Page 1
MD CD DSP RECEIVER DPX-8030MD 3 7 63 1515 0 SERVICE MANUAL 2002-4 PRINTED IN JAPAN B51-7924-00 (4) 517 This service manual dose not include information on the CD and MD mechanism assembly (exploded view, parts list, schematic diagram and mechanism oparation description).
Page 2
3 7 6 3 1 5 1 5 0 IC12 PWR IC E-VOL SYSTEM E-VOL E’S INPUT MUTE SP OUT FM : 603mV FM : 1979mV AM : 428mV AM : 626mV CD : 1346mV CD : 3512mV MD : 1346mV MD : 3512mV CH : 1346mV AUX : 455mV...
Page 3
DPX-8030MD COMPONENTS DESCRIPTION 3 7 63 1515 0 • SYNTHESIZER UNIT (X14-6980-21) Ref No. Application/Function Operation/Condition/Compatibility System µ-com Input selector & electronic volume Input source switching, SP=OUT/PRE-OUT electronic volume. Generates BU 5V supply from B.UP, Power supply IC and AUD 8V supply and DSP(D)3.3V supply and PCON output.
Page 4
DPX-8030MD COMPONENTS DESCRIPTION 3 7 63 1515 0 Ref No. Application/Function Operation/Condition/Compatibility Turns on when base goes Lo and sends a reset signal to the system Q101 RST DRIVER µ-com/panel µ-com/changer. Turns on when base goes Hi and resets the system µ-com.
Page 6
DPX-8030MD MICROCOMPUTER'S TERMINAL DESCRIPTION 3 7 63 1515 0 PIN No. Pin Name Description Processing Operation SP REQ Spectrum analyzer enable output PN SCCON Panel communications line (Flash CE) Active at L SEL E2PROM E2PROM inserted/not inserted Writes at H...
Page 7
DPX-8030MD MICROCOMPUTER'S TERMINAL DESCRIPTION 3 7 63 1515 0 PIN No. Pin Name Description Processing Operation PMODE Panel position sensor input terminal (A/D input) Vth is set in test mode CD DET CD photosensor terminal L: CD present (A/D input) Vth: 2.2 volts...
Page 8
DPX-8030MD MICROCOMPUTER'S TERMINAL DESCRIPTION 3 7 63 1515 0 PIN No. Pin Name Description Processing Operation GS03 FL dot section data output terminal 3 Not used L: Fixed FL CLK FL dot section clock input terminal Not used L: Fixed...
Page 9
DPX-8030MD MICROCOMPUTER'S TERMINAL DESCRIPTION 3 7 63 1515 0 PIN No. Pin Name Description Processing Operation External bus DATA 11 External bus DATA 10 External bus DATA 9 External bus DATA 8 External bus DATA 7 External bus DATA 6...
DPX-8030MD TEST MODE 3 7 63 1515 0 How to enter the test mode Panel slot disc sensor (CD) •Test Mode 1, reset while holding down the 1 & 3 keys. Sensor status used for detecting if CD is inserted in slot at •Test Mode 2, reset while holding down the 1 &...
Page 11
DPX-8030MD TEST MODE 3 7 63 1515 0 Adding tuner functions Call up alignment mode by holding down the SEL key in Current track Search target Tracks other than shown below No.7 tuner:source, select the following items with the No.7 No.2...
Page 12
DPX-8030MD ADJUSTMENT (X16-1710-00) 3 7 63 1515 0 Adjusting the CD disc sensor phototransistor de- When CD detector voltage is LESS THAN target value tection voltage (ver1.0) ∗ Turn VR3 clockwise (to right) so CD Detector terminal vo- ltage is between 0.8 to 1.2 volts.
Page 13
PC BOARD (Component side view) PC BOARD (Foil side view) 3 7 6 3 1 5 1 5 0 SWITCH UNIT (X25-9320-00) SWITCH UNIT (X25-9320-00) X25-9320-00 (J74-1358-12) X25-9320-00 (J74-1358-12) VOL. VOL. CP16 CP15 CP10 CP14 CP13 CP11 1 3 9 4 2 2 9 6 5 1 3 CP21 CP19 CP22...
