Page 1
PCV-R532DS/R536DS/ R538DS/R539DS SERVICE MANUAL US Model S400 Specifications PERSONAL COMPUTER VAIO 9-928-359-11...
Page 2
CAUTION Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type recommended by the manufacturer. Dispose of used batteries according to the manufacturer’s instructions. – 2 – PCV-R532DS/R536DS/R538DS/R539DS...
2-2. REAR PANEL Note on mounting rear panel: When installation rear panel, refer to figure. GOOD 4 rear panel claws rear panel claws 1 two claws rear panel 3 two claws 2 two claws 2-3. TOP COVER, LEFT COVER, RIGHT COVER AND TOP COVER CHASSIS 1 three screws (unified 4.5) 2 five claws...
2-4. FRONT PANEL ASS’Y (PCV-R538DS/R539DS) 2 pull the disk tray. 1 Insert the pin. 3 escutcheon 5 two claws 4 two claws 6 front panel ass’y PCV-R532DS/R536DS/R538DS/R539DS...
2-5. FRONT PANEL ASS’Y (PCV-R532DS/R536DS) 2 two claws 3 front panel ass’y 1 two claws 2-6. 3 four screws (unified 4.5) 4 Remove HDD and HDD bracket in arrow A direction. 5 two screws (No.6-32UNC) 6 HDD 2 harness (IDE HDD) 5 two screws (No.6-32UNC) 1 power connector...
2-11. POWER SUPPLY 2 three screws (PS No.6-32UNC) 3 Remove power supply and PS bracket ass’y in arrow A direction. 4 three screws (PS No.6-32UNC) 5 power supply 1 Disconnect respective power connectors 2 screw on the mother borad, (unified 4.5) DVD-ROM, CD-RW (PCV-R538DS/R539DS), IFX-90 ass’y (PCV-R532DS),...
2-19. CPU (PCV-R532DS) 3 Elect the lever in arrow A direction. 4 CPU 1 stopper 2 heatsink (PCV-R536DS/R538DS) 1 two claws 3 Unlocked four claws, 2 CPU and and the stopper removed. heatsink claws claws 4 heatsink 2-12 PCV-R532DS/R536DS/R538DS/R539DS...
(PCV-R539DS) 1 two claws 3 Remove the stopper in arrow A direction. 2 CPU and heatsink 4 heatsink 2-20. MEMORY (DIMM) 1 Open two clips. 2 memory (DIMM) Note 1: In opening the clips, hold lightly the top of the memories with your fingers to prevent a drop.
SECTION 4 SERVICE INFORMATION 4-1. JUMPER SETTING ON HARD DISK DRIVE The hard disk drive of service parts can be used without changing factory jumper setting, when it was replaced for service. Capacity Model Part No. Maker Code Remarks (formatted) 1-772-373-11 MAXTOR 91700U5...
Page 25
Capacity Model Part No. Maker Code (formatted) PCV-R532DS/R536DS 1-772-375-11 QUANTUM Fireball CX10.2AT 10 GB Configuration Jumper Settings Master Slave Cable Select Default Jumper Reserved DS with CS Setting shown in Position for Slaves Parking not supporting Position DASP Factory setting PCV-R532DS/R536DS/R538DS/R539DS...
4-2. JUMPER SETTING OF MOTHER BOARD (PCV-R536DS/R538DS/R539DS) The Motherboard of service parts can be used without changing factory jumper setting, when it was replaced for service. DIP-SW Setting Funtion Pos ition Cle ar CMOS Clear Normal FREQ Ratio X3.0 X3.5 X4.0 X4.5 X5.0...
SECTION 5 FRAME HARNESS 5-1. CONNECTOR LIST MEW-AV MOTHERBOARD (for PCV-R532DS) Internal connector Connector location on MB See the frame harness diagram Power supply pin assignments : Signal Name Signal Name 20pin ATX type connector. Ground HDsel Ground N.C. Connector location on MB See the frame harness diagram Ground DRIVE_SELECT_#3...
Page 29
CPU FAN Digital Video(DV) Output Port (TENTATIVE) Supports CPU cooling fan of 500mA or less. Voltage = 12V 40 pin dual line header for digital video port Connector location on MB See the frame harness diagram pin assignments : Connector location on MB See the frame harness diagram Signal Name pin assignments :...
