Table of Contents

Advertisement

About this Manual ............................................................................................................................ 1-1
Safety Messages Used in this Manual .............................................................................................. 1-1
Pre-Delivery Inspection .................................................................................................................... 1-2
Front Axle Tire Alignment ............................................................................................................... 1-2
Service and Assistance ...................................................................................................................... 1-2
Reporting Safety Defects .................................................................................................................. 1-2
Occupant and Cargo Carrying Capacity Label ................................................................................. 1-3
Vehicle Certification Label ............................................................................................................... 1-4
Specifications and Capacities ........................................................................................................... 1-5
Owner and Vehicle Information ....................................................................................................... 1-6
2010 New Vehicle Limited Warranty ............................................................................................... 1-7
General Warnings ............................................................................................................................. 2-1
Driving Safety ................................................................................................................................... 2-1
Fuel and Propane Gas ....................................................................................................................... 2-1
LP Gas Leaks .................................................................................................................................... 2-2
Propane Gas Leak Detector .............................................................................................................. 2-2
Carbon Monoxide Warning .............................................................................................................. 2-3
Carbon Monoxide Alarm .................................................................................................................. 2-3
Smoke Alarm .................................................................................................................................... 2-4
Fire Extinguisher ............................................................................................................................... 2-5
Electrical ........................................................................................................................................... 2-5
Loading ............................................................................................................................................. 2-5
Maintenance ...................................................................................................................................... 2-5
Emergency Exits ............................................................................................................................... 2-6
Slideout Rooms ................................................................................................................................. 2-6
Formaldehyde Information ............................................................................................................... 2-7
Mold, Moisture, and Your Motor Home ........................................................................................... 2-7
Roadside Emergency ........................................................................................................................ 2-8
Wheel Mounting Nuts (Lug Nuts) .................................................................................................... 2-9
Jump Starting .................................................................................................................................... 2-9
Engine Overheat ............................................................................................................................. 2-10
Seats - Driver/Co-Pilot ..................................................................................................................... 3-1
Seat Belts .......................................................................................................................................... 3-2
Keys .................................................................................................................................................. 3-3
Remote Keyless Entry ...................................................................................................................... 3-4
Mirrors - Power Electric ................................................................................................................... 3-4
Rev. 1019100816

TABLE OF CONTENTS

Copyright 2009 Winnebago Industries, Inc. All rights reserved.
Part No. 161500-10-016

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Reyo and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Winnebago Reyo

  • Page 1: Table Of Contents

    3 – DRIVING YOUR MOTOR HOME Seats – Driver/Co-Pilot ........................3-1 Seat Belts ............................3-2 Keys ..............................3-3 Remote Keyless Entry ........................3-4 Mirrors – Power Electric ........................3-4 Rev. 1019100816 Part No. 161500-10-016 Copyright 2009 Winnebago Industries, Inc. All rights reserved.
  • Page 2 Table Of Contents Hazard Warning Flashers ........................3-5 Power Sunvisor ..........................3-5 Air Conditioner/Heater – Automotive (Dash) .................. 3-5 Radio In-Dash/Rearview Monitor System ..................3-6 Sirius® Plug and Play Satellite Radio ....................3-8 Battery Boost Switch ........................3-8 Engine Cooling System ........................3-9 Fuel Fill Access ..........................
  • Page 3 Table Of Contents Battery Care ............................6-8 Circuit Breakers and Fuses – House 12-Volt DC ................6-10 7 – PLUMBING Fresh Water System .......................... 7-1 Water Pump ............................7-2 Cold Water Filter ..........................7-3 Disinfecting Your Fresh Water System .................... 7-4 Shower Hose Vacuum Breaker ......................
  • Page 4 Table Of Contents 11 – MAINTENANCE AND STORAGE Sealants – Inspection and General Information ................11-1 Roof ..............................11-1 Undercarriage ..........................11-1 Exterior Automotive Paint Finish ....................11-2 Care of Appliques and Decals ......................11-4 Plastic Parts – Cleaning ........................11-4 Exterior Lights ..........................
  • Page 5: Introduction

    DANGER indicates a hazardous situation are intended as a guide, and in no way which, if not avoided, will result in death or extend the responsibilities of Winnebago serious personal injury. Industries beyond the standard written warranty as presented in this manual.
  • Page 6: Pre-Delivery Inspection

    National Highway Traffic Safety Administration (NHTSA) in addition to notifying Winnebago PRE-DELIVERY INSPECTION Industries, Inc. If NHTSA receives similar complaints, it may...
  • Page 7: Occupant And Cargo Carrying Capacity Label

    SECTION 1 – INTRODUCTION You can also obtain other information about motor vehicle safety from the NHTSA website at http://www.safercar.gov OCCUPANT AND CARGO CARRYING CAPACITY LABEL This label is affixed in the driver’s area next to or near the Vehicle Certification Label. It contains vehicle occupant and cargo carrying capacity along with the number of seat belt positions in the vehicle.
  • Page 8: Vehicle Certification Label

    These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago ® 9. Rear Axle Wheel Configuration: Single or Industries Dual as it relates to the inflation.
  • Page 9: Specifications And Capacities

