Table of Contents
Related Manuals for Storm Surge SS14CW
Summary of Contents for Storm Surge SS14CW
- Page 1 Operator’s Manual Water Pump SS14CW GAS/OIL Product Number: RATIO 50:1 20198 P/N: 22541 ECN: 10829 REV 1: 05/01/15 © 2015 Ardisam, Inc. All Rights Reserved Check for parts online at www.stormsurgepumps.com or call 800-345-6007 M-F 8-5...
-
Page 2: Table Of Contents
INTRODUCTION Congratulations on your investment in quality. Thank you for purchasing a water pump from Storm Surge™. We have worked to ensure that your pump meets the highest standards for usability and durability. With proper care, your pump will provide many years of service. -
Page 3: Pump Specifications
Operator’s Manual SS14CW Water Pump PUMP SPECIFICATIONS SS14CW PERFORMANCE DATA 1,000 1,500 2,000 Discharge Capacity (gal/hr) SPECIFICATIONS Engine Viper® 40cc 4-cycle Ignition Type Electronic Ignition Cooling System Forced Air Cooling Spark Plug Type / Gap (mm) NGK CMR6A / 0.6... -
Page 4: Warnings And Safety Precautions
Carefully follow all assembly instructions. CAUTION • Maintain the machine according to directions and CAUTION INDICATES YOU CAN BE HURT OR schedule included in this Storm Surge™ operator’s YOUR EQUIPMENT DAMAGED IF THE SAFETY manual INSTRUCTIONS THAT FOLLOW THIS SIGNAL •... - Page 5 Operator’s Manual SS14CW Water Pump GENERAL SAFETY RULES Regularly inspect the machine. Make sure parts are not bent, damaged or loose. Keep all screws, nuts and bolts tight. Read, understand, and follow all instructions on the machine and in the manual(s). Be thoroughly familiar with the controls Temperature of muffler and nearby areas may exceed 150°...
- Page 6 Operator’s Manual SS14CW Water Pump WARNING CAUTION ENGINES GIVE OFF CARBON MONOXIDE, AN HOT GASES ARE A NORMAL BY-PRODUCT OF A ODORLESS, COLORLESS, POISONOUS GAS. FUNCTIONING INTERNAL COMBUSTION ENGINE. CARBON MONOXIDE MAY BE PRESENT EVEN IF FOLLOW ALL SAFETY INSTRUCTIONS TO PREVENT YOU DO NOT SMELL OR SEE ANY ENGINE EXHAUST.
- Page 7 Operator’s Manual SS14CW Water Pump • Test the fuel cap for proper installation before starting Service and using engine. • Always stop the engine whenever you leave the • Always run the engine with fuel cap properly installed equipment, before cleaning, repairing or inspecting on the engine.
-
Page 8: Component Identification
Operator’s Manual SS14CW Water Pump COMPONENT IDENTIFICATION Clear Water Pump (SEE FIGURE 2.) THROTTLE LEVER WATER PRIMING FILLER MUFFLER INTAKE (SUCTION) OIL FILL PORT PORT LOCATION FRAME PUMP OUTLET DRAIN (DISCHARGE) PLUG PORT SPARK PLUG ACCESS PANEL RECOIL STARTER GRIP... -
Page 9: Installation
7. Install the included intake stainer basket (7) on the barbed hose end flange (3) with hose clamp (5). NOTE: Operation of your Storm Surge™ Water Pump without the included intake strainer basket will void your warranty. The intake strainer has been designed to prevent large debris from entering the pump intake which can cause damage. -
Page 10: Pump Placement
• The intake hose and strainer must be immersed in water when the pump is operating. NOTE: Operation of your Storm Surge™ Water Pump without an intake strainer basket will void your warranty. The intake strainer has been designed to prevent large debris from entering the pump intake which can cause damage. -
Page 11: Operation
Operator’s Manual SS14CW Water Pump Quality CAUTION To operate the engine, we recommend using VIPER® brand NEVER ADD FUEL WHEN ENGINE IS RUNNING OR 4-cycle oil (13235) or an equivalent 10W-30 engine oil to HOT FROM OPERATION. NEVER FILL THE TANK ensure that the engine operates correctly throughout the life INDOORS. - Page 12 Operator’s Manual SS14CW Water Pump STARTING AND STOPPING ENGINE THROTTLE LEVER • Move engine to a well ventilated area, outdoors, to prevent carbon monoxide poisoning. • Move to an area away from flames or sparks, to avoid ignition of vapors if present.
-
Page 13: Maintenance And Storage
Operator’s Manual SS14CW Water Pump NOTE: All repair parts must come from the factory. Never replace parts that are not specifically designed for the pump. 6. Reconnect the spark plug wire. Pump Maintenance Always shut off the engine, allow the engine to cool, and remove the spark plug before performing any maintenance. - Page 14 Operator’s Manual SS14CW Water Pump CHANGING OIL with warm water and mild soap. Remember to thoroughly Be sure the engine is not operating and is located on a level oil the foam filter with 30 or 40 weight motor oil and surface before checking or refilling oil.
