Summary of Contents for VitalBodies.com Vital H2O
- Page 1 VITALBODIES.COM INSTALLATION AND USER MANUAL THANK YOU FOR CHOOSING VITALBODIES.COM: VITAL UNDER SINK SYSTEM V2...
- Page 2 VITALBODIES.COM FAUCET SINK SINK WATER SADDLE DRAIN ICE MAKER (OPTIONAL) FILTER 6 FILTER 5 MEMBRANE INPUT WATER VITALBODIES.COM VITALBODIES.COM PRE-FILTER MANIFOLDS 2006 © VITALBODIES.COM RELAX AND TAKE YOUR TIME: Make sure you have nothing scheduled for the rest of the day, so you have time to fully finish this job.
- Page 3 ODIES STRAIGHT WRENCH VALVE BRACKET TANK SCREWS VALVE 1/4” OR 3/8” 1/4” TO 1/4” JOHN GUEST JOHN GUEST BULK HEADS MALE JOHN GUEST UNION 1/4” TO 1/4” JOHN GUEST JOHN GUEST PRE-FILTER MANIFOLDS UNION T REDUCING UNION 2006 © VITALBODIES.COM...
- Page 4 FAUCET INPUT CONNECTION WATER SADDLE 2006 © VITALBODIES.COM INSTALL RO MEMBRANE: Insert the RO Membrane into it’s housing . It is shipped sealed for freshness and can only go in one way. (Insert the end with the two small O-Rings).
- Page 5 TUBING 2006 © VITALBODIES.COM PREPARE TANK: The Pressurized Holding Tank has a threaded fitting on it. Put on the tank valve. It is recommended that some anti-leak materials be used, like Teflon Tape. Attach the hose by pushing it in the quick disconnect fitting of the tank valve.
-
Page 6: Mount The System
2006 © VITALBODIES.COM CREATE FAUCET HOLE: You will be going through one of three types of materials. There is a fourth - Porcelain. It can be done, but it is strongly advised you do not do it yourself. In the case of Porcelain, it is advised you call a Pro. - Page 7 NEEDLE PIERCING VALVE 2006 © VITALBODIES.COM Needle-Piercing Valve: Position where you can get to it. It is normally best to have the valve handle on the right (unless you are left-handed) and the connection facing towards the cabinet doors. NOTE: If you have soft rubber tubing that you will be piercing though, you might what to replace it with copper or rigid plastic tubing.
-
Page 8: Normal Position
2006 © VITALBODIES.COM POSITION, DRILL AND INSTALL: Attach the rubber gasket to the pipe. Position the saddle over that spot and screw it on. Drill it out with a 1/4" drill bit. Put the compression nut on the yellow line and push the yellow line into the discharge pipe. - Page 9 (OPTIONAL) FILTER 6 DEIONIZATION MEMBRANE FLUSH FILTER FLUSH INPUT WATER VITALBODIES.COM VITALBODIES.COM PRE-FILTER MANIFOLDS 2006 © VITALBODIES.COM VISUAL INSPECTION - DOUBLE CHECK EVERYTHING: Make sure the flow restricter handle is set to the FLUSH position. Turn OFF the tank valve. Are there...
-
Page 10: Testing The System
(WIDE OPEN) 2006 © VITALBODIES.COM FINAL INSPECTIONS: When completed, get a nice bright flashlight and check over the entire system carefully. Also, remember that when the tank fills up completely, the system is then fully under pressure and that is when the tiny leaks occur --- if they are going to occur --- so keep an eye on it for a couple of days. - Page 11 This will save you the wonder of how pure your water really is, how are your filters doing, etc. Order replacement filters at VitalBodies.com. TURN OFF THE WATER: First step is to make sure you turn the water off to the filter. There is a little brass faucet (needle piercing valve) that is attached to the cold water line (under the sink) that needs to be turned off so water stops going into the filter.
- Page 12 NOTE: You should not need to change the RO Membrane until the TDS meter lets you know the filter is no longer filtering. You may want to print this page so you can have these instructions at hand. Let us know if you need any other information. VITALBODIES.COM...
-
Page 13: Troubleshooting
ONE OF THESE STEPS WILL FIX MOST LEAKS TUBING ADD MORE TEFLON TAPE ON THREADS PUSH TUBE IN FIRMLY. IF NEEDED REMOVE AND REINSTALL TUBE. PULL OUT TUBE, CUT THE END OFF STRAIGHT, AND RE-INSERT FIRMLY 2006 © VITALBODIES.COM... - Page 14 VITALBODIES.COM ONE OF THESE STEPS WILL FIX MOST LEAKS! TIGHTEN THE MANIFOLDS, ADD MORE TEFLON TAPE OR RESEAT THE QUICK CONNECTS... TUBING ADD MORE TEFLON TAPE ON THREADS PUSH TUBE IN FIRMLY. IF NEEDED REMOVE AND REINSTALL TUBE. PULL OUT TUBE, CUT THE END OFF...
- Page 15 HOW TO PARTICIPATE: 1. Give your friend the coupon below. 2. Refer VitalBodies.com as the place to buy an RO SYSTEM. 2. Let your friend know they can MENTION your name and email address. 3. Soon after your friend's completed satisfied purchase, we will email you a coupon for a free filter change*! We do not send junk mail.
- Page 16 VITALBODIES.COM ORGANIC, ECO, VITAL AND SUSTAINABLE SHIPPING DATE: PACKING SLIP: PORTABLE HOME ...