Kozy-World GSP3012 Owner's Operation And Installation Manual

Hide thumbs

Table Of Contents

Kozy-World

OWNER ' S OPERATION AND INSTALLATION MANUAL

GSP3012 GSN3011

GSP3014 GSN3013

GSP2222 GSN2221

WARNING:

This is an unv ented gas-

fired heater. It uses air (oxygen) from the

room in which it is installed. Prov isions

for adequate combustion and ventilation air

must be provided. Ref er to Air For Com-

bustion and Ventilation section on page 4

of this manual.

World Marketing of America, Inc.

P.O. Box 192, Rt. 22 West

Mill Creek, PA 17060

KOZY WORLD PHONE NUMBER: (814) 643-1775

http://www.worldmkting.com

WARNING :

manual is not followed exactly, a f i re o r ex -

p l o s i o n m a y r e s u l t c a u si n g p r o pe r t y

damage, personal injury, or loss of life.

Do not store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any

other appliance.

WHAT TO DO IF YOU SMELL GAS

l Do not try to light any appliance.

l Do not touch any electrical switch; do not use any

phone in your building.

l Immediately call your gas supplier from a neighbor's

phone. Follow the gas supplier's instructions.

l If you cannot reach your gas supplier, call the

fire department.

Installation and service must be performed by

a qualified installer, service agency, or local

gas supplier.

WARNING: Improper installation, adjustment,

alteration, service or maintenance can cause in-

jury or property damage. Refer to this manual for

correct installation and operational procedures. For

assistance or additional information consult a

qualified installer, service agency, or local gas supplier.

This appliance may be installed in an aftermarket*,

permanently located manufactured (mobile) home,

where not prohibited by local codes.This appliance

is only for use with the type of gas indicated on the

rating plate. This appliance is not convertible for use

with other gases.

WATER VAPOR:A BY-PRODUCT OF UMVENTED ROOM

HEATERS

Water vaporis a by-product of gas combustion.An

unvented room heater produces approximately one(1)

ounce(30) of every 1,000BTU'S(3KW'S) of gas input per

hour,Refer to papg 6.

Installer : please leave these instructions with

the consumer

Consumer : please retain these instruction for

future use

*Aftermarket: Completion of sale, not for purpose of

resale, from the manufacturer.

COMPACT LP & NATURAL

GAS VENT-FREE STOVE

I f th e i nfo rmati o n i n this

WM-QL058-03W-0603

Table of Contents

Need help?

Do you have a question about the GSP3012 and is the answer not in the manual?