Page 30
INIT# Data bit 2 SLCT IN# Holder location on MB See the frame harness diagram Data bit 3 Ground Battery vender Sony CR2032 or equivalent Data bit 4 Ground Data bit 5 Ground Serial IRQ header Data bit 6 Ground...
Microphone In pin assignments : PS2 Keyboard/Mouse Signal Name Sleeve Ground Connector location on MB Rear side, see the frame harness diagram Microphone mono In pin assignments Ring Electret Bias Voltage Signal Name Keyboard Data GAMEVCC line need the over current protector. Raychem miniSMDC110-2 or Mouse Data equivalent is used for that.
Page 32
P2B-AE MOTHERBOARD (for PCV-R536DS/R538DS/R539DS) Internal connector Power supply 168pin DIMM socket x2 20pin ATX type connector. 2 slot DIMM connector, 3.3V Unbuffered SDRAM Connector location on MB Right top corner of the MB Connector location on MB Next to the 440BX chipset pin assignments : Slot 1 Signal Name...
Page 33
Reffered as 1394HEAD1 and 2 Holder location on MB Next to the Panel header HEAD1 is not installed Battery vender Sony CR2032 or equivalent VIDEO 4 pin standard 2mm single line header for Video signal input Connector location on MB Located near PCI3 slot...
Page 34
Serial IRQ header (not installed Serial (COM1) 2 pin standard 2mm single line header for Serial IRQ signal Connector location on MB In rear I/O window Connector location on MB Next to the BIOS pin assignments : Pin assignments : Signal Name Signal Name IRQSER...
Page 35
Game/Line Out(Headphone)/Line In/Microphone Jack Connector location on MB Rear side Game port pin assignments : Signal Name GAMEVCC JPYB0 JOYA0 JOYA1 JOYB1 GAMEVCC GAMEVCC JOYB2 JOYA2 MIDI_TxD JOYA3 JOYB3 MIDI_RxD Line Out pin assignments : Signal Name Sleeve Ground Audio Left Out Ring Audio Right Out Line In pin assignments :...
SECTION 6 REPAIR PARTS LIST NOTE: Ref. • The parts listed here are for service, and therefore they may be different The components identified by No. Part NO. Description Remark from the parts shown in circuit diagrams or used in the set. mark 0 or dotted line with mark •...
Ref. No. Part NO. Description Remark When shape of 29 (COVER (2) ASSY, DRIVE) is dif- ferent from, 61 (SPACER (DRIVE)) does not use it. 1-468-417-41 x POWER, SWITCHING (170W) COVER (2) ASSY, SPACER (DRIVE) 4-639-150-01 UNIFIED SCREW 4.5 X-4622-220-1 BRACKET ASSY, PS DRIVE (4-643-900-01)
Ref. When shape of 29 (COVER (2) ASSY, DRIVE) is dif- No. Part NO. Description Remark ferent from, 61 (SPACER (DRIVE)) does not use it. 1-468-417-41 x POWER, SWITCHING (170W) COVER (2) ASSY, SPACER (DRIVE) 4-639-150-01 UNIFIED SCREW 4.5 DRIVE (4-643-900-01) X-4622-220-1 BRACKET ASSY, PS...
6-5. ACCESSORIES AND PARTS LIST Ref. No. Part NO. Description Remark ACCESSORIES & PACEKING MATEIRALS ********************************* POWER CORD (1) 4-644-968-01 USER GUIDE 4-644-969-01 READ ME FIRST 201 1-777-786-11 CORD, AC 202 1-772-397-11 x EZ KEYBOARD (PS/2) 203 1-772-207-21 WHEEL MOUSE (PS/2) 204 1-782-207-11 CABLE, MODEM –...
6-5. BARCORD LABEL : Part No. : Serial No. : Revision No. How to see barcode label : Maker Barcode 1 The shaded barcode label is used for repair data. C: Barcode [FDD] [HDD] (PCV-R532DS, R536DS) A, B [HDD] (PCV-R538DS/R539DS) [DVD-ROM] [HDD] (PCV-R538DS/R539DS) A, B...
Page 42
[MOTHER BOARD] [IFX-90 ASSY] (PCV-R532DS) (PCV-R532DS) A, B A, B [MODEM CARD] [GVC] A, B [DIMM] (PCV-R536DS/R538DS/R539DS) A, B A, B [POWER SUPPLY] (suffix-41) A, B 6-11 6-11 [END] PCV-R532DS/R536DS/R538DS/R539DS...