Summary of Contents for Galaxy vans luxury van
- Page 1 Luxury Van Owner’s Manual 3 Years/36,000 Miles Limited Warranty Waldoch Crafts, Inc. 13821 Lake Drive NE Forest Lake, MN 55025 651-464-3215 or 1-800-328-9259 www.waldoch.com Printed in USA All Rights Reserved...
- Page 2 Important To ensure proper warranty please fill out customer warranty card. To order parts call 1-800-328-9259 Service Department 1-800-328-9259 If your van is covered under warranty, please contact you dealer.
- Page 3 CUSTOMER QUESTIONNAIRE (Please check the appropriate box) Completely Very Somewhat Satisfied Satisfied Satisfied Dissatisfied Comments Overall Exterior Overall Interior Appearance Quality of Workmanship Quality of Materials Seating Audio System Interior Lighting Overall Satisfaction Please Note: For Warranty to be valid, the card below must be filled out completely and mailed to Waldoch Crafts, Inc.
- Page 4 NO POSTAGE NECESSARY IF MAILED IN THE UNITED STATES BUSINESS REPLY MAIL FIRST CLASS MAIL PERMIT NO. 218 FOREST LAKE, MN POSTAGE WILL BE PAID BY ADDRESSEE ATTN: General Manager Waldoch Crafts 13821 Lake Drive NE Forest Lake, MN 55025 FREE T-Shirt Mail Back to Recieve Your FREE Waldoch T-Shirt Small...
- Page 5 Roughneck ELAN ELAN A ple Van Partnerships...
-
Page 6: Table Of Contents
Table of Contents Introduction Congratulations ..............1 Introduction ................2 Warranties Limited Warranty ..............3-7 How the Item in Your Conversion Van Operate Self-Protecting (FETs) Electrical Panel ......8 Overhead Console ...............9 Driving Lights ................9 TV Listening ................. 10 Rear Radio ................10 DVD ..................10-11 Low Top Monitor/DVD Combo ........ -
Page 7: Congratulations
Waldoch travel. To be sure that you receive the full benefits of each feature included in your Waldoch Luxury Van, please read the following owner’s manuals carefully. The easy-to-read instructions will explain the proper operation of each convenient Waldoch feature. Safety tips will help you take the necessary precautions to keep your family and passengers safe and sound. -
Page 8: Introduction
Introduction All information and specifications in this owner’s manual are current at the time of printing. However, due to Waldoch Vans continued commitment to product development, we reserve the right to make changes at any time without notice or obligation. If you have any questions about your van after reading through this manual, please contact the dealer from whom you purchased the van. -
Page 9: Limited Warranty
Limited Warranty: Van Conversions Waldoch Crafts, Inc. warrants to the original retail buyer all items that it adds to an automotive van or light truck chassis as part of its conversion package (unless classified below as not covered), to be free from defects in materials used and workmanship rendered for a period of thirty-six (36) months from date of initial sale to retail buyer (unless further limited - see below) or thirty-six thousand (36,000) miles, whichever comes first. - Page 10 Cosmetic or surface defacing and/or corrosion (resulting from stone chips or scratches in paint, for example) is not included in warranty coverage. There is no warranty coverage for damage caused by airborne fallout (such as chemicals, tree sap, stones and hail). No conversion or vehicle which has been customized, altered, or to which any additional has been made in any manner after it has left Waldoch, other than authorized in writing by Waldoch, will be warranted by Waldoch.
-
Page 11: Warranties
Owner agrees to let Waldoch or its designated representative inspect the subject conversion van at reasonable times to determine whether a defect in its conversion exist and, if so, the proper remedy for it. 9. Customizing/Alterations: Waldoch warrants its conversion vans to Waldoch’s specifications, as amended from time to time. - Page 12 ALL EXPRESS OR IMPLIED WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE, OR OTHERWISE. IF ANY IMPLIED WARRANTIES ARISE UNDER STATE LAW IN CONNECTION WITH THE SALE BY WALDOCH OF ANY NEW VAN CONVERSION, THEY SHALL BE LIMITED IN DURATION TO THE DURATION OF THIS WARRANTY.
- Page 13 I have received and read a copy of this Agreement, and I may review it with my attorney before signing. I and anyone making claims on my behalf, or through me, shall submit any and all claims I may have in connection with my conversion vehicle (CV) against any retail dealer, manufacturer, or supplier of component parts, to binding arbitration under the federal Arbitration Act, 9 U.S.C.
