Summary of Contents for CONTROLMATIK M 4510 C SERIES
- Page 1 I N S T R U C T I O N M A N U A L F O R Chlorine gas leak detector with battery back up series M 4510 C 2007 © Controlmatik ABW d.o.o.
- Page 2 NAV00196 CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60 http://www.contolmatik-abw.si, Email: info@controlmatik-abw.si...
-
Page 3: Table Of Contents
7.0 Reset the alarm relay outputs ................... 13 8.0 The Sensor ......................... 14 9.0 Connection scheme ....................16 10.0 Technical data ......................18 CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60 http://www.contolmatik-abw.si, Email: info@controlmatik-abw.si... -
Page 4: General Description
NAV00196 1.0 General description: The M 4510 C series Controlmatik ABW leek detector is assembled as unit with display, two adjustable alarms and unit fault alarm, power supply module, battery back up and separate detection cell - probe. The detection cell is mounted in IP 65 housing and features 4- 20 mA output which is connected to the signal evaluation unit. -
Page 5: The Unit
The signal gas measuring sensor probe M 2103 C (2) is connected to the signal evaluation unit with display (1). The signal evaluation unit evaluates the signal and displays the value in PPM. CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60... - Page 6 Indicate error messages Set mode Set the parameters for two adjustable set point alarms Check all test functions Menu mode(Only for certificated Controlmatik ABW service) Set all parameters which are important for the normal operation of the device CONTROLMATIK ABW d.o.o.
-
Page 7: Controls And Displays
In combination with key give us access to controller menu. This menu is use only for certificated Controlmatik ABW service! CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60 http://www.contolmatik-abw.si, Email: info@controlmatik-abw.si... - Page 8 This menu is use only for certificated Controlmatik ABW service! In combination with key give scrolling for alarm parameters set CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60 http://www.contolmatik-abw.si, Email: info@controlmatik-abw.si...
- Page 9 In combination with key give access and scrolling for alarm parameters set up CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60 http://www.contolmatik-abw.si, Email: info@controlmatik-abw.si...
-
Page 10: Start Up
Only one sensor is connected! If only one sensor is connected then ERROR sign from the other sensor is not appeared CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60... -
Page 11: Set The Limits For Alarms
With above described procedure, accessing set up for all 4. alarms To exit the alarm limit set up menu push key. Returns back to display mode menu CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60 http://www.contolmatik-abw.si, Email: info@controlmatik-abw.si... -
Page 12: Test Functions
To check activated relay outputs for sensor 1 press To check activated relay outputs for sensor 2 press CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60 http://www.contolmatik-abw.si, Email: info@controlmatik-abw.si... -
Page 13: During Operation
One sensor is working properly and one is in error, they are displayed one after the other. CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60 http://www.contolmatik-abw.si, Email: info@controlmatik-abw.si... -
Page 14: Reset The Alarm Relay Outputs
After reset, the relays will not be actuated again unless the value drops under set point value and rise again to set point value. Controlmatik ABW recommends to connect the neutralisation or sprinkling system to alarm relay OUTPUT 3 at SENSOR 1 or OUTPUT 5 at SENSOR 2. -
Page 15: The Sensor
(20ppm) in couple of seconds. If the bottle is removed for 2 - 3 cm from the sensor, the concentration will be lower and the sensor will rise only for 4 - 5 PPM. At CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60... - Page 16 50 – 70 cm from the ground. If only one probe is used in the chlorine gas storage room than it must be mounted near the gas source for rapid gas detection. CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60...
-
Page 17: Connection Scheme
Connect power supply to left terminal: PE, N, L1 Gas sensor 1 Connect to terminal 14 and 17 Gas sensor Connect to terminal 16 an 18 CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60 http://www.contolmatik-abw.si, Email: info@controlmatik-abw.si... - Page 18 Take off the cap cover Fix the device with screws Remount the clamp cover to obtain the IP65 CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60 http://www.contolmatik-abw.si, Email: info@controlmatik-abw.si...
-
Page 19: Technical Data
M 4510: approx. 2.5 kg M 2103: 0,5 kg Housing protection type: IP 65 Technical data is subject to change without notice! CONTROLMATIK ABW d.o.o. Fajfarjeva 15, 1230 Domžale, Slovenija, Evropa Tel.: 01 721 35 52, Fax.: 01 721 93 60 http://www.contolmatik-abw.si, Email: info@controlmatik-abw.si...
Need help?
Do you have a question about the M 4510 C SERIES and is the answer not in the manual?
Questions and answers