacity 70 litres Machine length 1,270 mm... -
Page 11: Wiring Diagram
Brush motor fuse Grey Drive system motor fuse Orange Smart key Pink Brush motor Vacuum system motor Violet Drive system motor White EcoFlex pump (optional) Yellow Brush deck actuator motor NO ON BOARD BATTERY CHARGER P100862 SC2000 - 9100000383 01/2015... -
Page 12: Use/Operation
(6). Battery Charging 10. Disengage the support rod (36), then grasp the handle (35) 11. Fully charge the batteries (see the procedure in and carefully lower the recovery tank assembly (17). Maintenance chapter). 9100000383 - SC2000 01/2015... -
Page 13: Before Machine Start-Up
Available brushes and their relevant application guides (suggestions only) Models 46 GRIT 80 GRIT 180 GRIT 240 GRIT 500 GRIT PROLENE PROLITE UNION MIX General cleaning: Concrete Ceramic tiles/quarrystones Marble Vinyl tiles Rubber tiles Polishing: Rubber tiles Marble Vinyl tiles SC2000 - 9100000383 01/2015... - Page 14 Close the cover (18). Grasp the handle (35) and carefully lift the recovery tank assembly (17). Fill the tank (38) with a detergent suitable for the work to be performed (highly concentrated detergent). NOTE Maintenance chapter). 9100000383 - SC2000 01/2015...
-
Page 15: Machine Start And Stop
NOTE If the machine is on but not working, it automatically turns off after 5 minutes. CAUTION! To reset the machine operation, lift the recovery tank assembly (17) and reconnect the battery connector (6). SC2000 - 9100000383 01/2015... -
Page 16: Machine Operation (Scrubbing/Drying)
If necessary, to reduce the noise, turn on the vacuum system mute function by pressing the push-button (44). NOTE Figure 5 P100867 To stop scrubbing/drying, press the One-Touch push-button (43) and wait for the brush deck (7) to lift. After 10 seconds, the vacuum system turns off too and the squeegee (13) lifts. 9100000383 - SC2000 01/2015... - Page 17 Do not use the machine with discharged batteries, to avoid damaging the batteries and reducing the battery life. NOTE In case the machine drive system cannot be used in order to move the machine, see Pushing/Towing The Machine paragraph. SC2000 - 9100000383 01/2015...
-
Page 18: Tank Emptying
For versions with EcoFlex system, empty the detergent tank (38) and clean the system with a draining cycle (see the procedure in Maintenance chapter). Close the solution tank valve (9-B). Press the emergency push-button (5) to disconnect the battery connector (6). 9100000383 - SC2000 01/2015... -
Page 19: Maintenance
EcoFlex system (optional) cleaning and draining Squeegee blade check Solution Filter Cleaning Squeegee blade replacement Drive and brush motor vent check and cleaning Brush motor carbon brush check or replacement Drive system motor carbon brush check or replacement SC2000 - 9100000383 01/2015... -
Page 20: Battery Charging
Disengage the support rod (36), then grasp the handle (35) and carefully lower the recovery tank assembly (17). Now the machine is ready to be used. NOTE For further information about the operation of the battery charger (22), see the relevant Manual. 9100000383 - SC2000 01/2015... -
Page 21: Supervisor Key (Yellow)
Silent mode setting RPM (*) Reduced brush rpm activation threshold RESET Restore factory settings for all parameters Increase the value of this parameter to reduce the brush motor speed in a wider range of applications and vice versa. SC2000 - 9100000383 01/2015... - Page 22 Remove the Supervisor key (if any) from the key reader. Press the push-button (B). To return to the user mode screen, press push-button (C). To return to the main screen (E, Fig. 7), press push-button (A). 9100000383 - SC2000 01/2015...
-
Page 23: Squeegee Cleaning
Unscrew the handwheels (I) and remove the strap (J), then turn or replace the front blade (C). • Install the blade in the reverse order of removal. Install the squeegee (13) and screw down the handwheels (32). • • Use the knob (33) to make adjustments. Figure 11 P100850 SC2000 - 9100000383 01/2015... -
Page 24: Cleaning The Brush
The gasket (E) allows the creation of a vacuum in the tank, which is necessary to suck up the recovery water. Check that the seating surface (H) of the gasket (E) is in good condition, clean and suitable to form a seal with the gasket itself. 10. Close the cover (18). Figure 12 P100873 9100000383 - SC2000 01/2015... -
Page 25: Solution Filter Cleaning
Rinse and wash out the tank with clean water in the appointed disposal area. 10. When the detergent tank has been drained, it may be necessary to drain the EcoFlex system too (see procedure in following section). Figure 14 P100875 SC2000 - 9100000383 01/2015... -
Page 26: Draining The Ecoflex System
It is located inside the driver’s seat (12) and it does not allow the machine drive system to operate if the operator is not seated on the driver’s seat. ELECTROMAGNETIC BRAKE It is built-in the rear driving wheels (24) and keeps the machine braked when the machine is off or stopped. 9100000383 - SC2000 01/2015... -
Page 27: Troubleshooting
Adjust the squeegee. handwheel. NOTE If the machine has been purchased with an on-board battery charger, the machine cannot operate if this device is not on board. In case of battery charger malfunction, contact an authorised Service Center. SC2000 - 9100000383 01/2015... -
Page 28: Scrapping
Electric motors - various 29 % 32 % Ferrous materials 100 % 23 % Wiring harness 80 % Liquids 100 % Plastic - non-recyclable material Plastic - recyclable material 100 % Polyethylene 92 % 26 % Rubber 20 % 9100000383 - SC2000 01/2015... - Page 29 ENGLISH INSTRUCTIONS FOR USE revised 07/2017 SC2000 - 9100000383 01/2015...
- Page 30 We supply a full range of cleaning equipment for rental or purchase. For more information, or a cleaning solution to suit your business, please get in touch – For a more comprehensive product range, please visit our website. Address Contact Berrington House, t: 0845 33 77 695 Berrington Road,...
Need help?
Do you have a question about the SC2000 and is the answer not in the manual?
Questions and answers