Page 1
THE POWER BEHIND THE BIKE Lafree Europe began life in June 1999 as an independent division of Giant Europe. In terms of experience, we couldn't have a bigger name behind us. Giant is presently the world's largest manufacturer of quality bicycles. The company enjoys an international reputation for constant innovation and has pioneered many of the most advanced developments in bicycle design and manufacturing technology.
Light Emitting Diode (LED) Control Centre (handlebar) ....5 Energy Level Indicator ....20 Position of the Serial Numbers ..6 Automatic Motor Shut-Off ....21 Front Wheel Quick-Release 3. What is LaFree? ......7 Lever Cam........21 Frequently Asked Questions ..7 7.7.1 Adjusting the quick-release mechanism........21 4.
(battery pack/charger unit), VPC Throttle components, or the entire The following trademarks are registered bicycle. trademarks of Lafree in Europe and other countries. Even though Lafree functions as a standard bicycle, you should still review the chapters on •...
WHAT IT’S CALLED VPC-Variable Power Control throttle-right 19. bottom bracket (inside motor housing) side 20. crank arm derailleur/hub gear shifter - left side 21. chainring (inside motor housing) primary frame tube 22. drive chain seat tube 23. pedal chain stay 24.
2.1 Energy set & Diagnostic Readout charger plug/extension cord energy indicator carrying handle Self-Test button key set receptacle/power switch charge level indicator lights FIGURE 2C FIGURE 2B e 1@ 1@ 1# FIGURE 2D 2.2 Control centre (handlebar) Variable Power Control (twist throttle) front brake lever Variable Power Control cable brake adjusting barrel...
Lafree. Lafree’s advanced on-board torque/speed Q: What is the “range” of Lafree’s Energy Set? sensor automatically adjusts to rider input and A: Your range will vary depending on the road determines how much assistance is needed.
Q: How many charges will the Energy Set Q: Can I ride my Lafree in the rain or through accept before needing replacement? puddles? A: Lafree’s lead acid battery can be charged A: Yes. However, you should not spray water from 300-400 times before replacement.
4.1.2.1 Height Adjustment physical examination. If someone else Put your heel on the pedal at its lowest selected a Lafree for you, as a gift, for position. Your leg should be stretched with a example, it is important to have the correct slight bend in the knee.
FIGURE 4D (see Fig. 4C) the seat post may break, which could cause you to lose control and fall. Riding Lafree with the seat post protruding from the frame beyond the Minimum Insertion or Maximum Extension mark can also damage the frame.
Lafree. Here Reflectors are important safety devices which is a simple, sixty-second mechanical safety are designed as an integral part of Lafree. check which you should get in the habit of The reflectors are designed to pick up and making every time you’re about to get on...
If you 4.3.4 Brakes can squeeze the levers so that they touch Lafree offers models with rim brakes (Fig 4E, 4F) and with disc brakes. Visually inspect for your forefinger, you should have a qualified proper cable routing.
If not, replace them. Are the handlebar ends plugged? If not, plug them before you ride. You are now ready to safely ride your Lafree. However, we suggest that you take a few moments to review the following chapters on riding tips and safety, especially if you have not ridden a bicycle in a long time.
(Section 4.3) before you attempt to ride bicycle lighting system which meets Lafree, In addition, make sure that you always national laws and without reflectors is follow the electronic diagnostic procedure for dangerous and can result in accidents.
ELECTRIC ENERGY SET OPERATION 6.1 Charging the Energy Set place Lafree or the Energy Set in direct (lead acid battery) sunlight, near a heat source (water heater, Lafree’s portable Energy Set has a self- furnace, fireplace, etc.), or in contact with contained charger, allowing charging of the moisture while charging (Fig.
6.2.1 Removing, Charging, and Storing Energy Set • Do not park Lafree or place Energy Set in Lafree’s Energy Set can be removed from the direct contact with moisture, sunlight, or a bicycle for easier charging and storage. When heat source while charging.
CAUTION: Store Energy Set in a low, cool, dry, level, secure area with good ventilation and away from any heat source. If storing Lafree with Energy Set in place, turn ignition to OFF position. Leaving ignition in the ON position while stored or parked will result in more rapid energy loss.
• Always pull gently on the charging cord. contact. It is also best not to lay Lafree on its Never yank or extend past its full length. To side in any case, as doing so can cause...
(no power) then twisted counter clockwise again for VPC Throttle to engage. 7.1 Variable Power Control For safety, do not pedal Lafree while the bike (VPC Throttle) is leaned over in a turn and VPC Throttle Lafree’s Variable Power Control (VPC) Throttle engaged, as the pedal may come in contact gives you instant access to the motor’s power...
Start Lafree by turning the key to the ON 7.3 Energy Set Ignition position. Following this, turn the safety switch to the ON position. You should hear an...
Lafree to an diagnostic check, follow the directions below: authorised Lafree dealer immediately. Operating Lafree with the Energy Set on, but • Brake Actuated Motor Shut-Off-Pull on each with any or all of these features inoperable brake lever individually.
2. Understand and apply the correct 7.6 Automatic Motor Shut-Off technique for clamping your wheel Lafree is equipped with four automatic motor in place with a quick-release. shut-off features. 3. Check that the wheel is securely clamped in the fork before each and 1.
7.7.3 Removing Quick-Release Front quick-release lever open accidentally. Wheel However, these tabs are not designed to keep (a) Place Lafree’s support stand in its down the wheel in place should the quick-release and locked position. lever open accidentally. If you hear or feel looseness coming from the front wheel, stop (b) Release the front brake’s elbow cable...
The lever should be parallel to the fork blade/pointing (f). Lafree’s support stand will hold the bike upward and curved toward the wheel. upright, but for additional safety we...
OPEN position. (Fig 7D). 7.8 Seat Post Quick-Release (c) Lift the rear wheel form the ground, and Lafree is equipped with a quick-release seat with the derailleur still pulled back, push post binder for easy seat height adjustment the wheel forward and down until the for a variety of riders.
7.9.1 How brakes work 7.10.1 What the gears are for It’s important to your safety that you Lafree’s gearing is a simple yet effective way instinctively know which brake lever controls to help you fine tune your pedal revolutions, which brake on your bike. The braking action also known as cadence.
7.11.1 Tyres Lafree’s tyres are general-purpose in design, Lafree is equipped with a specially designed made for improved (paved) road surfaces. twist shifter, located on the left side of the They are not designed for unimproved roads handlebar to the inside of the left grip.
Now rotate the pin through the locks (Fig 7L). To ride Lafree again, put your foot in front of the support stand and move the wheel. Make sure not to touch the spokes.
SERVICE & MAINTENANCE NOTE: Technological advances have made Regardless of which option you select, we bicycles and bicycle components more recommend that the first time you work on sophisticated than ever before, and the pace something on your bike, ask your dealer to of innovation is increasing.
Page 29
derailleur pulley bushings. Wipe off excess oil. your dealer check the wheel for tension and Lubrication is a function of climate. Talk to trueness. your dealer about the best lubricants and the recommended lubrication frequency for your • Check the frame (particularly in the area area.
If the tyre is cut, line the inside of the tyre in the WARNING: Riding your Lafree with a area of the cut with something that will resist flat or under-inflated tyre can seriously...
However, it is strongly recommended Lafree dealer or other qualified person will that you do not ride with only one functioning prolong the safe use of your frame and brake, and that you never ride with two non- components.
11. Excluded from the guarantee are defects front fork of the Lafree bicycle are free of resulting from wearing away through material and/or construction defects for a normal usage, as well as defects resulting period of 10 years.