1. Manuals
  2. Brands
  3. CHALET Manuals
  4. Motorhomes
  5. 26PR
  6. User manual

CHALET 26PR User Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
About this Manual ............................................................................................................................ 1-1
Safety Messages Used in this Manual .............................................................................................. 1-1
Pre-Delivery Inspection .................................................................................................................... 1-2
Front Axle Tire Alignment ............................................................................................................... 1-2
Service and Assistance ...................................................................................................................... 1-2
Reporting Safety Defects .................................................................................................................. 1-2
Vehicle Certification Label ............................................................................................................... 1-3
Body and Chassis Specifications ...................................................................................................... 1-4
Tank Capacities ................................................................................................................................. 1-5
Owner Information ........................................................................................................................... 1-6
Emergency Information .................................................................................................................... 1-6
2007 New Vehicle Limited Warranty ............................................................................................... 1-7
General Warnings ............................................................................................................................. 2-1
Driving .............................................................................................................................................. 2-1
Formaldehyde Information ............................................................................................................... 2-1
Propane Gas Leak Detector .............................................................................................................. 2-1
Carbon Monoxide Warning .............................................................................................................. 2-2
Carbon Monoxide Alarm .................................................................................................................. 2-2
Smoke Alarm .................................................................................................................................... 2-3
Fire Extinguisher ............................................................................................................................... 2-3
Emergency Exits ............................................................................................................................... 2-4
Roadside Emergency ........................................................................................................................ 2-4
Jump Starting .................................................................................................................................... 2-5
Engine Overheat ............................................................................................................................... 2-6
Effects of Prolonged Occupancy ...................................................................................................... 2-6
Mold, Moisture and Your Motor Home ............................................................................................ 2-6
Seats .................................................................................................................................................. 3-1
Seat Belts .......................................................................................................................................... 3-2
Child Restraints ................................................................................................................................. 3-3
Keys .................................................................................................................................................. 3-4
Rearview Monitor System ................................................................................................................ 3-4
Mirrors - Exterior ............................................................................................................................. 3-4
Foot-Pedal Parking Brakes ............................................................................................................... 3-5
Rev.0705060828

Table of Contents

Copyright 2006 Winnebago Industries, Inc. All rights reserved.
August 2006
Part No. 132000-25-007

Advertisement

Table of Contents
loading

Related Manuals for CHALET 26PR

Summary of Contents for CHALET 26PR

  • Page 1: Table Of Contents

    Table of Contents INTRODUCTION 1 About this Manual ..........................1-1 Safety Messages Used in this Manual ....................1-1 Pre-Delivery Inspection ........................1-2 Front Axle Tire Alignment ....................... 1-2 Service and Assistance ........................1-2 Reporting Safety Defects ........................1-2 Vehicle Certification Label ....................... 1-3 Body and Chassis Specifications ......................
  • Page 2 Table of Contents Class A Automatic Pull-Button Parking Brakes .................... 3-5 Grade Brake ............................3-5 Over-drive Switch ..........................3-6 Dome Light Switch ........................... 3-6 Hazard Warning Flasher ........................3-6 Battery Boost Switch ........................3-6 Air Conditioner/ Heater – Automotive ..................... 3-7 In-Dash Radio ...........................
  • Page 3 Table of Contents Class A Water Heater By-Pass Valve ......................4-11 Electric Entrance Step ........................4-11 Windows ............................4-12 PROPANE GAS SYSTEM 5 Propane Gas Supply .......................... 5-1 Safe Use of the Propane Gas System ....................5-2 Propane Gas Warnings and Precautions ................... 5-3 Pressure Regulator ..........................
  • Page 4 Table of Contents Class A TV Antenna ............................8-2 TV Signal Amplifier ......................... 8-3 TV Master Power Switch – 12-Volt (Rear Bedroom TV) ..............8-4 Cable TV Hook Up ........................... 8-4 Digital Satellite Television System ....................8-4 Two-Way Radios ..........................8-5 FURNITURE &...
  • Page 5 Table of Contents Class A Preparing Vehicle For Storage ......................11-7 Removal From Storage ........................11-8 Coach Maintenance Chart ......................11-10 Recommended Sealant Application ....................11-13...

  • Page 7: Introduction

    SECTION 1 INTRODUCTION Congratulations! We welcome you to the design without notice, and without exciting world of motor home travel and incurring obligation to install the same camping. You will find it convenient and on products previously manufactured. enjoyable to have all the comforts of home and The materials in your InfoCase contain still enjoy the great outdoors wherever you warranty information and operating and...

  • Page 8: Pre-Delivery Inspection

    SECTION 1 INTRODUCTION Class A SERVICE AND ASSISTANCE WARNING Your dealer will be glad to provide any additional information you need, as well as WARNING indicates a potentially answer any questions you might have about hazardous situation which, if not avoided, operating the equipment in your motor home.