    SECTION 1 – INTRODUCTION SPECIFICATIONS AND CAPACITIES ® ® Dodge Dodge Itasca Reyo Sprinter F50 Sprinter F50 Chassis Chassis Feature Number Length 25' 5" 25' 5" 10' 10" 10' 10" Exterior Height Exterior Width 7' 6" 7' 6" Exterior Storage 56.1 cu.
  • Page 10: Owner And Vehicle Information

    Motor Home Serial Number __________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...
  • Page 11: 2010 New Vehicle Limited Warranty

    ITEMS NOT SUBJECT TO WARRANTY COVERAGE Winnebago Industries, Inc. of Forest City, Iowa, warrants each new Chassis, drivetrain and related components* Winnebago and Itasca motor home to the owner for recreational use Wheels* in the U.S.A. and Canada as follows:...
  • Page 12 If you are touring or have moved, contact any unresolved warranty disputes for recreational vehicles. This dispute Winnebago Industries motor home dealer in the United States or resolution program reviews eligible product and service related Canada for warranty service.
  • Page 13: Safety And Precautions

    SECTION 2 – SAFETY AND PRECAUTIONS • Use care when accelerating or decelerating on GENERAL WARNINGS a slippery surface. Abrupt speed changes can cause skidding and loss of control. • Only seats equipped with seat belts are to be occupied while the vehicle is moving. •...
  • Page 14: Lp Gas Leaks

    SECTION 2 – SAFETY AND PRECAUTIONS • All pilot lights must be extinguished and asphyxiation is greater when the appliance is appliances turned off while refilling the fuel used for long periods of time. Failure to comply tank or LP gas tank. could result in death or serious injury.
  • Page 15: Carbon Monoxide Warning

    SECTION 2 – SAFETY AND PRECAUTIONS CARBON MONOXIDE WARNING WARNING EXPLOSION HAZARD: DO NOT use an WARNING open flame to test for gas leaks. When testing for gas line leaks with a soapy water solution, DO NOT use a detergent Avoid inhaling exhaust gases, as they containing ammonia or chlorine.
  • Page 16: Smoke Alarm

    RV application. We recommend obtaining a replacement from your Further Information ® Winnebago Industries dealer. See the manufacturer’s information in your Further Information InfoCase for further instructions.
  • Page 17: Fire Extinguisher

    • Do not remove the radiator cap while engine your coach. We recommend obtaining a and radiator are still hot. Always check replacement only from your Winnebago coolant level visually at the see-through ® Industries dealer or a reliable RV parts supplier.
  • Page 18: Emergency Exits

    SECTION 2 – SAFETY AND PRECAUTIONS • Never get beneath a vehicle that is held up by a jack only. Side • Do not mix different construction types of Latch tires on the vehicle, such as radial, bias, or belted tires, as vehicle handling may be affected.
  • Page 19: Formaldehyde Information

    SECTION 2 – SAFETY AND PRECAUTIONS Mold is a plant and requires its own special FORMALDEHYDE environment to grow. That environment includes INFORMATION organic materials, nutrients, moisture, and proper temperature. Some of the materials used in this recreational vehicle emit formaldehyde. Eye, nose, and throat How Can I Avoid Mold? irritation, headache, nausea, and a variety of To reduce the ability for mold to grow, you...
  • Page 20: Roadside Emergency

    DO NOT jerk your foot off the accelerator. ® Just ease back on the accelerator slowly and Winnebago Industries gently to continue momentum. The deflated If Winnebago Industries determines that mold tire will slow the vehicle. ® ® is present in the Winnebago...
  • Page 21: Wheel Mounting Nuts (Lug Nuts)

    We recommend that you ask for an underlift (wheel lift or frame lift) type towing assembly for safe towing. ® Winnebago Industries does not assume Steel Wheel Front Steel Wheel Rear responsibility for damage incurred while towing this vehicle.
  • Page 22: Engine Overheat

    SECTION 2 – SAFETY AND PRECAUTIONS ENGINE OVERHEAT If you see or hear steam escaping from the engine compartment or have any other reason to suspect an extreme engine overheating condition, pull the vehicle over to the roadside as soon as it is safe to do so, stop the engine, and get all passengers out of the vehicle.
  • Page 23: Driving Your Motor Home

    SECTION 3 – DRIVING YOUR MOTOR HOME The information in this section refers only to features installed or adapted to the dash and driver compartment area by Winnebago ® Industries . It also includes passenger seating in the living area of the coach.
  • Page 24: Seat Belts

    SECTION 3 – DRIVING YOUR MOTOR HOME 2. Depress the Foot Pedal and press and hold the A lumbar adjustment dial is located on the Activation switch DOWN simultaneously side of the driver and passenger seats to provide until seat fully lowers and front lock tab is the travel comfort you need.
  • Page 25: Keys

    SECTION 3 – DRIVING YOUR MOTOR HOME Unfastening 1- Insert tab into buckle Press the release button in the buckle. Hold slot until it “clicks” and is onto the tongue when you release it from the locked buckle to keep it from retracting too rapidly. When the lap-shoulder belt is in use, the lap belt must ride low across the hip area and the 3- Press to...
  • Page 26: Remote Keyless Entry

