Advertisement
Advertisement
Table of Contents
Related Manuals for Patriot PLATINUM
Summary of Contents for Patriot PLATINUM
- Page 1 INSTRUCTION MANUAL Thermostatic Gas Griddles This manual contains important information regarding your unit. Please read this manual thoroughly prior to equipment set-up, operation and maintenance. Failure to comply with regular maintenance guidelines outlined in this manual may void the warranty.
-
Page 2: Before Installation
WARNINGS • Do not store or use gasoline or other fl ammable vapors or liquids in the vicinity of this or any other equipment. • Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death. • Read the installation and maintenance instructions thoroughly before installing or servicing this equipment. -
Page 3: Gas Conversion
Standards Council, NFPA, 1 Batterymarch Park Quincy, MA 02169-7471. NFPA Standard #96 Vapor Removal from Cooking Equipment, latest edition, available from the National Fire Protection Association, Batterymarch Park, Quincy, MA. In the commonwealth of Massachusetts all gas appliances vented through a ventilation hood or exhaust system with a damper or with a power means of exhaust shall comply with 248 CMR. - Page 4 Gas Piping: Gas piping shall be of such size and so installed as to provide a supply of gas suffi cient to meet the full gas input of the appliance. If the appliance is to be connected to existing piping, it shall be checked to determine if it has adequate capacity. Joint compound (pipe dope) shall be used sparingly and only on the male threads of the pipe joints.
-
Page 5: Seasoning The Griddle
The main gas valve should be “CLOSED/OFF” for fi ve (5) minutes prior to lighting plots to clear any existing gas. (Main gas valve is supplied by others.) 1. Turn “ON or OPEN” the main gas valve to the unit. 2. - Page 6 OPERATING THE GRIDDLE Turn the burners on about 15-20 minutes before cooking for preheating. Set the knobs to the desired fl ame height or temperature. Each valve controls the gas fl ow to the burner to bring that area of the griddle up to the desired temperature. If different temperature settings are to be used, adjoining areas should be set to progressively higher temperatures using the lowest temperature on the outside burners.
-
Page 7: Troubleshooting
TROUBLESHOOTING Problem Possible Causes Solution Griddle not lighting Main gas line is closed Open valve Check quick disconnect and Quick disconnect not inserted all Griddle not lighting make sure it is fully inserted into the way female coupling Griddle not lighting Pilot is not lit Ignite pilot light Griddle not lighting... - Page 8 Parts Diagram for the Gas Griddles March 2016...
- Page 9 Parts List for the Gas Griddles DRW. NO. Part Description TOP REAR BEAM LOWER REAR SHROUDING BACK SIDE PANEL (COAMING) FRONT PLATEN GAS VALVE NOZZLE PILOT U-SHAPED BURNER RIGHT SIDE PANEL (COAMING) FLUE PANEL SUPPLY PIPE (PILOT) LOCATION PIN (GRIDDLE PLATE) NG/LPG REGULATION VALVE GAS INLET PIPE FIXED PLATE (BURNER)
-
Page 10: Warranty
Patriot warrants its equipment against defects in materials and workmanship, subject to the following conditions: Patriot gas equipment is warranted for three (3) years, effective from the date of purchase by the original owner. A copy of the original receipt or other proof of purchase is required to obtain warranty coverage.