  • Page 9: Vehicle Certification Label

    SECTION 1 INTRODUCTION Class A VEHICLE CERTIFICATION LABEL This label contains vehicle identification and other important reference information.The label is affixed to the armrest panel or wall to the left of the driver seat. Explanation of Data on your vehicle. These pressure levels must be maintained to assure proper handling, safety 1.

  • Page 10: Body And Chassis Specifications

    SECTION 1 INTRODUCTION Class A BODY AND CHASSIS SPECIFICATIONS Model 26PR 29RR 30BR 33TR 34AR 35NR Length (Bumper to Bumper) 27’ 1” 29’ 9” 30’ 11” 33’ 10” 34’ 6” 35’ 0” Exterior Height (w/AC) Ford — 12’ 1” 12’ 3”...

  • Page 11: Tank Capacities

    Model 26PR (Galley, Shower & Lavatory) ........

  • Page 12: Owner Information

    SECTION 1 INTRODUCTION Class A OWNER INFORMATION Owner’s Name _______________________________________________________________________ Street Address ________________________________________________________________________ City and State (or Province in Canada)_____________________________________________________ Motor Home Serial Number _____________________________________________________________ Vehicle Chassis Identification No (VIN) ___________________________________________________ Vehicle Mileage at Time of Delivery ______________________________________________________ Selling Dealer Name and Address ________________________________________________________ ___________________________________________________________________________________ EMERGENCY INFORMATION YOUR WINNEBAGO INDUSTRIES DEALER...

  • Page 13: 2007 New Vehicle Limited Warranty

    SECTION 1 INTRODUCTION Class A 2007 NEW VEHICLE LIMITED WARRANTY WINNEBAGO INDUSTRIES, INC. WARRANTY COVERAGE TO OWNER ITEMS NOT SUBJECT TO WARRANTY COVERAGE Chassis, drivetrain and related components* Winnebago Industries, Inc. of Forest City, Iowa, (“Winnebago”) Wheels* warrants each new Winnebago and Itasca recreational motor home Tires* to the owner for use in the U.S.A.
  • Page 14 SECTION 1 INTRODUCTION Class A OBTAINING WARRANTY REPAIRS CALIFORNIA: Winnebago Industries participates in the Consumer Arbitration While any Winnebago Industries motor home dealer can perform Program for Recreation Vehicles (CAP-RV). This third-party dispute warranty service, we recommend you return to the dealership that resolution program is available, at no charge to you, to settle sold you your vehicle.

  • Page 15: Safety/Precautions

    SECTION 2 SAFETY/PRECAUTIONS not been affected. Never operate any vehicle if a difference in braking efficiency is GENERAL WARNINGS noticeable. • Only seats equipped with seat belts are to be • Adverse weather conditions and extremes in occupied while the vehicle is moving. terrain may affect handling and/or •...

  • Page 16: Carbon Monoxide Warning

    SECTION 2 SAFETY/PRECAUTIONS Class A Further Information See the manufacturer’s information in your InfoCase for further instructions on nuisance alarms and care and testing of the propane gas leak detector. CARBON MONOXIDE WARNING Propane Gas Leak Detector WARNING Avoid inhaling exhaust gases, as they WARNING contain carbon monoxide, which is a colorless, odorless and poisonous gas.

  • Page 17: Smoke Alarm

    SECTION 2 SAFETY/PRECAUTIONS Class A detect toxic carbon monoxide gas fumes resulting from incomplete combustion of fuel. It will detect CO gas from any combustion source such as the furnace, gas range/oven, water heater, refrigerator, chassis engine, and electric generator engine. Press button to test Press button to test Carbon Monoxide Alarm...

  • Page 18: Emergency Exits

    SECTION 2 SAFETY/PRECAUTIONS Class A We also recommend that you inspect the fire extinguisher for proper charge at least once a WARNING month in accordance with National Fire Protection Association (NFPA) recommendations as stated on the label. This window should be kept closed while driving to avoid drawing dangerous If the charge is insufficient, the fire exhaust gases into the vehicle.

  • Page 19: Jump Starting

    SECTION 2 SAFETY/PRECAUTIONS Class A Never get beneath a vehicle that is held up by Winnebago Industries does not assume a jack only. responsibility for damage incurred while towing this vehicle. If You Get A Flat Tire NOTE: Consult the chassis operating guide for •...

  • Page 20: Engine Overheat

    SECTION 2 SAFETY/PRECAUTIONS Class A Ventilate with outside air: ENGINE OVERHEAT Partially open one or more windows and a roof vent to circulate outside air through the If you see or hear steam escaping from the coach. In cold weather, this ventilation may engine compartment or have any other reason to increase use of the furnace, but it will greatly suspect an extreme engine overheating condition,...
  • Page 21 SECTION 2 SAFETY/PRECAUTIONS Class A process to begin. Keep the environment as clean motor home users lack of timely and appropriate as possible. Vacuum the carpet. Clean food spills action to mitigate circumstances should a thoroughly and quickly. Avoid grease buildup problem occur.