    SECTION 3 – DRIVING YOUR MOTOR HOME Keys have an identification number, either a Move Selector Switch L or R to select mirror. small metal tag or stamped into the key head. Center “neutral” position disables arrows These numbers are recorded on the vehicle’s to avoid unintentionally moving a mirror component model/serial sheet, which is included in your InfoCase.
  • Page 27: Hazard Warning Flashers

    SECTION 3 – DRIVING YOUR MOTOR HOME Power Sunvisor Switch (Located beneath cab radio) Mirror Head Pivot Lock -Typical View Loosen Allen head set screw to pivot mirror head.* (Torque 75-100 in/lbs) AIR CONDITIONER/HEATER – AUTOMOTIVE (DASH) *Set screws may be located on the opposite side of the mirror arm.
  • Page 28: Radio In-Dash/Rearview Monitor System

    SECTION 3 – DRIVING YOUR MOTOR HOME Air Intake Hose Fastener Air Intake Hose/Fastener Air Filter Housing (View shown from beneath (Located underneath the front hood) the front end of coach) 3. Lift up air filter housing lid and replace filter. RADIO IN-DASH/REARVIEW MONITOR SYSTEM –If Equipped...
  • Page 29 SECTION 3 – DRIVING YOUR MOTOR HOME iPod Cable • MENU - Press to access USER SETTING MENU. Press and hold access SYSTEM -If Equipped SETUP MENU. Your coach is equipped with a cable to • AUDIO - Press and hold access AUDIO connect your iPod to play through your radio.
  • Page 30: Sirius Plug And Play Satellite Radio

    SECTION 3 – DRIVING YOUR MOTOR HOME To install the satellite unit, place your Sirius radio into the docking station, aligning the tabs at the edges of the the radio adapter with the grooves in your radio. Gently push the radio down until it is fully seated in the docking station.
  • Page 31: Engine Cooling System

    SECTION 3 – DRIVING YOUR MOTOR HOME NOTE: The House/Coach Battery Disconnect FUEL FILL ACCESS switch near the entrance door must be ON and house batteries must be The fuel fill access is located directly behind sufficiently charged for this feature to the driver side door on the exterior of the coach.
  • Page 32: Tires

    SECTION 3 – DRIVING YOUR MOTOR HOME Further Information Out-of-balance tires will not roll smoothly and can lead to vibrations and uneven tread wear, Refer to the chassis manual in your InfoCase such as cupping and flat spots. Tires may need to for further information.
  • Page 33: Appliances And Systems

    SECTION 4 – APPLIANCES AND SYSTEMS The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. See Section 2 of this manual for any safety and precautions you need to take regarding the operation of your appliances.
  • Page 34: Refrigerator Service Access Compartment

    SECTION 4 – APPLIANCES AND SYSTEMS • To start up the refrigerator, press Mode button for 2 seconds. The previously selected operating mode is displayed (e.g. 120, which means 120V). • Press Mode again and you may change the operating mode to: AU (Automatic Energy Selection) or manually change to 120V, 12V, or Gas NOTE: The 12V DC operation is only...
  • Page 35: Range Top

    SECTION 4 – APPLIANCES AND SYSTEMS Avoiding Asphyxiation The following warning label has been located in the cooking area to remind you to provide an adequate supply of fresh air for combustion. Refrigerator Access Compartment (Top) 2. Remove the door from the opening. To Close 1.
  • Page 36: Microwave Oven

    SECTION 4 – APPLIANCES AND SYSTEMS is out. They also tell you which mode the water MICROWAVE OVEN heater is operating in (LP Gas or Electric 110- Volt. -If Equipped Refer to the microwave oven manufacturer’s Water And Holding Tank Levels information provided in your InfoCase for Touch either the Black Water Level, Gray complete operating instructions.
  • Page 37: Water Heater - Gas/ Electric

    SECTION 4 – APPLIANCES AND SYSTEMS Water Pump NOTE: The black and gray water tanks are measured in 1/3 increments while the When use of the self-contained water system fresh water tank is measured in 1/4 is desired, touch the Water Pump On/Off touch increments.
  • Page 38: Pressure-Temperature Relief Valve

    SECTION 4 – APPLIANCES AND SYSTEMS faucet anywhere in the coach. When water begins to flow steadily from the faucet, the water heater is full. For Propane Gas Operation Press the Water Heater (LP) touch cell on the Monitor Panel. The “LP Pilot Out” light will glow for about 10-15 seconds, then it will go out.
  • Page 39: Propane Gas Furnace

    SECTION 4 – APPLIANCES AND SYSTEMS Lift handle straight out to open P-T valve when water heater is cold* Water Heater Exterior Service Access 4. Let the handle of the P-T valve snap shut. Normally there is an air gap at the top of the water heater tank, which acts as a pressure buffer.
  • Page 40: Heat Pump

