Page 2
Deleted note 1 requiring installation of SB550-33-5. 09-26-12 LSM-SCD-006-3 was LSM-500-391-3. LSM-SCD-019-1 was LSM-500-391-7. Added DN212-202-18 hat bushings. AN960-8 qty was 18. M81824-1-2 was M7928/5-4. LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com 210 Airport Drive East, Sebastian, Florida, 32958, U.S.A.
Page 3
Begin by checking the contents of your kit against the list below. -1 35W Ballast Installation Kit -3 60W Ballast Installation Kit Nomenclature Part Number Vendor Quantity PAR 46 Assy, LH LSM-500-361-9 LoPresti Aviation PAR 46 Assy, RH LSM-500-361-10 LoPresti Aviation 35W Ballast Assy LSM-SCD-006-3 LoPresti Aviation 60W Ballast Assy LSM-SCD-019-1...
Remove the landing light feed wires from the bundle and cut them at the rear of the existing lamp housing. Remove the chafe guard to allow splicing to the new power harness. See photo 2. LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com...
Page 5
¼” bolts that secure the housings to the attach bracket. Detach existing power and ground wires from the landing light assembly. It is not necessary to remove the attach brackets. See photos 3, 4 and 5. LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com...
Page 6
LSM-500-066 Rev F Page 5 of 14 Photo #3 Gear Door Mounted Lights Photo #4 Gear Door Mounted Lights LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com 210 Airport Drive East, Sebastian, Florida, 32958, U.S.A.
Page 7
5522417-52 panel underneath the two clearance holes. Access to this area is gained by removing the 512CZ (LH) and 612CZ (RH) access covers. Begin by removing the six mounting screws on each access cover. See photo 6. LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com...
Page 8
6 each DN212-202-18 hat bushings, 3 each MS21042-08 nuts, 3 each NAS43DD3-48FC spacers, 6 each NAS549F10 insulating washers and 6 each AN960-08 washers. Installation is typical for LH and RH of aircraft. See Figure 1. LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com...
Page 9
Reversing this order will result in the outboard bolt not having enough clearance. Do not substitute shorter length bolts or the self-locking mechanism will be defeated. See photos 7 and 8. LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com...
Page 10
LSM-500-066 Rev F Page 9 of 14 Photo #7 Gear Door Mounted Lights Photo #8 Strut Mounted Lights LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com 210 Airport Drive East, Sebastian, Florida, 32958, U.S.A.
Page 11
M23053/5-106-0 shrink tubing. Leave extra cable at the top to allow for twisting as the gear retracts as shown in photo 10. Installation is typical for LH and RH of aircraft. LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com...
Page 12
Due to the characteristics of HID lights, raising the light beam path will result in better illumination. Fill out FAA Form 337 and log book entry. LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com 210 Airport Drive East, Sebastian, Florida, 32958, U.S.A.
Page 13
LSM-500-066 Rev F Page 12 of 14 LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com 210 Airport Drive East, Sebastian, Florida, 32958, U.S.A.
Page 14
Check for cracking in the reflector housing clamp flanges and for safety wire integrity (if existing). Damaged clamp or broken safety wire must be replaced. LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com 210 Airport Drive East, Sebastian, Florida, 32958, U.S.A.
60W Ballast Kit Each ballast assembly draws a maximum of 5.9 amperes at startup and then draws 2.4 amperes at steady state, after the lamps warm up. LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com 210 Airport Drive East, Sebastian, Florida, 32958, U.S.A.
Page 27
CFR Part 25 MDL No.: 47, AFMS No.: N/A Rev.: B Aircraft Rev.: D Rev.: N/A Date: 12-01-2004 Company Date: 11-09-04 Date: N/A LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com 210 Airport Drive East, Sebastian, Florida, 32958, U.S.A.
Page 28
CFR Part 25 MDL No.: 47 AFMS No.: N/A Rev.: G Company 500, 550, S550 Rev: K Rev.: N/A Date: 11-28-07 Date: 10-17-07 Date: N/A LoPresti Aviation 800-859-4757 / 772-562-4757 or fax 772-228-9750 http://www.LoPrestiAviation.com 210 Airport Drive East, Sebastian, Florida, 32958, U.S.A.