  • Page 23: Driving Your Motor Home

    SECTION 3 DRIVING YOUR MOTOR HOME The information in this section refers only to features installed or adapted to the dash and Lift to Recline driver compartment area by Winnebago Industries. See your chassis owner’s manual for all original chassis related controls, instrumentation, switches and other features.

  • Page 24: Seat Belts

    SECTION 3 DRIVING YOUR MOTOR HOME Class A Arm Rest Adjustment The driver and co-pilot seat armrests may be adjusted to rest at two different positions as shown. Position 1 Raise armrest, push in toward seat, and lower into position. This position would generally be used when the seat is in the upright position.

  • Page 25: Child Restraints

    SECTION 3 DRIVING YOUR MOTOR HOME Class A Unfastening: accident or during a sudden maneuver. Children may be injured in an accident if they are seated in Press the release button in the buckle. Hold a child restraint which is not properly secured. onto the tongue when you release it from the A child restraint system is designed to be buckle to keep it from retracting too rapidly.

  • Page 26: Keys

    SECTION 3 DRIVING YOUR MOTOR HOME Class A Select the mirror to be adjusted by pushing the switch in the middle of the control to the right or KEYS left. Then press the arrow buttons as necessary to Your motor home is supplied with several sets obtain the best view.

  • Page 27: Foot-Pedal Parking Brakes

    SECTION 3 DRIVING YOUR MOTOR HOME Class A FOOT-PEDAL PARKING GRADE BRAKE BRAKES Workhorse 20,700 GVWR chassis and greater only 16,000 & 20,700 lbs GVWR Workhorse Chassis-All Ford This feature will enable the transmission to Chassis control the speed of the vehicle on long downhill grades to help avoid brake overheating and The parking brake foot pedal and release lever unnecessary brake wear.

  • Page 28: Over-Drive Switch

    SECTION 3 DRIVING YOUR MOTOR HOME Class A OVER-DRIVE SWITCH WARNING Workhorse 20,700 GVWR chassis and greater only Operating the hazard warning flasher system while moving on the highway is The Overdrive Switch allows you to illegal. deactivate the automatic overdrive feature of the transmission when necessary.

  • Page 29: Air Conditioner/ Heater - Automotive

    SECTION 3 DRIVING YOUR MOTOR HOME Class A Aux Fan Switch AIR CONDITIONER/ HEATER – - Optional AUTOMOTIVE The two-speed auxiliary fans are intended to assist the automotive windshield defroster Controls for the air conditioner, heater, system in clearing fog and frost in cold weather defroster and vent are all combined into one or humid conditions.

  • Page 30: Cb Radio Wiring

    SECTION 3 DRIVING YOUR MOTOR HOME Class A Radio Power Switch The radio power switch lets you connect the dash radio to the coach batteries with the ignition switch turned off for listening while parked. This prevents accidental draining of the chassis (starting) battery with prolonged use of the radio.

  • Page 31: Engine Access

    SECTION 3 DRIVING YOUR MOTOR HOME Class A • To reinstall the cover, position the front end of the cover first, then lower the rear end. It is ENGINE ACCESS important to be sure the front edge is pushed completely forward to the radiator cover to Hood ensure an air-tight seal.

  • Page 32: Tires

    SECTION 3 DRIVING YOUR MOTOR HOME Class A Out-of-balance tires will not roll smoothly and can lead to vibrations and uneven tread wear such TIRES as cupping and flat spots. Tires may need to be Improper tire pressure can result in tire balanced if uneven wear is detected or if ride overloading and abnormal wear and also affects comfort decreases noticeably.

  • Page 33: Loading The Vehicle

    SECTION 3 DRIVING YOUR MOTOR HOME Class A Gross Vehicle Weight Rating (GVWR). The Chassis supplied Fuse Panel Gross Axle Weight Rating (GAWR) means the See Chassis Owner’s Manual for Information weight value specified by the chassis manufacturer as the load carrying capacity of a single axle system as measured at the tire-to- ground interfaces.

  • Page 34: Roof Loading

    SECTION 3 DRIVING YOUR MOTOR HOME Class A You will first drive only your front wheels onto the scale pad, then drive ahead so that the ROOF LOADING whole vehicle is on the scale, then finally pull off The roof is capable of carrying up to 10 until just the rear wheels are on the pad.

  • Page 35: Car Or Trailer Towing

    SECTION 3 DRIVING YOUR MOTOR HOME Class A Corner Weighing (Side-to-Side) GAWR. For example, if the GAWR for the rear axle is 12,000 lbs., then the load on each rear dual The most accurate method of weighing a set (left rear duals or right rear duals) should not motorhome is to weigh each ‘corner’...