-
Page 14: How The Item In Your Conversion Van Operate Self-Protecting (Fets) Electrical Panel
Electrical Panel Your van is equipped with an Electrical Panel that DOES NOT require fuses. Features of the Electrical Panel include: • Self-Protecting FETs • Built-In Programmable Diagnostics • Rear Sofa Safety Feature (The sofa may only be operated while the vehicle is NOT in motion) •... -
Page 15: Overhead Console
Overhead Console The front overhead console in your van will be equipped with a unique arrangement of switches. This arrangement is determined by the options installed in your van. These switches operate items such as indirect lights, cabinet lights, a rear radio, fog lights and the sunroof. -
Page 16: Tv Listening
TV Monitor Listening* Speaker Button TV Power Button If your van is equipped with a TV Monitor Sound System, you have two ways to listen. You can listen through the speakers located in the ceiling or through the cordless headphones (option), which are on at all times. This switch turns the overhead speakers on and off. -
Page 17: Low Top Monitor/Dvd Combo
The ignition switch must be in the “ON” position before using any of these components. Please note the TV reception will be poor when vehicle is in motion. Vehicle motion and variations in electric current may cause the picture to “roll” or produce a “snowy” effect on the picture. -
Page 18: Indirect Lighting
TV in the High Top Van* Please refer to the operating instructions supplied in your “Care Package” for the particular electronic component installed in your van. Indirect Lighting Indirect lighting supplies soft, moderate lighting throughout the vans interior. The lights are located in valances, window sills and optional ceiling slats controlled by a switch in the overhead console. -
Page 19: Apple Computer Package
Apple Computer Package* Your High-Top Waldoch Conversion may be equipped with the Apple Package option. In the Apple package, where a TV screen would go, is replaced with an apple computer. The computer is then controlled by a wireless mouse and keyboard. The system will only turn on when the monitor button is pushed on the front ovearhead control switch. - Page 20 Wireless Mouse & Keyboard* The wireless mouse and keyboard are located conveniently overhead next to the other storage panels, usually on the passenger side. These battery powered devices need to be turned on before use and turned off to save battery life. Audio Surround Sound System* The Audio Surround Sound System is an upgrade from the factory system and includes a subwoofer usually located behind the rear sofa.
-
Page 21: Pleated Shades
Pleated Shades Optional pleated shades are installed on some vans. These are adjusted by sliding the shade up or down as desired. Hidden Shades* Hidden Shades are included as a Platinum Package Option. These are adjusted by pulling the shade up and securing to the hooks mounted at the top edge of the window. -
Page 22: Six-Way Power Front Seats
Six-Way & Power Recline Front Seats* Optional six-way power and or power recline seats are available on Waldoch Luxury Vans. They are controlled by the switches located on the lower outside section of the seat. The operation of each switch is described in the diagram below. -
Page 23: Armrests
Armrests Stationary Armrest Self Leveling Armrest... -
Page 24: Reclining Seat Backs
Reclining Seat Backs All vans are equipped with reclining seats. The following diagram illustrates how they are operated. The seat will recline when the lever at the base of the seat cushion is pulled up. The driver’s seat should be adjusted before the vehicle is in motion. Headrest The headrests are adjusted by moving the latch (illustrated below), grasping the... -
Page 25: Quick Release Seat Pedestal
Quick Release Seat Pedestal* Seats are equipped with quick release pedestals. To remove the seat, simply push down on tab, pull up on lever and slide around until seat pedestal releases. (Shown in illustration below.) To reinstall align seat on pedestal, push down, pull lever back until lock position. -
Page 26: Upper & Lower Child Restraint System
Upper and Lower Child Restraint System Your van has a child restraint anchoring system in place to insure the proper safety of your child. Your middle seats have upper anchorings points between the seat bottom and back. Rear anchor for child restraint system located behind sofa. Your lower seat anchoring is at the back of the pedestal plate. -
Page 27: Rear Storage Compartment
Rear Storage Compartment* Located in the rear of the van on the passenger side, rear compartment contains the vehicle jack (please refer to chassis owners manual for complete instructions). Note: On Ford models the vehicle jack is located under the sofa. Self Center Fold Down Section* Some rear sofas are designed so that the center section of the back folds down. -
Page 28: Power Sofa
Power Sofa* This sofa moves from upright position to a fold down position and back by operating the switches located on the passenger rear sidewall behind the sofa. (This is a hidden couspn sofa pictured) (Power) Controls to operate sofa position up or down and fore and aft is equipped. -
Page 29: Wheels
Wheels* SERVICE BULLETIN Customers purchasing a Waldoch Luxury van equipped with cast alloy wheels must be made aware of the lug nut tightening procedure necessary in the immediate break-in period of the van. Lug nuts need to be checked and tightened often the first one hundred (100) miles and once again after an additional two-hundred fifty (250) miles. -
Page 30: Alloy Wheels
Note on Alloy Wheels* If your van is equipped with alloy wheels that have a special coating, clean these wheels only with a soft cloth and warm soapy water–never use a wire brush or other objects that might remove the protective coating on the wheel. -
Page 31: End Matter Part Descriptions
Wheel Disclaimer* Waldoch has always carried the highest customer satisfaction levels in the custom wheel industry. In order to maintain these levels, the warranties on chrome plated wheels must be understood by the end user. Waldoch must advise all of our dealers to explain the proper care and maintenance of chrome wheels to the end user. -
Page 32: Part Descriptions
Driver Front Door Key # Part Description Upper Leather Trim French Stitched Armrest Factory Door Panel Driver Front Door Wood Trim Leather Door Panel Driver Door Pod Wood Trim Door Speaker - Factory Map Pocket... -
Page 33: Part Descriptions
Passenger Front Door Key # Part Description Passenger Door Pod Wood Trim Door Speaker - Factory Map Pocket Upper Leather Trim French Stitched Armrest Factory Door Panel Pass Front Door Wood Trim Leather Door Panel... - Page 34 Driver Side 60 Cargo Door* Key # Part Description Factory Door Panel Door Blind Door Pull Door Shroud Cup Holder Door Handle Bezel Leather Door Panel Door Pocket Led Light Step...
