Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
Figures can deviate due to the different set executions. drivers. • Specifications are indicative (subject to change). Table 2-1 Described Model Numbers and Diversity Mechanics Descr. Block Diagrams Schematics Styling 32PFL5007G/77 9-10 9-11 9-12 9-13 10.1 10.2 10.4 10.3 11.1...
Technical Specifications and Connections L12M1.1L LA EN 3 Connections REAR CONNECTORS SIDE CONNECTORS USB 3 SERV.U AV IN AUDIO IN NETWORK DVI/VGA USB 2 BOTTOM REAR CONNECTORS HDMI SIDE DIGITAL AUDIO USB 1 (1) ARC TV ANTENNA HDMI 19300_046_120417.eps 120417 Figure 2-1 Connection overview Note: The following connector color abbreviations are used - D2+...
Page 4
EN 4 L12M1.1L LA Technical Specifications and Connections 2.3.2 Rear Connections 12 - USB1 5 - RJ45: Ethernet 10000_022_090121.eps 090121 Figure 2-6 USB (type A) 10000_025_090121.eps - +5V 120320 - Data (-) - Data (+) Figure 2-4 Ethernet connector - Ground - TD+ Transmit signal 13 - HDMI1: Digital Video, Digital Audio - In - Audio Return...
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 6
EN 6 L12M1.1L LA Precautions, Notes, and Abbreviation List result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M. format number.
Page 7
6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
Page 8
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4- wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions L12M1.1L LA EN 9 4. Mechanical Instructions Index of this chapter: 4.1 Cable Dressing Notes: 4.2 Service Positions • Figures below can deviate slightly from the actual situation, 4.3 Assy/Panel Removal due to the different set executions. 4.4 Set Re-Assembly Cable Dressing 19300_047_120417.eps 120417...
Page 10
EN 10 L12M1.1L LA Mechanical Instructions 19300_048_120417.eps 120417 Figure 4-2 Cable dressing 42" 5000 series 19300_049_120417.eps 120417 Figure 4-3 Cable dressing 47" 5000 series 2012-Aug-17...
Page 11
Mechanical Instructions L12M1.1L LA EN 11 19300_050_120417.eps 120417 Figure 4-4 Cable dressing 42" 6000 series 19300_051_120418.eps 120418 Figure 4-5 Cable dressing 42" 7000 series 2012-Aug-17...
Page 12
EN 12 L12M1.1L LA Mechanical Instructions 19300_052_120418.eps 120418 Figure 4-6 Cable dressing 47" 7000 series 19301_009_120705.eps 120705 Figure 4-7 Cable dressing 55" 6000 & 7000 series 2012-Aug-17...
Page 13
Mechanical Instructions L12M1.1L LA EN 13 Service Positions For easy servicing of a TV set, the set should be put face down on a soft flat surface, foam buffers or other specific workshop tools. Ensure that a stable situation is created to perform measurements and alignments.
Page 14
EN 14 L12M1.1L LA Mechanical Instructions 19300_055_120418.eps 120418 Figure 4-10 Rear cover removal -all models -3- 4.3.2 Small Signal Board (SSB) Caution: it is mandatory to remount all different screws at their original position during re-assembly. Failure to do so may result in damaging the SSB.
Page 15
Mechanical Instructions L12M1.1L LA EN 15 Click! LVDS flat foil Click! 19300_072_120419.eps 120419 19222_001_120626.eps Figure 4-16 Re-mounting of SSB -2- 120626 Figure 4-14 SSB LVDS - catch locking Set Re-Assembly 4.4.1 Re-mounting of Small Signal Board (SSB) Refer to Figure 4-15 Figure 4-16 for details.
Page 16
EN 16 L12M1.1L LA Mechanical Instructions 4.4.2 Cable dressing & taping Refer to Figure 4-17 correct positioning of speaker connectors in the set (ridges on top side) - to avoid unwanted disconnection when mounting the back cover. Refer to Figure 4-18 Figure 4-23 for cable dressing and taping details.
Page 17
Mechanical Instructions L12M1.1L LA EN 17 19300_059_120418.eps 120418 Figure 4-20 Cable dressing back cover 42PFL5007G & ...6007G (keyboard control panel) 19300_060_120418.eps 120418 Figure 4-21 Cable dressing back cover 42PFL5007G & ...6007G (keyboard control panel - detail) 2012-Aug-17...