Page 14
PC BOARD (Component side view) 3 7 6 3 1 5 1 5 0 SYNTHESIZER UNIT (X14-6980-21) SUB CIRCUIT UNIT (X16-1710-00) X16-1710-00 (J74-1360-02) X14-6980-00 (J74-1356-12) 13 11 12 8 9 10 6 C334 C234 C338 C230 C451 C233 C413 C238 C340 C232 C229...
Page 15
PC BOARD (Foil side view) 3 7 6 3 1 5 1 5 0 SYNTHESIZER UNIT (X14-6980-21) SUB CIRCUIT UNIT (X16-1710-00) X14-6980-00 (J74-1356-12) X16-1710-00 (J74-1360-02) D412 C235 C335 C237 C337 R232 R332 R235 R335 C519 C509 C502 C508 R231 R331 R234 R334 Q201...
Page 16
Q11-13 DC CORD ∗ CD SERVO CD SERVO DC CORD BU5V BU5V BU5V (E30-4939-05) POWER POWER (E30-6028-05) CTRL SUPPLY 7.5V SUPPLY DPX-8030MD IC15 1/2W DPX-8200WMP ANT CON ON/OFF 7.5V AVR RESET R124 S7.5V 2.2K 1/2W 1/2W R174 P ANT Q102...
Page 18
OTHER : 5.0V DATA READ w w w DPX-8030MD(M) (2/2) CAUTION: For continued safety, replace safety critical components only with manufacturer's recommended u 1 6 3 parts (refer to parts list). Indicates safety critical components. To reduce the risk of electric shock, leakage- current or resistance measurements shall be carried out (exposed parts are acceptably insulated from the supply circuit) before the appliance is returned to the customer.
Page 19
: N80-3010-46 φ3x6 : N83-3006-46 M2x2.2 : N39-2022-46 M3x6 : N30-3006-46 L 13942296513 (X14-) (X14-) (X16-) (X14-) (X14-) (X14-) (A/2) FPC1 u163 Refer to the following page. DPX-8030MD (1/2) Parts with the exploded numbers larger than 700 are not supplied.
Page 20
3 7 63 1515 0 (X25-) L 13942296513 M1.4 : N09-4465-05 M1.4 (BLK) : N09-4466-05 M2x3 : N09-4467-05 φ2x5 : N80-2005-46 φ3x8 : N09-6027-05 φ2x10 : N80-2010-46 u163 DPX-8030MD (2/2) Parts with the exploded numbers larger than 700 are not supplied.
Page 21
DPX-8030MD PARTS LIST 3 7 63 1515 0 ∗ The language of an instruction manual. New Parts E : ENG F : FRE P : POR H : HUN O : POL Parts without Parts No. are not supplied. T : CHI...
Page 22
DPX-8030MD PARTS LIST 3 7 63 1515 0 ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. (X14-6980-21) Teile ohane Parts No. werden nicht geliefert. Des- Des- Ref.
Page 23
DPX-8030MD PARTS LIST 3 7 63 1515 0 ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. (X14-6980-21) Teile ohane Parts No. werden nicht geliefert. Des- Des- Ref.
Page 24
DPX-8030MD PARTS LIST 3 7 63 1515 0 ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. (X14-6980-21) Teile ohane Parts No. werden nicht geliefert. Des- Des- Ref.
Page 25
DPX-8030MD PARTS LIST 3 7 63 1515 0 ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. (X14-6980-21) Teile ohane Parts No. werden nicht geliefert. Des- Des- Ref.
Page 26
DPX-8030MD PARTS LIST 3 7 63 1515 0 ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. (X14-6980-21) Teile ohane Parts No. werden nicht geliefert. Des- Des- Ref.
Page 27
DPX-8030MD PARTS LIST 3 7 63 1515 0 ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. (X25-9320-00) Teile ohane Parts No. werden nicht geliefert. Des- Des- Ref.