Summary of Contents for LOHBERGER VARIOLINE AC 105
- Page 1 VARIO LI N E AQUA T HE R M C O MB I AC 1 05 O PER ATI NG M AN UAL wi t h INSTAL L ATIO N I N S T RU C TI O N S Issued 06-2016...
-
Page 2: Table Of Contents
Table of contents Table of contents Table of contents 1. Important standards / guidelines .........3 11. Combustion ..............16 Prerequisites for effi cient combustion 2. Important instructions prior to installation The combustion process and start-up ..............4 Clean combustion JETFIRE Flame convergence plate 3. -
Page 3: Important Standards / Guidelines
Therefore please read the information in this operating manual carefully. With the above in mind, we believe that this appliance will give satisfactory service for many years. Your LOHBERGER Heiz + Kochgeräte Technologie GmbH Our contribution towards climate protection Our contribution towards climate protection... -
Page 4: Important Instructions Prior To Installation And Start-Up
2. 2. 2. Important instructions prior to installation and start-up Important instructions prior to installation and start-up Important instructions prior to installation and start-up CAUTION! CHILDREN PLAYING! Before connecting the appliance to the chimney, Before connecting the appliance to the chimney, Before connecting the appliance to the chimney, inform the local qualifi ed chimney sweep inform the local qualifi ed chimney sweep... -
Page 5: Transport / Unpacking / Inspection
Only install genuine spare parts provided by your local specialist dealer. Wearing parts (e.g. seals), components exposed to high thermal stress (fi reclay, cast-iron parts) or broken stove parts should be replaced or exchanged as soon as possible. Correct procedure in the event of chimney fi res: Correct procedure in the event of chimney fi... -
Page 6: Safety Instructions
4. 4. 4. Safety instructions Safety instructions Safety instructions During installation and operation CAUTION! CHILDREN PLAYING! CAUTION! CHILDREN PLAYING! CAUTION! CHILDREN PLAYING! Bear in mind that certain components of the Bear in mind that certain components of the Bear in mind that certain components of the •... -
Page 7: Cooking Surface
Cooking surface Your stove is equipped with a polished steel cooking surface. Stove frame (adjustable in the stove type CLASSIC) With the stove type CLASSIC the stove frame is adjustable in its fi tting to the appliance. This means you can have the stove frame fl ush with the working top as well as the appliance front fl ush with the kitchen front when installing the appliance in a fi tted kitchen. - Page 8 15 14 Stove frame stainless steel 14 Ash door panel 28 Cast-iron grate combustion chamber 2a Cooking surface (Ceran, extra charge) 15 Base panel of ash drawer 29 Combustion air slider secondary air 2b Cooking plate oven (standard) 16 Base panel of fuel drawer 30 Grate riddling / grate adjustment 2c Cooking plate combustion chamber (standard) 17 Heat exchanger finishing panel...
-
Page 9: Installing The Appliance
(Figure 12). > 20 The LOHBERGER fi re protection units type VBS are only tested in conjunction with The LOHBERGER fi re protection units type VBS are only tested in conjunction with The LOHBERGER fi re protection units type VBS are only tested in conjunction with LOHBERGER stoves of the series VARIOLINE (stoves type AC.., LM.., LC.., LCP...). -
Page 10: Chimney Connection
7. 7. 7. Chimney connection Chimney connection Chimney connection Schematic diagram fl ue gas connection (Figure 13) Trouble-free and effi cient operation is assured if the following conditions for an optimum combustion are fulfi lled: Adequate condition of the chimney: good thermal insulation, smooth inner surface, no leakages ... -
Page 11: Combustion Air
8. 8. 8. Combustion air Combustion air Combustion air The appliance is dependent on indoor air (open-fl ued appliance); that means The local qualifi ed chimney sweep or your venti- The local qualifi ed chimney sweep or your venti- The local qualifi ed chimney sweep or your venti- the air required for combustion is drawn from the room where the appliance is lation installer will be happy to provide informati- lation installer will be happy to provide informati-... -
Page 12: Connection Of The Heating System
9. 9. 9. Connection of the heating system Connection of the heating system Connection of the heating system The boiler is suitable and permissible as a heat generating device for hot-water The connection to the heating appliance as well The connection to the heating appliance as well The connection to the heating appliance as well heating systems with a fl ow temperature of up to 95°... -
Page 13: Safety Valve
Connection with LOHBERGER installation package (optional equipment) Explanation of symbols Explanation of symbols Explanation of symbols... -
Page 14: Operating The Stove
10. Operating the stove Operating the stove Operating the stove Start-up fl ap To facilitate initial heating, all LOHBERGER stoves are equipped with a start-up closed open fl ap. Opening the start-up fl ap provides a direct route from the fi rebox chamber to the fl ue pipe. -
