Summary of Contents for Elite TDCH CST 100I
- Page 1 Thermo Dynamic water heater & central heating booster USER MANUAL ELITE TDCH Installation Instructions and User Manual www.elitetdch.com ELITE TDCH Aug 2014v1 Page 1 of 25...
- Page 2 NOTES TO END USER THIS UNIT SHOULD ONLY BE INSTALLED BY QUALIFIED PERSONNEL IF AFTER INSTALLATION THE UNIT DEVELOPES ANY FAULTS CONTACT YOUR INSTALLER Installer Name Tel Number Date Installed Serial Number www.elitetdch.com ELITE TDCH Aug 2014v1 Page 2 of 25...
- Page 3 Ave De Los Labrodores, 5, Local 28760 Tres Cantos Madrid, Spain Tel 00 91 804 2612 Email jchacon@energypanel.es To avoid injury as well as the damaging the TDCH unit the following instructions should be followed. www.elitetdch.com ELITE TDCH Aug 2014v1 Page 3 of 25...
- Page 4 The TDCH is a thermo dynamic sytem based on air source heat pump using ambient room air which is then forced through a heat exchanger and condenser using refrigerent fluid. This is all contained in a compact easy to install housing www.elitetdch.com ELITE TDCH Aug 2014v1 Page 4 of 25...
- Page 5 Thermo Dynamic water heater & central heating booster www.elitetdch.com ELITE TDCH Aug 2014v1 Page 5 of 25...
- Page 6 Thermo Dynamic water heater & central heating booster 1. Compressor 2. Tank 3. Drum 4. Dehydrator 5. Expansion Valve 6. Ventilator 7. Condenser coil externa 8. Evaporator 9. CH booster coil internal www.elitetdch.com ELITE TDCH Aug 2014v1 Page 6 of 25...
- Page 7 Thermo Dynamic water heater & central heating booster 250 litres tank A = 176 cm B = 59 cm www.elitetdch.com ELITE TDCH Aug 2014v1 Page 7 of 25...
- Page 8 Thermo Dynamic water heater & central heating booster 10. Hot Water Outlet 11. Electrical Connection 12. System Water Inlet 13. Immerser coil 14. Heat exchange drip line 15.CH flow 16.Pressure reducing outlet 17. CH return www.elitetdch.com ELITE TDCH Aug 2014v1 Page 8 of 25...
- Page 9 5. Central heating flow to Item 15 6. Central heating return to Item 17 7. Pump and timer installed in Central Heating outlet 8. Plug in unit 9. Plug in timer / pump www.elitetdch.com ELITE TDCH Aug 2014v1 Page 9 of 25...
- Page 10 • The unit must be installed vertically • Check that the setting area in strong enough to take the units weight a 250 litre unit weighs approx. 300 Kgs when full of water www.elitetdch.com ELITE TDCH Aug 2014v1 Page 10 of 25...
- Page 11 It is best pactice to situate the unit next to an outside wall and and fit ducting to direct the cold air to the outside of the building. Hot air drawn in through top of unit and cold air expelled at rear through wall ducting www.elitetdch.com ELITE TDCH Aug 2014v1 Page 11 of 25...
- Page 12 It is recommended that an expansion vessel (tank) is fitted on the cold water outlet side. The current plumbing regulations should be referred to when fitting the expansion vessel 17 is located on the rear of the unit see Page 8 www.elitetdch.com ELITE TDCH Aug 2014v1 Page 12 of 25...
- Page 13 Thermo Dynamic water heater & central heating booster www.elitetdch.com ELITE TDCH Aug 2014v1 Page 13 of 25...
- Page 14 Thermo Dynamic water heater & central heating booster Filling the tank www.elitetdch.com ELITE TDCH Aug 2014v1 Page 14 of 25...
- Page 15 Close the cold water feed and hook the hot water outlet to the hot water system NB Resitance refers to Immerser Coil www.elitetdch.com ELITE TDCH Aug 2014v1 Page 15 of 25...
- Page 16 Thermo Dynamic water heater & central heating booster www.elitetdch.com ELITE TDCH Aug 2014v1 Page 16 of 25...
- Page 17 70 deg C, the switch is on the front of the cabinet see Fig 7 (resistance switch). NOTE To activate the immerser coil both the thermodynamic and the immerser coil switches must be in the on position www.elitetdch.com ELITE TDCH Aug 2014v1 Page 17 of 25...
- Page 18 Thermo Dynamic water heater & central heating booster www.elitetdch.com ELITE TDCH Aug 2014v1 Page 18 of 25...
- Page 19 Thermo Dynamic water heater & central heating booster www.elitetdch.com ELITE TDCH Aug 2014v1 Page 19 of 25...
- Page 20 Thermo Dynamic water heater & central heating booster Trouble shooting cont. www.elitetdch.com ELITE TDCH Aug 2014v1 Page 20 of 25...
- Page 21 Thermo Dynamic water heater & central heating booster www.elitetdch.com ELITE TDCH Aug 2014v1 Page 21 of 25...
- Page 22 6. Connect a 22 mm feed fig 7 on page 22 by teeing it into the FLOW side of the CH system as near as possible to the boiler and the other end onto the isolation valve on the oulet on the TDCH www.elitetdch.com ELITE TDCH Aug 2014v1 Page 22 of 25...
- Page 23 TDCH starts circulating prior to the central heating boiler starting up, this will ensure that there is no secondary source of energy to raise the water temperature. Current building/ hot water regulations should be adhered to at all times www.elitetdch.com ELITE TDCH Aug 2014v1 Page 23 of 25...
- Page 24 Thermo Dynamic water heater & central heating booster If in any doubt please refer to And this paragraph in particular www.elitetdch.com ELITE TDCH Aug 2014v1 Page 24 of 25...
- Page 25 Thermo Dynamic water heater & central heating booster Fig 7 www.elitetdch.com ELITE TDCH Aug 2014v1 Page 25 of 25...
Need help?
Do you have a question about the TDCH CST 100I and is the answer not in the manual?
Questions and answers