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information Please see the furnace operating instructions provided in your InfoCase for further information, including operating precautions, and periodic maintenance. See the Coach Maintenance Schedule for recommended intervals. NOTE: If the furnace burner has any residuals of metal protectant or lubricants used during manufacture of the furnace, it may smoke slightly when the furnace is...
  • Page 41: Ducted Roof Air Conditioning System

    SECTION 4 – APPLIANCES AND SYSTEMS temperatures begin to reduce the efficiency of the NOTE: The ducted roof air conditioning system heat pump. The heat pump will not operate when has ceiling registers that can be closed if the outside temperature falls below 36 degrees F. necessary to force more cool air toward a specific area of the coach or to route To operate the heat pump:...
  • Page 42: Furnace-A/C Thermostat Operation Chart

    SECTION 4 – APPLIANCES AND SYSTEMS FURNACE-A/C THERMOSTAT OPERATION CHART The following chart shows the system functions with the “Heat/Cool” thermostat. Disregard references to heat functions when using the “Cool Only” thermostat in the rear bedroom. X = Switch Position O = Switch position does not matter or is inactive for this feature FAN MODE FAN SPEED...
  • Page 43: Propane Gas

    SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY WARNING The propane gas system supplies fuel for the gas range/oven, water heater, furnace, and refrigerator (while in gas mode). When used and Do not alter or remove propane tank handled properly, this system is safe and valves or gauge.
  • Page 44 SECTION 5 – PROPANE GAS DAN GE R DO NOT FILL CONTAINER TO MORE THAN 80 PERCENT OF CAPACITY. FAILURE TO COMPLY COULD RESULT IN A FIRE OR PERSONAL INJURY. Make sure the motor home is level when filling. It is possible to accidentally overfill Main Tank Valve Switch the tank if the vehicle is not level, with the (Located near monitor panel area)
  • Page 45: Safe Use Of The Propane Gas System

    SECTION 5 – PROPANE GAS phone directory yellow pages for locations of • Exercise caution at all times. Be familiar with local propane gas refilling stations or bulk the distinctive odor of propane gas. If a leak is dealerships. suspected, turn off the supply valve immediately.
  • Page 46: Propane Gas Warnings And Precautions

    SECTION 5 – PROPANE GAS PROPANE GAS WARNINGS AND PRECAUTIONS WARNING It is illegal for vehicles equipped with propane tanks to travel on certain roadways or through Propane cylinders shall not be placed or certain tunnels in the U.S. To avoid stored inside the vehicle.
  • Page 47: Propane Vaporization In Cold Weather

    SECTION 5 – PROPANE GAS WARNING Visually inspect the pressure regulator vent periodically for blockage by accumulated debris or insect nests, etc. Vent obstruction could result in excessive pressure causing fire or explosion, which could result in death or serious injury. If an obstruction exists, have the regulator serviced by a qualified service center.
  • Page 48 SECTION 5 – PROPANE GAS This means that in extremely cold weather when a large volume of gas is being used by the furnace for heating, it is possible to experience a loss of gas pressure. At first, this problem may appear to be caused by an empty tank or a regulator freeze-up, but is actually caused by failure of the liquid gas to vaporize as fast as it is needed by the furnace.
  • Page 49: Electrical

    SECTION 6 – ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motor home that is •...
  • Page 50 SECTION 6 – ELECTRICAL The three-prong power cord is designed to ground the electrical system through the receptacle. It is also designed to carry the amperage output of most campground outlets. 30 Amp Receptacle • Route power cord through notch and close door If the electrical receptacle to be used is while shoreline is connected to outlet designed to mate with the three prongs on the...
  • Page 51: Power Center

    SECTION 6 – ELECTRICAL The converter power panel contains the house electrical system 120-volt circuit breakers and 12-volt fuses. The power converter changes 120-volt AC current from the auxiliary generator or the shoreline into 12-volt DC current for use by 12- volt equipment in the motor home.
  • Page 52: Circuit Breakers - House 120-Volt Ac

    SECTION 6 – ELECTRICAL Further Information CIRCUIT BREAKERS – HOUSE See the manufacturer’s operation, care, and 120-VOLT AC maintenance information in your InfoCase. The breaker panel protects all 120-volt Charging Section components in the motor home from either an overload on the circuit or a short in the wiring or The converter charges house batteries while component itself.
  • Page 53: Ground Fault Circuit Interrupter

    SECTION 6 – ELECTRICAL GROUND FAULT CIRCUIT ELECTRICAL GENERATOR – INTERRUPTER 120-VOLT –If Equipped Bath, galley, and exterior outlets are connected to a GFCI (Ground Fault Circuit Interrupter), which is an extremely sensitive WARNING circuit breaker that will help to protect against severe electrical shock if a ground fault develops.
  • Page 54: Electrical System - House 12-Volt Dc

    SECTION 6 – ELECTRICAL The following hourmeter is located on or next 4. Do not operate the generator engine while to the monitor panel in your coach. parked if vegetation, snow, buildings, vehicles, or any other object can deflect the exhaust under or into the vehicle.
  • Page 55: House/Coach Battery Disconnect Switch