Page 15: Grate Riddling
Grate riddling To remove ash from the grate use the grate crank handle from the ash drawer (Figure 23). To do this, push the grate crank handle onto the upper square spi- Grate crank got and turn as required. However, if the air slits of the grate are very clogged handle by slag, crusts or other combustion residues, completely remove the grate and clean it. -
Page 16: Combustion
11. Combustion Combustion Combustion Prerequisites for effi cient combustion: • suffi cient amount of combustible material • oxidising agent, mostly oxygen • enough heat to reach the ignition temperature or to maintain the minimum fi re temperature required for combustion •... -
Page 17: 12. Fuels
12. Fuels Fuels Fuels Suitable fuels FIREWOOD (LOGS) Firewood (Figure 31) should have a moisture content of approx. 20 % of the dry weight, a length of 1/3 m and should be split into small pieces. This way, the fi rewood quickly catches fi re and produces a higher heat output than the Figure 31 same volume of large logs. -
Page 18: Adding Fuel
Adding Fuel • Add more fuel according to the table (see air supply settings). • Turn primary air supply for the required heat output. • Adjust secondary air supply for the required type of fuel. When adding fuel we recommend: 1. -
Page 19: Maintenance And Cleaning
14. Maintenance and Cleaning Maintenance and Cleaning Maintenance and Cleaning Regular maintenance and care or cleaning of the appliance, the fl ue gas ducts, the connecting piece and the chimney are particularly important for the opera- tional safety, effi ciency and maintaining the value of the appliance. A thorough cleaning should be performed after each heating period and after a long period of non-use (see Important instructions, page 4). -
Page 20: Grate
Grate The ash can be removed from the grate quite easily by riddling the grate. Howe- ver, if the air slits are very clogged by slag, crusts or other combustion residue, completely remove the grate and clean it. To do this, open the combustion chamber door and the ash door, pull out the ash drawer, lift the grate from below and pull it out through the combustion chamber door. -
Page 21: Cleaning The Glass Viewing Window Of The Combustion Chamber
Cleaning the glass viewing window of the combustion chamber To clean the glass viewing window use gentle cleaning agents (e.g. soapy wa- ter) and a soft cloth. In adverse weather conditions or as a result of incorrect operation or the use of unsuitable fuels the inside of the combustion chamber window may become fogged. -
Page 22: Stoves With Glass Ceramic Cooking Surfaces
to warp. • • • Never use abrasive or harsh cleaning agents Never use abrasive or harsh cleaning agents Never use abrasive or harsh cleaning agents Stoves with glass ceramic cooking surfaces such as grill and oven sprays, stain and rust re- such as grill and oven sprays, stain and rust re- such as grill and oven sprays, stain and rust re- mover, scouring powder, sponges with abrasive... -
Page 23: Troubleshooting
15. Troubleshooting Troubleshooting Troubleshooting A combination of factors is a prerequisite for ensuring a trouble-free operation of the stove: Stove: Correct assembly, connection and start-up. Handling and Care: Regular cleaning of the stove, fl ue pipe and chimney according to the instructions in the operating manual. Chimney: Correct dimensions, fl... -
Page 24: After-Sales Service
Please note: AUSTRIA (Head offi ce) To enable our customer service to deal with repairs and supply spare parts LOHBERGER Heiz u. Kochgeräte Technologie GmbH quickly and to your satisfaction, we require the following information with your Landstraße 19 service request:... -
Page 25: Appliance Dimensions
17. Appliance dimensions Appliance dimensions Appliance dimensions dimensions in cm 18 - 15*** RA Ø 15 RA Ø 15 3 - 0*** 6 - 3*** 5 - 6,5 13,5 RA Ø 15 VL, 1“ Dimensions with installation package 19,5 14,5 (External thread) +/- 1,25 (optional equipment) -
Page 26: Technical Data
19. Type testing Type testing Type testing The Lohberger Pellet module was successfully tested by the Technical University of Vienna according to the current European Standards. Test report number: TGM-VA HL 7813 The appliance is in conformance with the emission values according to art.15a B-VG (Austrian law) for protective measures and energy saving. -
Page 27: Warranty
These warranty conditions are valid in all European countries where LOHBERGER appliances are sold by local specialist dealers. Warranty claims must always be directed to a local LOHBERGER specialist dealer or the dealer from whom you have bought the appliance. - Page 28 LOHBERGER HEIZ U. KOCHGERÄTE TECHNOLOGIE GMBH Landstraße 19, 5231 Schalchen, Austria Telephone: +43(0)7742/5211-0 / Telefax: +43(0)7742/5211-109 offi ce@lohberger.com www.lohberger.com Page 28 Page 28...