- Page 35 Driver Side 40 Cargo Door* Key # Part Description Leather Door Panel Storage Factory Door Panel Door Pull Door Blind Door Shroud Door Pocket Accent Wood Trim...
- Page 36 Pass Side 60 Cargo Door Key # Part Description Door Handle Bezel Door Shroud Factory Door Panel Door Blind Door Pull Leather Door Panel Cup Holder Led Light Step...
- Page 37 Pass Side 40 Cargo Door* Key # Part Description Factory Door Panel Door Pull Door Blind Door Shroud Door Pocket Leather Door Panel Accent Trim Door Pocket...
- Page 38 Driver Rear Cargo Door Key # Part Description Factory Door Panel Door Blind Leather Door Panel Accent Trim Mesh Storage Compartment First Aid Kit Air Compressor...
- Page 39 Passenger Rear Cargo Door Key # Part Description Factory Door Panel Door Blind Cargo Door Handle Bezel Wood Trim Leather Door Panel...
- Page 40 GM Dash Key # Part Description Leather Steering Wheel Dash - Factory Drink Tray - Factory* *High Gloss Wood Finish Applied by Waldoch.
- Page 41 Center Ice Chest and Entertainment Console * Key # Part Description (2) 12 Volt Plugs Storage Box (2) Cup Holder Coller Lid Vent Removable Console 12 Volt Power Storage...
- Page 42 Driver Side Wall 3 Door - GM (Without driver cargo doors) Key # Part Description Driver Window Ledge Wood Accent Seat Belt Blind Driver Side Front Blind Driver Side Middle Blind Driver Side Rear...
- Page 43 Passenger Side Wall 3 Door - GM Key # Part Description Passenger Ledge Cup Holder/ Accent Trim - 3 Door Air Vent Power Sofa Swi (option) Wood Accent Window Shade or Blind (option, Shade Shown) Rear 3pt Seat Belt...
- Page 44 Low Top Ceiling - Rear to Front Key # Part Description Air Vent Reading Light - 09 Style 15.6” LCD Flip - Down Monitor with Built-In DVD...
- Page 45 Low Top Ceiling - Front to Rear Key # Part Description Speakers - TV High Intensity Ceiling Light Panel Reading Lights...
- Page 46 High Top GM Ceiling - Rear to Front Key # Part Description Wing Storage Doors Reading Lights High Intensity Ceiling Light Panel TV Speakers Indirect Lighting Accent Wood Trim...
- Page 47 High Top GM Ceiling - Front to Rear Key # Part Description Wing Storage Door Acccent Trim Speakers Power Sunroof Air Vent Rear Heat & A/C Control...
- Page 48 Ceiling Elements Key # Part Description Center Light Beam Speakers Air Vent Rear Sunroof w/Screen Reading Light...
- Page 49 Rear Sofa Back Key # Part Description Self-Protecting (FETs) Electical Panel (No Fuses) Rear Air/Heat Shroud Sofa Back Storage and Net (Hidden Sofa Only) Jack Storage Rear Sofa Switch...
- Page 50 Passenger Side Wall 4 Door Key # Part Description Rear Air Vent 12Volt Receptacle Cup Holder Accent Trim Headphone/USB Port?
- Page 51 Driver Front Window 3 Door Key # Part Description Accent Trim Headphone/USB Port Cup Holder Rear Heat & A/C Controls 12Volt Receptacle Rear Air Vent...
- Page 52 Driver & Rear Ground Effects 4 Door Key # Part Description Dr Front Flare Dr Front Door Dr Running Board Dr Front Cargo Door Dr Body Dr Rear Flare Ground-Effects Molding Insert Rear Bumper Cover...
- Page 53 Driver & Rear Ground Effects 3 Door/ Extended Van (Without Driver Side Cargo Doors) Key # Part Description Dr Front Flare Dr Front Door Dr Running Board Dr Body Black Ground-Effect Molding Dr Rear Flare Rear Bumper Cover...
- Page 54 Pass & Front Ground Effects 3 or 4 Door Key # Part Description Pass Rear Flare Pass Body Pass 40 Door Pass 60 Door Pass Running Board Pass Front Door Pass Front Flare Factory Bumper Cup Front Step Bumper...
- Page 55 Full Length Boards Driver Side Passenger Side Rear Flare w/Tail Piece...
-
Page 56: Maintenance Record
Maintenance Record Record the maintenance performed on your van in space provided below. This will serve as a permanent record for your later reference, and will help ensure that you care for your van properly. Please refer to the owners manual provided by the van manufacturer for the appropriate maintenance intervals. - Page 57 Date Mileage Maintenance Performed...
-
Page 58: Notes
Notes... - Page 59 Notes...