Table of Contents
Advertisement
SCR BATTERY CHARGER
FEATURES
•
Microprocessor controlled charge circuit monitors battery state of charge and automatically turns charger off
when the batteries reach full charge.
•
Line voltage compensation produces consistent charger output for input voltage variations from nominal.
•
Automatic taper of charge rate for superior battery life through optimum equalization of cells and low water
use rate.
•
Convection cooled design for maximum reliability and minimum maintenance.
•
Factory set for either flooded or sealed batteries, but is field changeable.
•
Battery maintenance feature keeps batteries charged while they are in storage.
•
UL and CSA listed.
SPECIFICATIONS
Battery Capacity (20 hr. rate)
Size (H x W x L) / Weight
PLEASE SAVE THESE IMPORTANT SAFETY AND OPERATING INSTRUCTIONS
For correct operation of the equipment, it is important to read and be familiar
with this entire manual before installing and operating the charger.
LOOK FOR THIS SYMBOL TO POINT OUT SAFETY PRECAUTIONS.
BECOME ALERT—YOUR SAFETY IS INVOLVED. IF YOU DO NOT FOLLOW THESE
SAFETY INSTRUCTIONS, INJURY OR PROPERTY DAMAGE CAN OCCUR.
www.lesterelectrical.com
www.fairplayelectriccars.com
FULLY AUTOMATIC
Model
AC volts
Frequency / Phase
AC Amps (Maximum)
Battery Pack Voltage
DC Output Current
DO NOT DISCARD THIS MANUAL AFTER READING.
25930
105 - 128
60 / 1
11.5
48 V
17 Amps tapering to 6 Amps
105 - 210
9" x 8.75" x 11" / 39 Lbs.
1
*35589*
IT MEANS:
35589A
Advertisement
Table of Contents
Summary of Contents for Fairplay 25930
- Page 1 Factory set for either flooded or sealed batteries, but is field changeable. • Battery maintenance feature keeps batteries charged while they are in storage. • UL and CSA listed. SPECIFICATIONS Model 25930 AC volts 105 - 128 Frequency / Phase 60 / 1 AC Amps (Maximum) 11.5...
-
Page 2: Important Safety Instructions
following figure. If changed from the factory setting, IMPORTANT SAFETY INSTRUCTIONS place a decal on the front of the charger over the Before using battery charger, read all instructions existing marking “SET FOR XXX BATTERIES” to and cautionary markings on battery charger, battery indicate the type of batteries to charger. -
Page 3: Normal Operation
AC INPUT NORMAL OPERATION This battery charger must be grounded to reduce the The instructions printed on the charger are for risk of electric shock. It is equipped with an electric daily reference. cord having an equipment-grounding conductor and 1. With the charger DC output cord disconnected a grounding-type plug. -
Page 4: Proper Care Of Deep Cycle Motive Power Batteries
Using the charger with any of the above symptoms VALVE REGULATED BATTERIES could result in a fire, property damage, or personal During charge, the battery voltage increases injury. gradually which causes the charge to decrease Have your distributor, dealer or other qualified to near zero and remain there until the charger service agent repair or replace worn or damaged turns off. -
Page 5: Personal Precautions
7. When the temperature falls below 65°F, the CAUTION: ALWAYS WEAR PROTECTIVE batteries should be placed on charge as soon EYE SHIELDS AND CLOTHING WHEN WORKING after use as possible. Cold batteries require WITH BATTERIES. BATTERIES CONTAIN ACIDS more time to fully recharge. WHICH CAN CAUSE BODILY HARM. -
Page 6: Troubleshooting Guide
seconds. If the "click" is not heard remove the DC TROUBLESHOOTING GUIDE plug from the receptacle and connect the DC plug of To be able to troubleshoot safely and effectively, another charger, which you know is operating it is important to read this guide completely properly, to the receptacle. -
Page 7: Exploded View
EXPLODED VIEW SERVICE PARTS LIST 25930 Service Part Description 48V 17A Case assembly 35606S Transformer assembly 25935S Fuse assembly 08776S Relay 21238S SCR assembly, blue & brown wires 35332S SCR assembly, violet & white wires 35318S Electronic controller assembly 25855S... -
Page 8: Wiring Diagram
WIRING DIAGRAM www.lesterelectrical.com 35589A www.fairplayelectriccars.com...
Need help?
Do you have a question about the 25930 and is the answer not in the manual?
Questions and answers