    SECTION 6 – ELECTRICAL The house batteries supply power to 12-volt equipment located in the living area of the motor home. This includes the following 12-volt powered components (if equipped): interior 12- volt lighting, range exhaust fan, propane furnace fan, fresh water pump, systems monitor panel with water level and holding tank gauges, refrigerator, roof vent fans, and 120-volt electrical generator starter.
  • Page 56: Battery Care

    SECTION 6 – ELECTRICAL House Batteries Chassis Battery Connector Chassis Battery (Located to the right of the accelerator pedal) The chassis (starting) battery is located in a compartment “well” in the floor beneath carpet Further Information ahead of the driver seat. See the chassis manual provided in your InfoCase for details on access and servicing.
  • Page 57 SECTION 6 – ELECTRICAL The two best defenses against sulfating • Make sure battery cable clamps are tight on and insufficient charge are to: the terminal posts and are free of corrosion. • Neutralize corrosion buildup or acid film on 1.
  • Page 58: Circuit Breakers And Fuses - House 12-Volt Dc

    SECTION 6 – ELECTRICAL WARNING To prevent wiring damage, it is essential when replacing the cables on the battery, or when using a “booster” battery, that the positive post and the positive cable be attached and the negative post and negative cable be attached.
  • Page 59 SECTION 6 – ELECTRICAL Battery Boost Switch See Driving Your Motor Home section for information on the Battery Boost Switch. 6-11...
  • Page 61: Plumbing

    SECTION 7 – PLUMBING FRESH WATER SYSTEM The fresh water system provides water to the galley sink, shower, bathroom lavatory, toilet, and water heater. Water may be supplied by either of two sources: • a fresh water tank and water pump located within the motor home;...
  • Page 62: Water Pump

    SECTION 7 – PLUMBING 2. Turn Fresh Water Valve to Normal position These devices simply connect in-line between and turn the water pump switches OFF. the supply hose and the city water input on the coach. Water pressure regulators are commonly available at most RV dealerships and many large retail discount or home supply centers.
  • Page 63: Cold Water Filter

    SECTION 7 – PLUMBING Initial Waterline Priming 1. Make sure that all water drain valves are closed, including water heater valve. 2. Turn water pump switch to “OFF” position. 3. Fill water tank. 4. Open all faucets, hot and cold. 5.
  • Page 64: Disinfecting Your Fresh Water System

    SECTION 7 – PLUMBING • Purge a new filter cartridge before using for drinking. Run a few gallons of water through the filter and discard the water (or use for watering plants) to avoid ingesting carbon dust or particles that may have been present in the new filter cartridge.
  • Page 65 SECTION 7 – PLUMBING This procedure is also recommended before water system. (If a 100 ppm concentration is long periods of storage, such as over winter. desired as discussed in step 3, use 1 cup of household bleach for each 30 gallons of tank Models with City Water Tank Fill capacity.) The bleach will be drawn into the tank when...
  • Page 66: Shower Hose Vacuum Breaker

    SECTION 7 – PLUMBING upright to avoid draining the bleach. EXTERIOR SHOWER/WASH Connect the hose to a city water hydrant to force STATION the bleach into the tank and fill the tank with water. –If Equipped This method has the additional benefit of disin- The exterior wash station feature allows you fecting the city water hose at the same time.
  • Page 67: Waste Water System

    SECTION 7 – PLUMBING the holding tank. Toilet tissue made specifically for use in RV toilets and holding tanks is available at most RV supply centers. • Don’t dispose of sanitary napkins or other non-dissolving items in the toilet. • Don’t put automotive antifreeze or caustic chemicals, such as laundry bleach or heavy detergents into the toilet or holding tank.
  • Page 68: Waste Water System (Waste Pump)

    SECTION 7 – PLUMBING NOTE: DO NOT OPEN BOTH VALVES AT See “Specifications” in Section 1 - ONCE. Do not open the gray tank valve Introduction for tank capacities for your model. until the black tank is drained and dump valve closed to avoid sewage back-up WASTE WATER SYSTEM into gray tank.
  • Page 69 SECTION 7 – PLUMBING Dumping Holding Tanks 1. Remove sewage drain hose from water service center. Sewage Drain Hose -Typical View 2. Remove dust cap from sewage drain outlet and connect sewer hose. Be sure it is firmly attached. Waste Pump (Located behind removable panel in water service center) -Typical View...
  • Page 70 SECTION 7 – PLUMBING 1st - Pull black water valve to drain black water (sewage) tank. Waste Pump Switch Black Water Drain Valve (Located in water service center) (Located in driver side compartment) -Typical View -Typical View 6. Add an odor control chemical to the sewage NOTE: DO NOT OPEN BOTH VALVES AT holding tank through the toilet.
  • Page 71: Holding Tank Heater

    SECTION 7 – PLUMBING Holding Tank Level Indicators will drain the house/coach batteries in a relatively short period. Typically, the See “Systems Monitor Panel” in Section 4 - batteries would not support overnight Appliances for further information on the heating without a supplemental charging monitor panel and checking tank levels.
  • Page 72: Water Heater Bypass And Antifreeze Siphon Valves