Page 18
EN 18 L12M1.1L LA Mechanical Instructions 19300_061_120418.eps 120418 Figure 4-22 Cable dressing back cover 42PFL7007G (keyboard control panel and Ambilight fixation double-sided tape) 2012-Aug-17...
Page 19
Mechanical Instructions L12M1.1L LA EN 19 19300_062_120419.eps 120419 Figure 4-23 Cable dressing back cover 47PFL7007G (keyboard control panel and Ambilight fixation double-sided tape) 2012-Aug-17...
Decrease the number of nuisance calls. • Solved customers' problem without home visit. 39mm PHILIPS ComPair Mode is used for communication between a computer MODEL: and a TV on I2C /UART level and can be used by a Service 32PF9968/10 PROD.SERIAL NO:...
Page 21
Service Modes, Error Codes, and Fault Finding L12M1.1L LA EN 21 5.2.2 Service Default Mode (SDM) • AAAAAAB-XX.YY: See paragraph Software Identification, Version, and Cluster for the SW name definition. Purpose • ERR: Shows all errors detected since the last time the Set the TV in SDM mode in order to be able to create a pre- buffer was erased in format <xxx>...
Page 22
EN 22 L12M1.1L LA Service Modes, Error Codes, and Fault Finding After entering SAM, the following items are displayed, with How to Exit “SAM” in the upper right corner of the screen to indicate that the Switch the set to STANDBY by pressing the mains button on television is in Service Alignment Mode.
Page 23
• ComPair/VGA adapter cable: 9965 100 09269. Introduction Error Codes ComPair (Computer Aided Repair) is a Service tool for Philips Consumer Electronics products. and offers the following: 5.4.1 Introduction 1. ComPair helps you to quickly get an understanding on how to repair the chassis in a short and effective way.
EN 24 L12M1.1L LA Service Modes, Error Codes, and Fault Finding 5.4.2 How to Read the Error Buffer • 12 short blinks followed by a pause of 1.5 seconds, • 9 short blinks followed by a pause of 1.5 seconds, •...
A description on how to upgrade the main • C lines are working correctly (3V3) software can be found in the DFU or on the Philips website. • Manually store a known channel and check if there is IF output at tuner pins 7 &...
Page 26
EN 26 L12M1.1L LA Service Modes, Error Codes, and Fault Finding soon as the programming is finished, the set must be restarted. In the “Setup” menu you can check if the latest software is running. 5.7.3 How to Copy NVM Data to/from USB Write NVM Data to USB 1.
Alignments L12M1.1L LA EN 27 6. Alignments Index of this chapter: In case you have a color analyzer: 6.1 General Alignment Conditions • Measure with a calibrated (phosphor- independent) color 6.2 Hardware Alignments analyzer (e.g. Minolta CA-210) in the centre of the screen. 6.3 Software Alignments Consequently, the measurement needs to be done in a 6.4 Option Settings...
EN 28 L12M1.1L LA Alignments If you do not have a color analyzer, you can use the default Option Settings values. This is the next best solution. The default values are average values coming from production (statistics). 6.4.1 Introduction • Set the RED, GREEN and BLUE default values per temperature according to the values in the “Tint settings”...
Circuit Descriptions L12M1.1L LA EN 29 7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction The LC12M1.1L LA chassis is a digital chassis using a 7.2 Power Supply Mediatek chipset. It covers screen sizes of 32" to 55". 7.3 DC-DC converter 7.4 Front-End Main key components are the Mediatek MT5396 integrated 7.5 Audio...
Page 30
EN 30 L12M1.1L LA Circuit Descriptions (Reserved) 19300_064_120419.eps 120419 Figure 7-2 SSB cell layout 2012-Aug-17...
Page 31
Circuit Descriptions L12M1.1L LA EN 31 DC-DC 1.1 V DC-DC 1.5 V NAND flash DC-DC 3.3 V DDR3 DC-DC 5 V DDR3 MT5396 Headphone-Amp Class-D amplifier Digital Demodulator 19300_069_120419.eps 120419 Figure 7-3 SSB key component overview (top) 2012-Aug-17...