  • Page 36: Trailer Wiring Connector

    SECTION 3 DRIVING YOUR MOTOR HOME Class A Towing will affect vehicle handling, durability and fuel economy. Exceeding any of CAUTION the listed Gross Weight Ratings will result in unacceptable overall vehicle performance. Maximum safety and satisfaction when towing Exceeding any of the recommended depends on proper use of correct equipment.

  • Page 37: Towing Guidelines

    SECTION 3 DRIVING YOUR MOTOR HOME Class A Hitch Ratings: TOWING GUIDELINES SAE Standard J684 defines Class 1 trailers as “GVWR not to exceed Gross Vehicle Weight Rating 2,000 lbs.”; (GVWR): Class 2 trailers as “GVWR over 2,000 lbs. and not to exceed 3,500 lbs.

  • Page 38: Tools & Ladder Storage

    SECTION 3 DRIVING YOUR MOTOR HOME Class A downshifting. Select the lowest adequate gear range for the duration of the incline. See your chassis operating guide for specific information. CAUTION Observe the engine temperature gauge more frequently than normal. If overheating occurs, pull off to the side of the road and allow the engine to thoroughly cool before refilling the...

  • Page 39: Storage Compartment Doors

    SECTION 3 DRIVING YOUR MOTOR HOME Class A • Always store the ladder extension when not To ensure that exterior storage compartment in use. doors have latched properly, press firmly on the bottom edges of the doors with the palms of your •...

  • Page 41: Appliances & Systems

    SECTION 4 APPLIANCES & SYSTEMS Leveling The appliances installed in your motor home are manufactured by reputable RV appliance Before operating the refrigerator when the makers and have been tested by independent motor home is stationary, place a small level on laboratories to meet all applicable standards and the freezer plate and make certain the unit is codes set for RV appliances.

  • Page 42: Refrigerator Service Access Compartment

    SECTION 4 APPLIANCES & SYSTEMS Class A REFRIGERATOR SERVICE RANGE AND OVEN ACCESS COMPARTMENT - Exterior The exterior refrigerator compartment allows access to the rear of the refrigerator for inspection, maintenance and service. The range in your motor home operates on propane gas.

  • Page 43: Microwave Oven

    SECTION 4 APPLIANCES & SYSTEMS Class A SYSTEMS MONITOR PANEL WARNING Portable fuel-burning equipment including wood and charcoal grills and stoves, should not be used inside the recreational vehicle. The use of this equipment inside the recreational vehicle may cause fires or asphyxiation. MICROWAVE OVEN For complete operating instructions, refer to the manufacturer’s information provided in your...

  • Page 44: Energy Management System (Ems)

    SECTION 4 APPLIANCES & SYSTEMS Class A The approximate fluid levels are measured by • Red - battery needs charging before use. electronic sensors on the sides of the tanks. There To get an accurate reading; is generally more fluid in a tank than indicated on 1.

  • Page 45: Propane Gas Furnace

    SECTION 4 APPLIANCES & SYSTEMS Class A 2. Move THERMOSTAT switch from Off to Heat and press the Temp Selector button (Up/ Down arrows) until the desired temperature is shown in the display. 3. Furnace fan should start to blow immediately after setting the thermostat.
  • Page 46 SECTION 4 APPLIANCES & SYSTEMS Class A alarm. We do not recommend removing the smoke alarm battery. Further Information Please see the furnace operating instructions provided in your InfoCase for further information, including operating precautions, and periodic maintenance. See the Coach Maintenance Schedule in Section 11 for recommended intervals.

  • Page 47: Thermostat Operation

    SECTION 4 APPLIANCES & SYSTEMS Class A THERMOSTAT OPERATION The following chart shows the system functions with the “Heat/Cool” thermostat. Disregard references to heat functions when using the “Cool Only” thermostat in the rear bedroom. The furnace thermostat also controls ducted roof HEAT PUMP air conditioner operation when the thermostat - Optional...

  • Page 48: Ducted Roof Air Conditioning System

    SECTION 4 APPLIANCES & SYSTEMS Class A extract heat from the outside air on a cold day and • Be sure ceiling vents are open to distribute carry it to the inside of the coach to maintain a heat pump output air. comfortable temperature.

  • Page 49: Gas/ Electric Water Heater

    SECTION 4 APPLIANCES & SYSTEMS Class A • If you are using the shoreline, the switch must means you can have hot water at the faucets be in POWERCORD position. immediately upon arriving at a site, or even while driving if needed. •...

  • Page 50: Pressure-Temperature Relief Valve

    SECTION 4 APPLIANCES & SYSTEMS Class A The energy management system (EMS) will 2. Turn electric water heater switch off. shut down the electric water heater element while 3. Turn off propane gas supply (if not to be used the microwave oven is being used to avoid an for extended period).