Questions and answers

Summary of Contents for Kozy-World GSP3012

Page 1 Do not touch any electrical switch; do not use any phone in your building. l Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. GSP3012 GSN3011 l If you cannot reach your gas supplier, call the GSP3014 GSN3013 fire department.
Page 2: Table Of Contents
fade. Natural gas may be present M o d e l s G S P 3 0 1 2 , G S P 3 0 1 4 , Table of Contents e ve n t h o u g h n o o d o r e xi s t s . GSP2222 are equipped for propane Make certain you read and under ga s.
Page 3: Safety Information
SAFETY INFORMATION cautions required, and that has com- In the State of Massachusetts the gas Continued plied with all the requirement of the cock must be a “T” handle type. The authority having jurisdiction. State of Massachusetts requires that 11 . T h i s h e at e r n e e d s f re s h ai r PRODUCT FEATURES a flexible appliance connector cannot ventilation to run properly.
Page 4: Air For Combustion & Ventilation
AIR FOR COMBUSTION AND VENTILATION Confined and Unconfined Space Unusually Tight Construction WARNING: This heater shall not be installed in a confined space or The National Fuel Gas Code, ANS The air that leaks around doors and unusually tight construction unless Z223.1 defines a confined space as a windows may provide enough fresh provisions are provided for adequate...
Page 5 3. Add the Btu/Hr of all fuel burning appliances in the space. Vent-free heater Btu/Hr Example: Gas water heater* Btu/Hr Gas water heater 30,000 Btu/Hr Gas furnace Btu/Hr Vent-free heater 26,000 Btu/Hr Vented gas heater Btu/Hr Total 56,000 Btu/Hr Gas heater logs Btu/Hr Other gas appliances* + Btu/Hr...
Page 6: Installation
INSTALLATION NOTICE: This heater intended for use as supplemental heat. Use this heater along with your primary heating system. Do not install this heater as your primary heat source. If you have a central heating system, system's circulating blower while using heater.
Page 7: Connecting To Gas Supply
CLEARANCES TO COMBUSTIBLES The installer must supply an external regulator. Carefully follow the instructions below. The external regulator will reduce incoming gas This stove is a freestanding unit pressure. You must reduce incoming gas pressure designed to set directly on the floor. to rating inches of water.
Page 8: Gas Connections
Pressure Testing Gas WARNING: Never connect CAUTION: Avoid damage to Supply Piping System heater to private (non-utility) gas regulator. Hold gas regulator with wells. This gas is commonly known wrench when connecting into gas as wellhead gas. Test Pressures In Excess Of 1/2 piping and/or fittings.
Page 9 IMPORTANT: Make sure log does It is very important to install the logs 2. Open gas supply tank valve. not cover any burner ports (see Fig- exactly as instructed. Do not modify 3. Make sure control knob of heater is ure 10).
Page 10: Installing Blower Accessory
Installing Blower Accessory BLOWER ACCESSORY 20-6028 FOR GSN3011,GSP3012 ,GSN3013,GSP3014 And 20-6029 FOR GSN2221,GSP2222 Remove the 3 screws from the Wire. (Make sure these wires are back, upper right hand corner or clear of the fan.) the stove. Set these screws Reattach the Back Panel using aside.
Page 11 Installing Blower Accessory BLOWER ACCESSORY 20-6028 OR 20-6029 Figure 14 -F Routing Power Cord Figure 15 -F Mounting Blower And Installing Blower Control Housing...
Page 12: Operating Heater
OPERATING HEATER LIGHTING repairs. Until repairs are made, FOR YOUR SAFETY INSTRUCTION light pilot with match. To light pilot with match, see Manual READ BEFORE LIGHTING NOTICE: During initial operation of Lighting Procedures. new heater, burning logs will give WARNING: If you do not Keep control knob pressed in for off a paper-burning smell.
Page 13 THERMOSTAT CONTROL CLEANING BURNER OPERATION INJECTOR HOLDER AND The thermostat control knob can be PILOT AIR INLET HOLE set to any comfort level between HI The primary air inlet holes allow the proper amount of air to mix with the and LO.
Page 14: Specifications
(GSP3012 & GSP3014) of your heater Propane/LP How heater was malfunctioning l Ignition Piezo Type of gas used (propane/LP or GSP3012 & GSP3014 Models Burner Manifold Pressure 8.0"W.C. Purchase date Inlet Gas Pressure Usually, will ask you to (In.
Page 15: Troubleshooting
TROUBLESHOOTING Note: All troubleshooting items CAUTION: Never use a wire, WARNING: Only a qualified are listed in order of operation. needle, or similar object to service person should service clean ODS/pilot. This can and repair heater. damage ODS/pilot unit. REMEDY OBSERVED PROBLEM POSSIBLE CAUSE No spark when ignition button is...
Page 16 TROUBLESHOOTING Continued POSSIBLE CAUSE REMEDY OBSERVED PROBLEM 1. Burner orifice is clogged. 1. Clean burner orifice (see Cleaning B urner(s) do es n ot ligh t af ter 2. Burner orifice diameter is too and Maintenance) or replace ODS/pilot is lit. small.
Page 17 TROUBLESHOOTING Continued WARNING: If you smell gas Shut off gas supply. Do not try to light any appliance. Do not touch any electrical switch; do not use any phone in your building. Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.
Page 18: Parts Breakdown & Parts List
ILLUSTRATED PARTS BREAKDOWN GSP3012 GSN3011 GSP3014 GSN3013 GSP2222 GSN2221 Q TY ( N G ) Q TY ( L P ) K E Y N O P A R T N O . D E S C R IP TIO N...
Page 19 ILLUSTRATED PARTS BREAKDOWN GSP3012 GSN3011 GSP3014 GSN3013 GSP2222 GSN2221 QTY(NG) QTY(LP) PART NO. DESCRIPTION GSN30 11 GSN222 1 GSN301 3 GSP301 2 GSP2 22 2 GSP301 4 BL 03 7-02 Lo g set BL 03 8-02 Lo g set BL 03 9-02...

This manual is also suitable for:

Gsn3011 Gsp3014 Gsn3013 Gsp2222 Gsn2221

Kozy-World GSP3012 Owner's Operation And Installation Manual

Table of Contents

Need help?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Kozy-World GSP3012

Summary of Contents for Kozy-World GSP3012

This manual is also suitable for:

Table of Contents