Page 32
EN 32 L12M1.1L LA Circuit Descriptions V-Disp switch 19300_070_120419.eps 120419 Figure 7-4 SSB key component overview (bottom) 2012-Aug-17...
Circuit Descriptions L12M1.1L LA EN 33 Power Supply 7.2.1 Connector Overview, Block Diagram and Fault Finding Table 7-1 Connector overview 32PFL5007G sets Connector 1308 1M95 1M99 1M11 1M09 Descr. Mains PSU to SSB PSU to SSB Ambilight/Bolt-on Bolt-on 3V3stdby GND_AL GND_AL GND_BO Standby...
Page 34
EN 34 L12M1.1L LA Circuit Descriptions Check First step Second step Check the fuse (F101) Normal operation Apply the mains voltage (AC Check the Standby voltage Check the entire block (PC102, V , etc.) at C306: measure 3.3 V Check the PFC voltage at C644 PFC present: measure 380 V to 400 V Check the entire block (V , ICs, etc.)
Page 35
Circuit Descriptions L12M1.1L LA EN 35 Audio Refer to Figure 7-9 for the implementation. Front-end Digital Class Speaker out D amp MUTE AIN0_L/R Analog AIN1_L/R POWER_DOWN Muting / input pairs reset circuit AIN2_L/R RESET_AUDIO AL/R3_ADAC Headphone Headphone out SPDIF_OUT Optical SPDIF out HDMI1-ARC out HDMI 19300_067_120419.eps...
EN 36 L12M1.1L LA IC Data Sheets 8. IC Data Sheets This section shows the internal block diagrams and pin layouts of ICs that are drawn as "black boxes" in the electrical diagrams (with the exception of "memory" and "logic" ICs). Diagram 10-2-2 B02, Tuner &...
Page 37
IC Data Sheets L12M1.1L LA EN 37 Diagram 10-2-2 B02, Tuner & Demodulator, Type CXD2828 (IC7210) Block diagram TSCLK TSSYNC ISDB-T TSVALID TSDATA[7:0] TAINP TAINM Viterbi TSIF decoder decoder OFDM Demodulator TIFAGC Status Terrestrial TMCC Monitor Tuner Tuner I Host I CXD2828ER TTUSDA TTUSCL...
Page 38
EN 38 L12M1.1L LA IC Data Sheets Diagram 10-2-4 B04A, MTK5396 Power, Type MT5396 (IC7300) Block diagram MT5396JDNJ 19300_040_120416.eps 120416 Figure 8-3 Internal block diagram 2012-Aug-17...
Page 39
IC Data Sheets L12M1.1L LA EN 39 Pinning information 1, MT5396JDNJ ARDQS2 BRDQ0 BRDQ6 DDRV DDRV ARDQ21 ARDQM2 ARDQ22 ARBA0 ARA2 ARA13 ARDQ8 DVSS ARRESE BRDQ9 BRDQ2 DDRV DDRV ARDQ23 ARDQ30 ARDQS2 ARDQ31 ARDQ18 ARA3 ARA7 ARDQ1 DVSS ARCLK1 BRDQ13 BRDQ4 DDRV DDRV...
Page 40
EN 40 L12M1.1L LA IC Data Sheets Pinning information 2, MT5396JDNJ ARCLK0 ARCLK0 ARDQ9 DDRV DVSS TCON5 TCON7 GPIO45 PDD3 PDD1 PACLE POWE# SD_D2 SD_D0 ARDQS0 ARDQS1 ARDQ11 DDRV DVSS TCON4 TCON6 TCON12 PDD4 PDD2 POCE1# SD_D3 SD_CMD SD_CLK ARDQS1 EMMC_C USB_DP USB_DM...
Block Diagrams L12M1.1L LA EN 41 9. Block Diagrams Wiring Diagram 32" (5000 series) Wiring diagram 32" 5000 series LED Power 8M95 1316 1M95 1D02 1M95 USB 3 MAIN POWER SUPPLY (1005) (1150) USB 2 8G51 8D01 HDMI SIDE SERV.U DIGITAL 8C20 AUDIO...
Block Diagrams L12M1.1L LA EN 42 Wiring Diagram 42" (5000 series) Wiring diagram 42" 5000 series LED Power 8M95 1316 1M95 1D02 1M95 MAIN POWER SUPPLY USB 3 (1005) (1150) USB 2 1308 HDMI SIDE SERV.U DIGITAL AUDIO AV IN AUDIO IN NETWORK DVI/VGA...