  • Page 51: Water Heater By-Pass Valve

    SECTION 4 APPLIANCES & SYSTEMS Class A To Replace the Air Gap: 1. Turn off the water heater switch and incoming water supply (city water and/or demand pump). 2. Open a faucet in the motor home to relieve water pressure. 3.

  • Page 52: Windows

    SECTION 4 APPLIANCES & SYSTEMS Class A Further Information For additional information on the step, see the manufacturer’s operators manual included in WARNING your InfoCase. Do not use step unless fully extended. Do Not Stand on step when vehicle’s WINDOWS ignition switch is turned to either the “On”...
  • Page 53 SECTION 4 APPLIANCES & SYSTEMS Class A Vertical Slider Windows Vertical slider windows have spring-loaded catches on both sides of the window that pop out to hold the window in its fully raised position. Press the catches outward toward the frames while lowering the window.

  • Page 55: Propane Gas System

    SECTION 5 PROPANE GAS SYSTEM PROPANE GAS SUPPLY WARNING The propane gas system supplies fuel for the range, water heater, furnace and refrigerator (while in gas mode). When used and handled Do not alter or remove propane tank properly, this system is safe and economical and gauge at any time.

  • Page 56: Safe Use Of The Propane Gas System

    SECTION 5 PROPANE GAS SYSTEM Class A Check local phone directory yellow pages for locations of local propane gas refilling stations or bulk dealerships. DAN GE R NOTE: If you travel outside the U.S. with your motor home, you may find butane or DO NOT FILL CONTAINER TO MORE propane/butane mixtures available in THAN 80 PERCENT OF CAPACITY.

  • Page 57: Propane Gas Warnings And Precautions

    SECTION 5 PROPANE GAS SYSTEM Class A Listed below are a few precautions to observe that will help you to use the propane gas system PROPANE GAS WARNINGS safely. AND PRECAUTIONS • Exercise caution at all times. Be familiar with It is illegal for vehicles equipped with propane the distinctive odor of propane gas.

  • Page 58: Pressure Regulator

    SECTION 5 PROPANE GAS SYSTEM Class A safety valves which relieve excessive pressure by discharging gas to the atmosphere. • Never use an open flame to test for propane gas leaks. Replace all protective covers and caps on propane system after filling. Make sure valve is closed and door latched securely.

  • Page 59: Cold Weather Propane Vaporization

    SECTION 5 PROPANE GAS SYSTEM Class A To help avoid the possibility of freeze-up, always keep tank control valve closed when not in use, even when tank is empty, to prevent moisture from collecting on the inside. If regulator freeze-up should occur, you may attempt to thaw the regulator using a light bulb.

  • Page 61: Electrical

    SECTION 6 ELECTRICAL Your coach is equipped with an electrical cord is connected to an outside power source, or system consisting of two separate voltages; a 12- when the generator is in operation, the power volt DC system and a 110-volt AC system. The converter automatically changes a portion of the 12-volt system consists of two internal power 110-volt current to 12-volt DC current.

  • Page 62: Power Center

    SECTION 6 ELECTRICAL Class A Connecting the Power Cord To connect to an external source, remove the cord from the utility compartment and plug it into a suitable power outlet to provide external power to the coach and converter/charger system. 1.

  • Page 63: Circuit Breakers - 110V Ac

    SECTION 6 ELECTRICAL Class A Thermal Overload Certain circuits, however, remain unchanged for use by items which require 110-volt current, A thermal overload will “break” the 110-volt such as the air conditioner(s), the refrigerator in AC power to the converter section of the Power AC mode, the microwave oven, etc.

  • Page 64: Receptacles (Outlets) - 110V

    Should this occur, unplug all the appliances on that circuit and press the reset button on the GFCI 110-Volt Circuit Breakers equipped outlet. Models 26PR, 29RR, 30BR If the GFCI keeps tripping, have the electrical system checked and repaired, if necessary, before using again.

  • Page 65: Generator - Auxiliary 110V Ac

    SECTION 6 ELECTRICAL Class A Generator Operation GENERATOR – AUXILIARY Consult the information provided in your 110V AC InfoCase for instructions on operation, troubleshooting and maintenance. Generator Hourmeter WARNING This meter is located on the monitor panel. It registers the total number of hours that the generator has been operated.

  • Page 66: Electrical System - 12V Dc

    SECTION 6 ELECTRICAL Class A Check auxiliary generator oil level frequently power than standard automotive batteries, and during periods of use. Refer to the generator will withstand the frequent drain-and-recharge manufacturer’s information in your InfoCase for cycles that occur under the demanding conditions specific recommendations.

  • Page 67: Battery Care

    SECTION 6 ELECTRICAL Class A If a battery does not contain at least 80% charge during freezing temperatures, the electrolyte can freeze and crack the battery case. The two best defenses against sulfating and insufficient charge are to: 1. Turn off the AUX BATT switch to avoid parasitic discharge (the trickle discharge caused by directly connected components like propane gas leak detectors or digital clock...