-
Page 15: Troubleshooting And Repair
SS14CW Water Pump TROUBLESHOOTING AND REPAIR Service Information BACK LATCH TABS At Storm Surge™ we build quality and durability into the ON/OFF design of our products; but no amount of careful design by us, SWITCH and careful maintenance by you, can guarantee a repair-free life for your machine. - Page 16 2. Low fuel in tank 2. Add fuel to tank Contact Storm Surge™ customer service at 800-345-6007 if additional assistance is needed. Only use approved Storm Surge™ spare parts. Check for parts online at www.stormsurgepumps.com or call 800-345-6007 M-F 8-5...
- Page 17 (SEE FIGURE 5 “PUMP PLACEMENT”) Check Engine Refer to Table 1. (Engine Troubleshooting Guide.) Contact Storm Surge™ customer service at 800-345-6007 if additional assistance is needed. Table 3. Pump Troubleshooting Guide: Low Pump Output PROBLEM: Low Pump Output POSSIBLE CAUSE REMEDY/ACTION 1.
-
Page 18: Parts Breakdown
Operator’s Manual SS14CW Water Pump ILLUSTRATED PARTS BREAKDOWN - PUMP & FRAME Check for parts online at www.stormsurgepumps.com or call 800-345-6007 M-F 8-5... - Page 19 Operator’s Manual SS14CW Water Pump 1, 15 15, 27 15, 28, 34 15, 29 15, 29, 30, 15, 31, 15, 32 15, 33 1, 15 15, 26 ITEM # PART # DESCRIPTION QTY. ITEM # PART # DESCRIPTION QTY. 67028 BOLT M6 X 1.0 X 16 HEX...
-
Page 20: Parts Breakdown
Operator’s Manual SS14CW Water Pump ILLUSTRATED PARTS BREAKDOWN - ENGINE Check for parts online at www.stormsurgepumps.com or call 800-345-6007 M-F 8-5... - Page 21 Operator’s Manual SS14CW Water Pump ENGINE PARTS LIST ITEM # PART # DESCRIPTION QTY. ITEM # PART # DESCRIPTION QTY. 13553 ON/OFF SWITCH GROMMET FUEL TANK 10887 BOLT M5 X 0.8 X 16 W/WASHER FUEL LINE 195 MM 17053 AIR FILTER COVER SWITCH HOLE...
-
Page 22: Warranty
Operator’s Manual SS14CW Water Pump WARRANTY TERMS AND CONDITIONS PRODUCT WARRANTY: 2-YEAR LIMITED WARRANTY Ardisam, Inc. (Ardisam), a manufacturing company, warrants this product to be free from defects in the material or workmanship for a period of two years from the date of purchase. If there is insufficient evidence of the purchase date, the effective date of this warranty will begin on the pump’s date of manufacture. -
Page 23: Maintenance Schedule
Operator’s Manual SS14CW Water Pump MAINTENANCE SCHEDULE Every 8 hours Every 50 hours Every 100 hours Maintenance Item Each year (daily) or seasonally or seasonally Clean Engine and Check Bolts & Nuts Engine Oil Check (See Lubrication Section) Change* (initial 5 hours) -
Page 24: Federal Emission Control Warranty Statement
Operator’s Manual SS14CW Water Pump FEDERAL EMISSION CONTROL WARRANTY STATEMENT (ECS Warranty), which is provided to you by Ardisam pursuant to federal law. See also the Ardisam “Product Warranty” (non-emission YOUR WARRANTY RIGHTS AND OBLIGATIONS warranties), which is enclosed herewith on a separate sheet or located in additional materials accompanying this product. - Page 25 Operator’s Manual SS14CW Water Pump for replacement as required maintenance in the Maintenance caused by the use of such an unapproved, add-on, modified, Schedule (located in the section of the Manual(s) pertaining to counterfeit and/or “grey market” part. maintenance) shall be warranted for the ECS Warranty Period. If any...
- Page 26 Operator’s Manual SS14CW Water Pump NOTES Check for parts online at www.stormsurgepumps.com or call 800-345-6007 M-F 8-5...
- Page 27 Operator’s Manual SS14CW Water Pump NOTES Check for parts online at www.stormsurgepumps.com or call 800-345-6007 M-F 8-5...
- Page 28 Ardisam, Inc. 1160 8th Avenue, PO Box 666 Cumberland, WI 54829 800-345-6007 | Fax 715-822-2223 E-mail: info@ardisam.com All weights, specifications and features are approximate and are subject to change without notice. Due to continuous product improvements, product images may not be exact. Items used for props not included. Some assembly may be required.