    SECTION 7 – PLUMBING Water Tank Drain Valve (Located in water service center) -Typical View Waterline Drain Valve (Located behind access panel in rear WATER HEATER BYPASS AND storage compartment) ANTIFREEZE SIPHON VALVES -Typical View Your coach may be equipped with a water heater bypass valve and an antifreeze siphon valve for easier winterization of waterlines using RV antifreeze.
  • Page 73: Winterizing Procedures

    SECTION 7 – PLUMBING 4. Remove the Cold Water Filter Cartridge (if WINTERIZING PROCEDURES equipped). Remove the filter cartridge from the filter assembly below the galley sink. You can winterize the water and plumbing (If your coach is not equipped with a cold system of your coach using one of the following water filter, continue to next numbered step.) two methods –...
  • Page 74 14. Pour about one cup of RV antifreeze down the system. A “blow-out” plug can be each drain for the galley sink, lavatory sink, ® ® purchased at any Winnebago or Itasca and shower/tub. This fills the drain trap pipes dealer. to prevent holding tank odors from entering the coach during storage.
  • Page 75 SECTION 7 – PLUMBING holding tanks. Although these products valve to avoid filling the water heater with may have a deodorizing effect, they may antifreeze. This feature is located near the water damage plastic and rubber parts in the pump. See the “Water System Drain Valve system.
  • Page 76 SECTION 7 – PLUMBING • Install the diverter plug into the filter socket. Insert plug up into the filter socket as far as possible and twist “clockwise” one-quarter turn until it stops. Antifreeze Siphon Tube -Typical View Set Up Winterization Valves •...
  • Page 77 SECTION 7 – PLUMBING NOTE: Ensure that all drain valves are CLOSED before pumping RV antifreeze into the water system. Refer to the “Water System Drain Valve Locations” chart at the end of this section for valve locations on your model.
  • Page 78 SECTION 7 – PLUMBING 17. Close dump valves and refit the dust cap onto the drain outlet. This will inhibit rust formation on valve shafts and prevent entry and contamination by airborne debris, insects, and rodents. Your drainage and fresh water systems are now winterized.
  • Page 79: Water System Drain Valve Locations

    SECTION 7 – PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS Model System Drain Valve Locations Waterlines To drain the entire water system, open the two drain valves in the water center compartment as well as open the two drain valves located through the access hole beneath the bed board. Water Tank Remote valve inside exterior shower panel (located near the water center).
  • Page 81: Entertainment

    SECTION 8 – ENTERTAINMENT TV – 12-VOLT LCD –If Equipped The liquid crystal display flat panel TV is powered by 12-volt DC current. The TV 12-Volt Master Power Switch must be On to operate the TV. The 12-volt current is supplied from the house batteries, or from the power converter when connected to shoreline power or running the generator.
  • Page 82: Audio-Video System Basic Operation

    SECTION 8 – ENTERTAINMENT DVD PLAYER WITH DELUXE SOUND –If Equipped 2. Pull the TV out. The DVD player is a selectable function of the multi-featured audio system. The player unit contains DVD/CD/MP3/AM-FM stereo radio. It also accepts portable audio player inputs and it also functions as an alarm clock.
  • Page 83: Electrical Inverter

    SECTION 8 – ENTERTAINMENT TV Sound through Deluxe Sound • The TV screen will display the DVD player Speakers logo when the correct When watching TV programs alone, the TV input is selected. normally plays sound through its own built-in stereo speakers.
  • Page 84: Tv Antenna

    SECTION 8 – ENTERTAINMENT Raising Antenna to Operating Position Turn elevating crank clockwise in “UP” direction until some resistance to turning is noted (about 13 turns). Antenna is now in operating position. Turn amplifier power switch “ON” to receive TV signal.
  • Page 85: Tv Signal Amplifier

    SECTION 8 – ENTERTAINMENT Checking Performance The TV signals available to an RV are entirely CAUTION dependent on its location in relation to the transmitter. Signals may vary from strong to no To avoid equipment damage, always usable signal at all. We recommend that the TV align directional handle to DOWN position system be checked out in an area known to have before lowering.
  • Page 86 SECTION 8 – ENTERTAINMENT ® See your authorized Winnebago Industries dealer for proper installation and sealing of roof mounted components. Interior Connection for Satellite Dishes (Located in galley or bedroom overhead cabinet) -Typical View Audio Video Connections The Audio Video Connections allow you to connect composite or component inputs for use of your camcorder, video games, etc.
  • Page 87: Furniture And Softgoods

    SECTION 9 – FURNITURE AND SOFTGOODS SLEEPING FACILITIES Seat Back Release Lever WARNING Sleeping facilities are not intended for use while vehicle is in motion. For safety, passengers must use safety belted seating positions while vehicle is in motion. Seat Back Release Lever (Located on the side of cab seats) •...
  • Page 88: Twin/Queen Bed Conversion