  • Page 68: Fuses And Circuit Breakers - House 12V Dc

    SECTION 6 ELECTRICAL Class A To ensure that the battery will always accept and hold a charge, follow these simple WARNING maintenance practices. • Make sure the batteries always remain securely clamped in the battery tray. To prevent wiring damage, it is essential when replacing the cables on the battery, •...
  • Page 69 House Fuses Circuit Breakers Good Fuse Bad Fuse Load Center Shown for Models 26PR, 29RR, 30BR 12-Volt Circuit Breakers 110-Volt Circuit Breakers Shown for Models 33LR, 34AR, 35NR The fuse panel accepts only blade type plug-in fuses. Always replace fuses with those of the...

  • Page 71: Plumbing

    SECTION 7 PLUMBING Pressure Fill from City Water Connection FRESH WATER SYSTEM 1. Attach hose to city water connector. The fresh water system provides water to the galley sink, shower, bathroom lavatory, toilet and water heater. Water may be supplied by either of two sources: •...

  • Page 72: Water Pump

    SECTION 7 PLUMBING Class A City Water Use WATER PUMP Connect hose to city water connection as described in previous steps. Turn Fresh Water When your coach is not connected to a city Valve to Normal position and turn demand water water supply, water is supplied from the fresh pump switches OFF.

  • Page 73: Disinfecting Fresh Water Systems On Rvs

    SECTION 7 PLUMBING Class A To Clean Pump Strainer DISINFECTING FRESH WATER Be sure all water pump switches are OFF. SYSTEMS ON RVS • Twist the inlet cap (bowl) counterclockwise to unscrew from the strainer assembly. (As approved by the U.S. Public Health Service) •...

  • Page 74: Shower Hose Vacuum Breaker

    SECTION 7 PLUMBING Class A SHOWER HOSE VACUUM BREAKER After using the shower, you may notice water dripping from the shower faucet assembly. The dripping results when vacuum in the shower hose (after closing the shower faucet) slowly releases and allows water remaining in the hose to drain down.

  • Page 75: Waste Water System

    SECTION 7 PLUMBING Class A 4. Open the black water valve (black handle) with a quick pull and make sure there are no WASTE WATER SYSTEM sags in the hose. Move the hose gently about to dislodge any waste and ensure complete (Holding Tanks) drainage.

  • Page 76: Holding Tank Level Indicators

    SECTION 7 PLUMBING Class A When using a sewer hook-up, keep the dump valves closed until a tank becomes full or when preparing to leave the site. This keeps the solids in suspension, allowing them to be carried out with the liquids when the dump valve is opened. If the valve is left open, the liquids will drain off, leaving solids in the tank.

  • Page 77: Water System Drain Valve Locations

    SECTION 7 PLUMBING Class A WATER SYSTEM DRAIN VALVE LOCATIONS Model System Drain Valve Locations 30BR & 33LR Water Lines Open exterior shower faucet and lay shower head on ground. Also place the tip of your finger inside the city water connection and gently press the backflow valve (small “button”...
  • Page 78 Drain plug on outside of coach, behind service door. Use socket to remove drain plug. Water Heater 26PR: Beneath galley cabinet - open cabinet door under Bypass Valve galley sink to access. 29RR: Beneath galley cabinet - remove drawer on right- hand side to access.

  • Page 79: Winterizing Procedure

    SECTION 7 PLUMBING Class A Siphon Tube Winterizing Valve Model 35NR shown Winterization Valve beneath rear bed Models 30BR & 33LR WINTERIZING PROCEDURE Blow Out Procedure 1. Level the motor home and drain the entire Models 29RR & 35NR shown plumbing system as described in the following steps.
  • Page 80 SECTION 7 PLUMBING Class A Lift handle only when water heater is cold 7. After water has stopped draining at all faucets 4. Turn on water pump and open all sink faucets and drain valves, leave faucets open and and shower head knobs. Leave open after connect a “blow-out”...
  • Page 81 SECTION 7 PLUMBING Class A 10. Now turn air pressure off and disconnect • Turn water heater by-pass valve to BY-PASS water purge adapters. Recap the city water position. connection to avoid contamination by dirt or • Remove and save the protective cap from the insects.
  • Page 82 SECTION 7 PLUMBING Class A • Replace the protective cap onto the end of the 4. Empty the water pump strainer filter bowl to suction tube to keep out insects and debris avoid water freezing and cracking the filter when not in use. bowl.

  • Page 83: Entertainment

    SECTION 8 ENTERTAINMENT Inverter Video Selector To Watch Broadcast TV (Antenna) • Press TV ANT button on MAIN TV section of Video Selection System panel. To Watch Cable TV DVD/VCR or Home Theater • Press CABLE TV button on MAIN TV section of Video Selection System panel.