Block Diagrams L12M1.1L LA EN 43 Wiring Diagram 42" (6000 series) Wiring diagram 42" 6000 series LED Power 8M95 1316 1M95 1D02 1M95 MAIN POWER SUPPLY USB 3 (1005) (1150) USB 2 1308 HDMI SIDE SERV.U DIGITAL AUDIO AV IN AUDIO IN NETWORK DVI/VGA...
Block Diagrams L12M1.1L LA EN 44 Wiring Diagram 42" (7000 series) Wiring diagram 42" 7000 series 8M83 LED Power 8M99 8M95 1316 1316 1M99 1M95 8M59 1D02 1M95 1M99 1A04 MAIN POWER SUPPLY USB 3 (1005) (1150) USB 2 1308 HDMI SIDE SERV.U...
Block Diagrams L12M1.1L LA EN 45 Wiring Diagram 47" (5000 series) Wiring diagram 47" 5000 series LED Power 8M95 1315 1316 1M95 1D02 1M95 MAIN POWER SUPPLY (1005) USB 3 (1150) USB 2 1308 HDMI SIDE SERV.U DIGITAL AUDIO AV IN AUDIO IN NETWORK DVI/VGA...
Block Diagrams L12M1.1L LA EN 46 Wiring Diagram 47" (7000 series) Wiring diagram 47" 7000 series 8M83 LED Power 8M99 8M95 1316 1316 1M99 1M95 8M59 1D02 1M95 1M99 1A04 MAIN POWER SUPPLY (1005) USB 3 (1150) USB 2 1308 HDMI SIDE SERV.U...
Page 47
Block Diagrams L12M1.1L LA EN 47 Wiring Diagram 55" (7000 series) Wiring diagram 55" 7000 series 8M83 LED power 8M99 8M95 1316 1316 1M99 1M95 MAIN POWER SUPPLY (1005) 8M59 1D02 1M95 1M99 1A04 USB 3 1308 (1150) USB 2 8308 HDMI SIDE...
Page 48
Block Diagrams L12M1.1L LA EN 48 Wiring Diagram 55" (6000 series) Wiring diagram 55" 6000 series LED power 8M99 8M95 1316 1316 1M99 1M95 MAIN POWER SUPPLY (1005) 1D02 1M95 1M99 1A04 USB 3 1308 (1150) USB 2 8308 HDMI SIDE SERV.U DIGITAL...
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 54 10. Circuit Diagrams and PWB Layouts 10.1 A 272217190587 - 272217190588 PSL 10-0-1 Power Supply Unit with Integrated LED Driver Power Supply Unit with Integrated Led Driver DC_LINK TP230 is on Pin 3 of L602 but this pin is not indicated here BD601 L501 10A 600V...
Page 55
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 55 10-1-1 Power Supply Unit with Integrated LED Driver Power Supply Unit with Integrated Led Driver CN2_1316 LED_A Anode_R TP213 TP164 R6 Cathode R5 Cathode TP165 R4 Cathode TP163 VREF R3 Cathode 5.1k TP161 R481F...
Page 56
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 56 10-1-2 Layout top 2011-12-08 Layout top 2722 171 90587 2722 171 90588 PLDC-P102A 19300_033_120410.eps 120410 back to 2012-Aug-17 div. table...
Page 57
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 57 10-1-3 Layout bottom 2011-12-08 Layout bottom 2722 171 90587 2722 171 90588 PLDC-P102A 19300_034_120410.eps 120410 back to 2012-Aug-17 div. table...
Page 65
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 65 10-2-8 B05A, Digital I/O - HDMI Digital I/O - HDMI B05A B05A 7300-9 MT5396 HDMI_ETHERNET RX_0_0 AG35 HDMI_0_RX_0 HDMI PORT 1 HDMI PORT 2 RX_0_0B AG34 HDMI_0_RX_0B RX_0_1 AG37 HDMI_0_RX_1 OPWR3_5V OPWR0_5V RX_0_1B AG36...
Page 66
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 66 10-2-9 B05B, Digital I/O - USB Digital I/O - USB B05B B05B +5V_SW USB PORT 1 (HDD) 3C02-1 +5V_USB1 1C01 100K FC33 +5V_USB1 FC50 3C02-2 USB_DM_P1 USB_OC_P1 FC34 USB_DP_P1 FC35 100K FC01 3C02-3 100K...