    SECTION 9 – FURNITURE AND SOFTGOODS Converting Twin Bed to a Queen Bed: • Maximum Capacity: 300 lbs. • To avoid injury to young children, do not leave them unattended on the bunk. Stowing the bunk 1. Remove the two metal support brackets and To stow the bunk, reverse Steps 1 and 2 and two wooden bed boards from the supplied follow the warning below:...
  • Page 89: Bed Extension

    SECTION 9 – FURNITURE AND SOFTGOODS 2. Arrange the cushions to fill in the open spaces. 4. Unfold the two decorative rectangular cushions and arrange to fill in the middle extension. To convert bed back into stored position, remove cushions and push bed board against wall.
  • Page 90: Window Shades/Screens

    SECTION 9 – FURNITURE AND SOFTGOODS • The other located behind the driver and passenger cab seats. NOTE: The cab seats must be completely rotated (facing the lounge area) to use as dinette seating. See the Driver/Co-Pilot Seat information in Section 3 - Driving Your Motor Home for complete operating instructions.
  • Page 91: Wood Furniture And Cabinetry

    No matter which species you choose for your new Winnebago Industries motorhome cabinetry, please keep in mind that no two pieces of wood are exactly the same.
  • Page 92 SECTION 9 – FURNITURE AND SOFTGOODS Therefore, since wood is a product of nature and will have certain natural characteristics and variances, they are not covered under the warranty.
  • Page 93: Slideout Rooms

    SECTION 10 – SLIDEOUT ROOMS SLIDEOUT ROOM TRAVEL LOCK –If Equipped Some models are equipped with an expandable prop-lock rod device to restrict movement of the slideout room while the vehicle is in motion. The Lock Rod must be released before extending the room or damage to the coach will result.
  • Page 94: Slideout Room Operation - Electric

    SECTION 10 – SLIDEOUT ROOMS SLIDEOUT ROOM OPERATION – ELECTRIC WARNING Your motor home may have more than one slideout room. Understand which switch operates which slideout room prior Slideout Room Keylock to operation. Make sure all slideout rooms are clear of people who could be harmed The key to turn the master keylock “off”...
  • Page 95 SECTION 10 – SLIDEOUT ROOMS SLIDEOUT ROOMS so the engine • Insert the Safety Lock key and turn to activate alternator can provide maximum power slideout room control switch. for proper operation of the slideout • Press the Slideout Room “EXTEND/OUT” mechanisms.
  • Page 96: Slideout Room - Extreme Weather Precaution

    SECTION 10 – SLIDEOUT ROOMS • Insert the Safety Lock key and turn to activate SLIDEOUT ROOM slideout room control switch. TROUBLESHOOTING – • Press the Slideout Room “RETRACT/IN” ELECTRIC switch and hold until the room is fully retracted, then release the switch. Battery Voltage or Circuit Breaker •...
  • Page 97 SECTION 10 – SLIDEOUT ROOMS If an error is detected on your slideout system, other, release that button until the other arm the LED light on the control panel will blink an catches up. The current limiting feature of the error code.
  • Page 98: Slideout Emergency Retraction

    SECTION 10 – SLIDEOUT ROOMS cleared prior to operating the room. To clear the error, perform the following steps (one at a time) to reset the system: • If none of the “Battery Voltage or Circuit Breaker Problems” troubleshooting recommendations reset the system, remove the touchpad from the wall (a screwdriver will be needed) and press and hold the RESET button (“Set Stops/Clear Fault”) located on...
  • Page 99: General Slideout Care

    SECTION 10 – SLIDEOUT ROOMS If help is available, a second person cranking • Remove bed frame/panel assembly by on the other handle simultaneously will removing bolts around the perimeter of the greatly speed up the process. bed. • Flip up partitian cabinet lid and remove access panel below.
  • Page 101: Maintenance And Storage

    • Have the sealant replaced if you notice any of attention. Delaying these repairs may allow water the above. Your local Winnebago Industries leakage and result in damage to interior ceiling dealer has the correct and necessary parts and and body panels, upholstery, etc., which is not experience to help you maintain your sealants.
  • Page 102: Exterior Automotive Paint Finish

    SECTION 11 – MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the initial 60-day cure stage, a coat of wax or amount of cargo you can carry and remain within polish can help protect the surface from these GVWR and GAWR limits.
  • Page 103 SECTION 11 – MAINTENANCE AND STORAGE Bug Removal to clean heavy road films on semi trailers and are often dirty. They are not • Rinse the loose debris off with water and designed for custom painted RV’s and allow the remaining residues to soak and they will scratch the clearcoat finish.
  • Page 104: Care Of Appliques And Decals

    SECTION 11 – MAINTENANCE AND STORAGE is subjected to various twisting and flexing forces • Fuel or antifreeze spilled on appliques or caused by routine cornering and turning, and by decals should be rinsed off immediately with uneven road surfaces, such as bumps, potholes, water.
  • Page 105: Exterior Lights

    • Butyl alcohol home is parked for an extended period of time. EXTERIOR LIGHTS ® Most Winnebago Industries vehicles have WARNING polycarbonate lenses on exterior lamps, which are very sensitive to a variety of chemical solvents and cleaners. When cleaning upholstery and fabric, do...
  • Page 106: Ceiling Fabric Care