  • Page 84: Front Tv Ignition Switch Interlock

    SECTION 8 ENTERTAINMENT Class A The inverter is typically located in the video center cabinet or on the lower face of the galley FRONT TV IGNITION SWITCH cabinet. INTERLOCK If your coach is equipped with a front overhead TV, it is plugged into a special electrical outlet with a built-in ignition switch interlock.

  • Page 85: Tv Signal Amplifier

    SECTION 8 ENTERTAINMENT Class A volt DC from the TV signals and provides a place for attaching the TV set and the 12-volt power source. Operation Turn elevating crank (counterclockwise) in Raising Antenna “DOWN” direction until resistance is noted. Antenna is now locked in travel position. Turn Turn elevating crank clockwise in “UP”...

  • Page 86: Tv Master Power Switch - 12-Volt (Rear Bedroom Tv)

    SECTION 8 ENTERTAINMENT Class A usable signal at all. We recommend that the TV Exterior Connection for Satellite system be checked out in an area known to have Dishes and Cable TV good TV reception. (In Utility Compartment) To check the antenna amplifier, raise the antenna, select a TV channel and rotate the antenna for best picture.

  • Page 87: Two-Way Radios

    SECTION 8 ENTERTAINMENT Class A TWO-WAY RADIOS - Optional If your coach is equipped with the available two-way radios, the charger/docking bay is located on a cabinet end near the entrance door - for easy access as you head out the door. We recommend that you read the satellite dish manual thoroughly to understand the system completely before attempting any setups or...

  • Page 89: Furniture & Softgoods

    SECTION 9 FURNITURE & SOFTGOODS SWIVEL GLIDER LOUNGE CHAIR This chair is not equipped with a seat belt and is not intended for seating while the coach is in motion. The chair has a glide-lock mechanism to prevent chair movement while the coach is moving.

  • Page 90: Couch/Bed Conversion

    SECTION 9 FURNITURE & SOFTGOODS Class A COUCH/BED CONVERSION Couch to Bed: Lift the front edge of the couch seat upward and pull outward from the wall while gently pushing downward on the backrest until the cushions lie flat. The bed is now ready for use. Bed to Couch: Push the front edge of the seat toward the wall while lifting upward on the backrest until the...

  • Page 91: Day/ Nighter Pleated Blinds

    SECTION 9 FURNITURE & SOFTGOODS Class A DAY/ NIGHTER PLEATED BLINDS Your coach may feature two-stage pleated window blinds that can be used for daytime or nighttime privacy. Sun Shade The lower section is a translucent white shade that can be lowered for privacy without darkening the inside of the coach.

  • Page 92: Wood Furniture And Cabinetry

    SECTION 9 FURNITURE & SOFTGOODS Class A After replacing the battery, place the clock Stains are likely to exaggerate the difference back into the socket with the 12 at the 9 o’clock between open and closed grains and other position as shown, then rotate clockwise so it is markings in wood.

  • Page 93: Slideout / Leveling

    SECTION 10 SLIDEOUT / LEVELING GENERAL SLIDEOUT / SLIDEOUT ROOM OPERATION LEVELING WARNINGS The slideout living room provides a spacious living area at the push of a button. The slideout • Do not use the coach leveling system as a lift room is extended and retracted using a motorized for changing tires or working under the mechanism with an electronic control system.
  • Page 94 SECTION 10 SLIDEOUT / LEVELING Class A • Unhook the strap end peg from the mooring bracket on the floor and wall edge. Store strap WARNING in location of your choice. (Under the couch is one choice.) Keep all persons clear of the slideout room and moving parts while extending or retracting.

  • Page 95: Slideout Room - Extreme Weather Precaution

    SECTION 10 SLIDEOUT / LEVELING Class A To Retract the Slideout Room See “Before Retracting the Slideout Room” before proceeding. To retract the room, press and hold the “IN” button. Press and Hold Press and Hold to Extend to Retract •...

  • Page 96: Slideout Troubleshooting

    SECTION 10 SLIDEOUT / LEVELING Class A SLIDEOUT CAUTION TROUBLESHOOTING Never let one side get more than 2 inches Problems Retracting the Room (50 mm) ahead of the other while Set the Park Brake if the red Park Brake light retracting.

  • Page 97: Bedroom Slideout

    Green light will flash error code, BEDROOM SLIDEOUT if system malfunctions Emergency Retraction Procedure Models 26PR, 29RR, 34AR & 35NR 1. Locate the tools in the right front side storage compartment - a ratchet wrench, a hex-end shaft and an extension shaft. (The ratchet wrench may be packaged in the InfoCase.)