Page 67
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 67 10-2-10 B06A, Analog I/O - Headphone Analog I/O - Headphone B06A B06A +3V3STBY 7801-2 PUMD12 HEADPHONE F809 A_PLOP A_STBY F810 1401 HP_LOUT LEFT F811 RIGHT MSJ-035-12D-B-AG-PBT-BRF RESET_AUDIO 7801-1 PUMD12 HP_ROUT +3V3_SW 7800 3807-1 TS489IST...
Page 68
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 68 10-2-11 B06B, Analog I/O - Component & Composite Analog I/O - Component & Composite B06B B06B YPBPR_DETECT I947 3967 CVBS_AV4 I910 3922 F924 CVBS_AV3 CVBS SIDE AIN1_L AIN1_R CVBS CVBS_GND I902 3925 5900 1VA4...
Page 69
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 69 10-2-12 B06C, Analog I/O - VGA Analog I/O - VGA B06C B06C IA01 5A00 FA01 IA02 5A01 FA02 IA09 3A10 IA03 5A02 +5V_SW 1A01 6A06 FA08 5A06 3A19 IA07 +5V_DC VGA_DETECT FA03 120R BAS316...
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 74 10.3 E 272217190554 - 272217190562 Keyboard Control Module 10-3-1 Keyboard Control Module Keyboard Control Module +3.3 V 6.8 kΩ CON3 Ω Ω Ω Ω Ω 1.5 k 3.9 k 5.6 k 18 k 8.2 k SOURCE VOL+...
Page 75
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 75 10-3-2 Keyboard Control Module layout Keyboard control module layout top Keyboard control module layout bottom 2012-02-06 2722 171 90554, 2722 171 90555, Keyboard Control Module 2722 171 90556, 2722 171 90557, layout 2722 171 90561, 2722 171 90562 19300_020_120403.eps...
Page 77
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 77 10-4-2 IR/LED/analogue light sensor board layout Sensor board layout top R22 C13 R25 R26 V1.0 R20 R23 GWA7.820.742-1 Sensor board control module layout bottom 2011-12-27 Sensor Board 2722 171 90629 layout 19300_025_120404.eps 120404 back to...
Page 78
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 78 10.5 AL 310431365614 12 LED AmbiLight 10-5-1 AL1, 12 LED single spectra 12 LED single spectra 2101 100n +12V 3108 3101 1A02 +3V3 +3V3 SCKI SCKI-BUF FH34SRJ-18S-0.5SH(50) 100R +3V3 9106 7102 9101 F001 F010...
Page 79
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 79 10-5-2 AL2, 12 LED single spectra 12 LED single spectra 7016 7015 7014 LTW-S45T LTW-S45T LTW-S45T BLUE BLUE BLUE PWM-B4 GREEN GREEN GREEN PWM-G4 +12V PWM-R4 3216-1 560R 3216-2 560R 3216-3 560R 3216-4 560R...
Page 80
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 80 10.6 AL 310431365635 10 LED AmbiLight 10-6-1 AL1, 10 LED single spectra 10 LED single spectra 2101 100n +12V 3108 3101 1A02 +3V3 +3V3 SCKI SCKI-BUF FH34SRJ-18S-0.5SH(50) 100R +3V3 9106 7102 9101 F001 F010...
Page 81
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 81 10-6-2 AL2, 10 LED single spectra 10 LED single spectra 3215-1 7016 7015 220R LTW-S45T LTW-S45T 3215-2 3215-3 BLUE BLUE PWM1-B4 220R 220R GREEN GREEN PWM1-G4 +12V 3215-4 3216-1 PWM1-R4 220R 750R 3216-2 750R...
Page 82
Circuit Diagrams and PWB Layouts L12M1.1L LA EN 82 10-6-3 AL3, 10 LED single spectra 10 LED single spectra 7011 7010 7009 LTW-S45T LTW-S45T LTW-S45T PWM1-B2 BLUE BLUE BLUE GREEN GREEN GREEN PWM1-G2 +12V PWM1-R2 3211-1 560R 3211-2 560R 3211-3 560R 3211-4 560R...