    SECTION 11 – MAINTENANCE AND STORAGE Draperies, Curtains and For most soils and stains, the fabric manufacturer recommends spot treatment with a Bedspreads ® solution of water and Tide brand laundry These items may be woven from a variety of detergent or equivalent.
  • Page 107: Cabinetry - Cleaning

    SECTION 11 – MAINTENANCE AND STORAGE The following cleaning chart is provided as a guideline for care and cleaning of ceiling fabrics used in your coach. CEILING FABRIC STAIN REMOVAL Type of Stain Cleaning Agent How to Remove Mustard Dry-Clean Solvent Scrub-Soak-Blot Dry Ketchup* High Strength Detergent...
  • Page 108: Tables And Countertops

    SECTION 11 – MAINTENANCE AND STORAGE Vinyl simulated wood panels may be cleaned • A high iron content in the water (hard water) with a mild, water-based cleaner and a soft cloth. may result in a brown or rust-colored stained Do not use solvents on vinyl wood panels.
  • Page 109: Doors And Windows

    SECTION 11 – MAINTENANCE AND STORAGE Lavatory Sink batteries, turn the Aux/Coach Battery Switch off to avoid electrical arcing when attaching The lavatory sink is made of the same material and detaching charge clamps. as the galley sink. See Galley Sink - Care and Cleaning Instructions.
  • Page 110: Vehicle Storage - Removal

    SECTION 11 – MAINTENANCE AND STORAGE If you are storing your vehicle through the 15. Replace batteries, if necessary, and check out winter, or in cold climates, extra preparations electrical system to make sure all lights and must be made to protect equipment and systems electrical components operate.
  • Page 111: Coach Maintenance Chart

    SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System Have propane gas system checked for leaks Pressure Regulator - inspect and adjust if needed Check propane tank condition, mounting, and fittings...
  • Page 112 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: Headlights, Taillights, and Marker Lights Turn Signals...
  • Page 113: Miscellaneous

    SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect (see “Sealants”...
  • Page 115: Loading The Vehicle

    SECTION 12 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motor home’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available space when loading your motor home.
  • Page 116 SECTION 12 – MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motor home is to weigh each “corner”...
  • Page 117: Car Or Trailer Towing

    SECTION 12 – MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual listed Gross Weight Ratings. See “Vehicle set (left rear duals or right rear duals) should not Certification Label” in the Introduction section exceed 6,000 lbs. for information on gross weight ratings.
  • Page 118: Trailer Wiring Connector

    SECTION 12 – MISCELLANEOUS Before descending a steep or long grade when TRAILER WIRING towing a trailer, reduce speed and shift into a CONNECTOR lower gear to control vehicle speed. Avoid prolonged or frequent application of brakes Your coach is pre-wired for trailer or car which could cause overheating and brake failure.
  • Page 119: Entry Step - Electric

    350 vehicle drive train: engine and cooling systems, lbs. All Winnebago Industries models transmission, drive line, drive axle, and others. equipped with a Class IV hitch have a...
  • Page 120: Windows

    SECTION 12 – MISCELLANEOUS Stationary Extended Mode - Step Switch OFF (Step Remains Extended) With the Step power switch in the OFF position, the step will extend when the screen door is opened and will stay extended whether the door is opened or closed. This position is normally used to keep the step extended when parked at a campsite or whenever people will be going in and out the vehicle...
  • Page 121: Power Roof Ventilator

    SECTION 12 – MISCELLANEOUS Side Latch Bottom Latch Entrance Door Window • To open window, slide latch to the left and raise (View of interior left-hand window up. side of window) • To lock window, slide latch to the right. -Typical View Side Latch...
  • Page 122: Storage Compartment Doors

    SECTION 12 – MISCELLANEOUS To Operate Ceiling Ventilator doors with the palms of your hands. If the door is ajar you will hear and feel a loud “click” when 1. Turn the Dome Crank Knob to raise the dome the latches engage properly. about 3"...
  • Page 123 SECTION 12 – MISCELLANEOUS Humidity and Condensation Moisture condensing on the inside of windows is a visible indication that there is too much humidity inside the coach. Excessive moisture can cause water stains or mildew, which can damage interior items such as upholstery and cabinets.
  • Page 125 INDEX 2010 New Vehicle Limited Warranty ..1-7 Engine Overheat ........2-10 About this Manual ........1-1 Entry Step – Electric ........12-5 Air Conditioner Filter ........4-9 Exterior Automotive Paint Finish ....11-2 Air Conditioner/Heater – Exterior Lights ........... 11-5 Automotive (Dash) ........
  • Page 126 Index Power Center ..........6-3 Tables and Countertops ......11-8 Power Roof Ventilator ....... 12-7 Tires ............3-10 Power Sunvisor ..........3-5 Toilet ............7-6 Pre-Delivery Inspection ....... 1-2 Towing Guidelines ........12-4 Pressure-Temperature Relief Valve ..... 4-6 Trailer Wiring Connector ......12-4 Propane Gas Furnace ........

Table of Contents