  • Page 98: General Slideout Care

    SECTION 10 SLIDEOUT / LEVELING Class A 4. The slotted end of the tool must engage with the pin in the endshaft on the slideout gear assembly. See arrow in close-up detail. GENERAL SLIDEOUT CARE • Wipe outer seals occasionally with talc or 303 brand protectant for smooth quiet operation.
  • Page 99 SECTION 10 SLIDEOUT / LEVELING Class A CAUTION Do not rely only upon the warning lights to indicate when jacks are up. It is the owner’s responsibility to check that all jacks are up before moving the coach. Jacks Down Light See the Leveling System Operator Manual in The “Jacks Down”...

  • Page 101: Maintenance/Storage

    SECTION 11 MAINTENANCE/STORAGE SEALANTS CAUTION Water is a recreational vehicle’s worst enemy when it is allowed to enter where it’s not Sealants must be inspected every 6 intended. Sealants perform a very important months and replaced if necessary. function and should be inspected closely and maintained regularly.

  • Page 102: Exterior Finish

    SECTION 11 MAINTENANCE/STORAGE Class A Waxing and Polishing of hydraulic hoses and wire harnesses to avoid kinks or leaks and pinched wires, When water will not bead up and roll off the etc. finish of your freshly washed vehicle, it’s time to apply a new coat of wax to the finish.

  • Page 103: Plastic Parts - Cleaning

    SECTION 11 MAINTENANCE/STORAGE Class A • ‘Pine’ type household cleaners PLASTIC PARTS - CLEANING Do not use cleaners containing the following products, compounds or solvents. These products Many parts in your motorhome, such as the will damage the finish dash, exterior light lenses, and certain exterior •...

  • Page 104: Interior Soft Goods

    SECTION 11 MAINTENANCE/STORAGE Class A Because they are not sealed, under ‘dew point’ areas. For best results, fabric cleaning should be conditions the headlights may exhibit signs of referred to a professional carpet and upholstery humidity condensation on the reflector surface cleaner.

  • Page 105: General Stains

    SECTION 11 MAINTENANCE/STORAGE Class A General Stains Most commercially available carpet and upholstery cleaners will do an excellent job As with any stain or contamination, the quick removing stains. From time to time, additional response is the best, especially when done in cleaning methods may need to be used to remove conjunction with the proper cleaner for the type stubborn or difficult stains.

  • Page 106: Cabinetry

    SECTION 11 MAINTENANCE/STORAGE Class A CABINETRY Wooden items may be cleaned with a soft cloth and a good quality wood finish cleaning product. Vinyl simulated wood panels may be cleaned with a mild, water based cleaner and a soft cloth. Do not use solvents on vinyl wood panels.

  • Page 107: Bathroom

    SECTION 11 MAINTENANCE/STORAGE Class A BATHROOM The tub and shower walls in the bathroom should be cleaned with a mild soap and water solution. Do not use an abrasive cleaner on the shower walls and tub. The lavatory sink is made of the same composite material as the galley sink.

  • Page 108: Removal From Storage

    SECTION 11 MAINTENANCE/STORAGE Class A Clean and Prep Coach for Storage 7. Have the vehicle chassis completely serviced and lubricated. Be sure radiator antifreeze 1. Turn off the propane gas tank. protection level is sufficient for the lowest 2. Turn the furnace thermostat switch OFF. anticipated temperatures.
  • Page 109 SECTION 11 MAINTENANCE/STORAGE Class A 9. After disinfecting and flushing the water lines thoroughly with fresh water, remove the water filter diverter plug and install a new water filter cartridge. Store the diverter for future use. The diverter plug is intended for winterization only.

  • Page 110: Coach Maintenance Chart

    SECTION 11 MAINTENANCE/STORAGE Class A COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. propane System Have propane system checked for leaks.

  • Page 111: Safety Equipment

    SECTION 11 MAINTENANCE/STORAGE Class A COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items Headlights, Taillights and Marker Lights Turn Signals...
  • Page 112 SECTION 11 MAINTENANCE/STORAGE Class A COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect Replace Frame &...

  • Page 113: Recommended Sealant Application

    SECTION 11 MAINTENANCE/STORAGE Class A RECOMMENDED SEALANT APPLICATION 11-13...
  • Page 115 Index 2007 New Vehicle Limited Warranty ..1-7 Electrical Cautions ........6-1 About this Manual ........1-1 Electrical Inverter ........8-2 Air Conditioner/ Heater – Automotive ..3-7 Electrical System – 110V AC ...... 6-1 Air Springs – Front ........3-10 Electrical System –...
  • Page 116 Index Class A Leveling System ........10-6 Service and Assistance ......... 1-2 Lights ............3-10 Shower Hose Vacuum Breaker ....7-4 Loading the vehicle ........3-11 Sleeping Facilities ........9-1 Microwave Oven .......... 4-3 Slideout Room – Extreme Weather Precaution ..........10-3 Mirrors –...

This manual is also suitable for:

29rr33tr30br35nr34ar

Table of Contents