Subscribe to Our Youtube Channel
Summary of Contents for BKI FKF-H
- Page 1 Remote Filter MODELS FKF, FKF-H Operation and Maintenance Serial Numbers 122085 and higher...
-
Page 2: Warranty Information
Warranty Information LIMITED ONE YEAR WARRANTY BKI (The "Company") warrants to the original purchaser that at time of shipment from the Company factory, this equipment will be free from defect in materials and workmanship. Written notice of a claim under this warranty must be received by the Company within ONE YEAR from the date of installation, but no longer than ONE YEAR AND THREE MONTHS from date of shipment from the factory. -
Page 3: Table Of Contents
Remote Filter Table of Contents Table of Contents Table of Contents............................1 Introduction ..............................2 Safety Precautions............................ 2 Safety Signs and Messages......................... 2 Safe Work Practices ..........................3 Safety Labels............................5 Operation ..............................6 Controls and Indicators..........................6 BLF/FKM Filtering Procedure ........................6 DNF Filtering Procedure ........................... -
Page 4: Introduction
Electric Pressure Fryer (model BLF and FKM only) and Donut Fryer (model DNF only). The BKI name and trademark on this unit assures you of the finest in design and engineering -- that it has been built with care and dedication -- using the best materials available. Attention to the operating instructions regarding proper installation, operation, and maintenance will result in long lasting dependability to insure the highest profitable return on your investment. -
Page 5: Safe Work Practices
If you lose or damage your mitts, you can buy new ones at your local restaurant equipment supply store or from your local BKI Distributor. Always wear non-skid shoes when working around the fryer or any other equipment that uses shortening. Never wear loose clothing such as neckties or scarves while operating your fryer. - Page 6 Remote Filter Introduction Keep Safety Labels Clean and in Good Condition Do not remove or cover any safety labels on your equipment. Keep all safety labels clean and in good condition. Replace any damaged or missing safety labels. Refer to the Safety Labels section for illustration and location of safety labels on this unit.
-
Page 7: Safety Labels
Remote Filter Introduction Safety Labels... -
Page 8: Operation
Controls and Indicators The FKF and FKF-H have a power switch to turn the pump motor on or off. It also contains a pump motor reset switch. If the motor overheats while filtering, it will automatically shut off. To reactivate the pump motor, wait 15 minutes to allow the motor to cool then press the switch. - Page 9 Remote Filter Operation Hot shortening may splash out of the pot causing severe injury when filling the pot if the lid is not closed. To prevent shortening splashes, close the lid before filling. 2. Close the lid to prevent shortening splashes. 3.
-
Page 10: Dnf Filtering Procedure
Remote Filter Operation DNF Filtering Procedure Always wear appropriate personal protection equipment during the filtering process to guard against possible injury from hot oil. 1. Set the fryer POWER switch to the ON position. 2. Set the FILTER MOTOR switch on the fryer to OFF. 3. - Page 11 Remote Filter Operation 15. After 1 minute, hold the hose by the handle and carefully raise the lid to check the level of the shortening. 16. Let the filter continue to pump the shortening until the fill mark in the fryer pot is reached or until air starts bubbling through the shortening.
-
Page 12: Filter Pad Replacement
Remote Filter Operation Filter Pad Replacement The filter pad must be replaced daily. If the shortening has a milky color when it is pumped into the pot, the filter pad should be replaced immediately. If the filter pad is not properly closed, breading crumbs will get through the pad opening and clog the pump. - Page 13 Remote Filter Operation...
-
Page 14: Replacement Parts
Use the information in this section to identify replacement parts. To order replacement parts, call your local BKI sales and service representative. Before calling, please note the serial number, model number and voltage on the rating tag affixed to the unit. - Page 15 Remote Filter Replacement Parts...
- Page 16 P.O. Box 80400, Simpsonville, S.C. 29680-0400, USA http://www.bkideas.com Made and printed in the U.S.A LI0171/0407...
Need help?
Do you have a question about the FKF-H and is the answer not in the manual?
Questions and answers