Table of Contents
Advertisement
Quick Links
G43 Pump
Owners
Manual
Check www.compressed-air-systems.com for most up to date manual and compressor service and technical information
CAUTION
READ THIS MANUAL CAREFULLY before operating or servicing this air compressor, to
familiarize yourself with the proper safety, operation, and standard operating procedures of this unit.
FAILURE TO COMPLY WITH INSTRUCTIONS IN THIS MANUAL COULD RESULT IN THE VOIDING OF YOUR
WARRANTY, AND PERSONAL INJURY, AND/OR PROPERTY DAMAGE.
THE MANUFACTURER OF THIS AIR
COMPRESSOR WILL NOT BE LIABLE FOR ANY DAMAGE BECAUSE OF FAILURE TO FOLLOW THE INSTRUCTIONS
IN THIS MANUAL. By following the instructions and recommendations in this manual you will ensure a longer and
safer service life of your air compressor.
If you have questions or need clarification about this manual or your compressor call 800-531-9656
Do not operate compressor outdoors in wet weather
Quality Air Compressor at a Great Price.
Advertisement
Table of Contents
Summary of Contents for Industrial Gold G43
- Page 1 G43 Pump Owners Manual Check www.compressed-air-systems.com for most up to date manual and compressor service and technical information CAUTION READ THIS MANUAL CAREFULLY before operating or servicing this air compressor, to familiarize yourself with the proper safety, operation, and standard operating procedures of this unit.
- Page 2 Compressed air is dangerous, do not play with it. Use the correct lubricant at all times. Always wear proper safety equipment when using compressed air. Always install compressor to all local applicable electric codes. Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com...
- Page 3 Compressed Air Systems, LLC only guarantees that the electric motor, electrical enclosure and electrical conduit are rated for NEMA7 hazardous location. Compressed Air Systems LLC accept no other responsibility for the rating of the package. Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com...
-
Page 4: Troubleshooting Chart
Use IS 100 (30W) compressor oil for cold weather conditions Compressor has wrong grade oil Move compressor to a warmer location Control lines frozen Put a heat lamp on compressor to maintain above freezing temperatures Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com... -
Page 5: Compressor Maintenance
If belts are loose, tighten per instructions on In the same 500 hrs/3 months a reciprocating next page. Failure to tighten can cause pre-mature belt compressors operating temperature may exceed 350 º failure. Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com... -
Page 6: Adjusting Belt Tension
Stop/Start Receiver or plant air system pressure is controlled within limits by a pressure switch automatically stopping and starting the compressor as the air pressure reaches a maximum preset pressure (cut out) and then drops to a minimum presser pressure (cut in). Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com... - Page 7 Under no circumstances should a compressor be placed in an area that may be exposed to a flammable, toxic, volatile or corrosive atmosphere nor should flammable, toxic, volatile or corrosive agents be stored near the compressor. CAUTION CAUTION Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com...
- Page 8 Safety valves are to be place ahead of any potential blockage point which included but is not limited to, shutoff valves, heat exchangers, pulsation dampeners, and discharge silencers. Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com...
-
Page 9: Pressure Vessels
Improper installation of the electrical system can cause the motor to overheat or a short circuit to occur. Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com... -
Page 10: Pressure Switch
Never substitute a check valve for a manual shut-off valve (block valve) if the purpose is to isolate the compressor from a system for servicing. Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com... - Page 11 If for any reason any part of the manual becomes illegible or if the manual is lost, have it replaced immediately. The instruction manual should be periodically read to refresh one’s memory, it may prevent a serious or fatal accident. Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com...
- Page 12 6. Manually activated safety relief valves by pulling ring or lever. 7. Check operation of controls. 8. After two days of operation check belt tension, air piping for leaks, and crankcase oil level. Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com...
- Page 13 LDV51 Air Filter Housing IAT-CA-712140 G43 PUMP Part Number Reciprocating Pump Oil IAT-30100 Air Filter Element IAT-CA-712114 Air Filter Housing IAT-CA-712140 Part numbers subject to change/update always consult factory prior to ordering Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com...
- Page 14 100X1 inch 31.10 L（Shape) 4.72(3.94) inch Bore 120(100) inch 22.05 W（Shape) inch 3.15 Stroke inch 25.59 H（Shape) inch 13.78 Flywheel dia. 335.16 Weight Groove Type MODEL G43 Two Stage Air Compressor Pump Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com...
- Page 15 G43 Pump (SINO-USA) DAFENG LIDA COMPRESSED AIR SYSTEMS CO.,LTD MODEL G43 Two Stage Air Compressor Pump Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com...
- Page 16 SPACER-FLYWHEEL GS43 27 431016 KEY-FLYWHEEL 28 431017 CAPSCREW-HEX M12X40 29 431018 LOCKWASHER Φ12 30 431019 CAPSCREW-HEX M8X30 31 431020 LOCKWASHER Φ8 32 431021 FILTER-INLET ASSEMBLY GS43 MODEL G43 Two Stage Air Compressor Pump Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com...
- Page 17 HOLD DOWN COVER-INLET GS43 60 431044 CAPSCREW-HEX M10X80 61 431036-1 VALVE COPPER GASKET GS33 62 431037-1 HP DISCH VALVE G43 63 431038-1 "O"RING-HOLD DOWN COVER GS33 MODEL G43 Two Stage Air Compressor Pump Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com...
- Page 18 78 431054 INTERCOOLER TUBE GS43 79 431055 INTERCOOLER TUBE G43 80 431056 CAPSCREW-HEX M10X20 81 431057 COOLER LINE STRAP G43 *a 430000-1 GASKET SET G43 MODEL G43 Two Stage Air Compressor Pump Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com...
-
Page 19: Additional Information
On electric driven compressors always follow NEC (National Electric Code) on any local applicable code that exceeds NEC guidelines. On gas/diesel engine driven packages follow engine manufacturer guide for proper placement and installation of engine driven equipment. Industrial Gold Air Compressors | 800-531-9656 | www.industrialgold.com... - Page 20 Quality Air Compressor at a Great Price. 2626 Skyway Drive Grand Prairie, TX, 75052 417-206-6353 800-531-9656 Fax - 417-206-6336 © Industrial Gold, LLC 10-2016...