Lubrication And Maintenance Of The Tractor; Oil Level; Oil Drain Plugs On - Dong Feng DF254G2-6 Service Manual

Chapter VI Lubrication and Maintenance of the Tractor
6.1 Oils to be used by the tractor and lubrication
6.1.1 Fuel oil and lubricants for the tractor
Position
Fuel tank
Gearbox, rear axle,
front drive axle,
hydraulic system
Clutch release
bearing
Other grease
nipples
Engine sump
Air pump
Steering gear
（4WD）
Oil inlet:
Grease nipples: 1 Water pump bearings of the engine

Oil level

inspection points: Dipstick of engine

Oil drain plugs on:

Category of oil
﹟
No.10 Light diesel Above 8℃
﹟
No.0 Light diesel 8℃～4℃
﹟
No.-10 Light diesel4℃～-5℃
﹟
No.-20 Light diesel-5℃～-14℃
﹟
No.-35 Light diese-14℃～-29℃
N100 Drive & hydraulic
dual-purpose oil
No.2Lithium-based grease
No.3 calcium-based grease
HCA-14 Diesel lube oil (SAE40)
HCA-11 Diesel lube oil (SAE30)
N100 Drive & hydraulic
dual-purpose oil
Engine (please refer to the Engine operation manual)
1 on upper-cover of the rear axle housing
1 on crankcase of the air pump
1 on left & right sleeves of the front axle
2 on the turnbuckles of the left & right lifting rod
1 on upper link
2 on the turnbuckles of the left & right check chains
2 on front & rear jaws of steering drag link
2 on left & right jaws of steering tie rod
2 on left & right steering arms
2 on rear pedestal (four wheeled drive only)
2 on left & right steering crank (four wheeled drive only)
1 on clutch operating shaft
1 on brake operating shaft
Dipstick on upper cover of rear axle housing
Dipstick on left half shaft housing of front wheel drive axle
Bottom of the engine sump
Lower-left side of the gearbox
Lower-rear side of the rear axle housing
Standard No
GB252-2000
GB443-1989
GB73245-1994
GB491-1987
GB11122-1997
GB443-1989
42
Remark
SAE85W
All atmospheric
temperature
All atmospheric
temperature
Summer
Winter
All atmospheric
temperature