Table of Contents
Advertisement
Quick Links
A PATIO HEATER
LIKE NO OTHER
Radiant Patio Heater
Manual for Installation, Operation & Maintenance
If you smell gas:
1. Shut off gas to appliance.
2. Extinguish any open flame.
3. If odor continues, immediately call your
WARNING: Improper installation, adjustment, alteration,
service or maintenance can cause injury or property damage.
Read the installation, operating and maintenance instructions
thoroughly before installing or servicing this equipment.
Do not store or use gasoline or other flammable vapors and
liquids in the vicinity of this or any other appliance. A propane
cylinder not connected for use shall not be stored in the vicinity
of this or any appliance.
*
FOR OUTDOOR USE ONLY
*
The Even-GLO Patio heater has been approved for indoor use in
applications (See page 8 for details) for natural gas units ONLY
Please retain these instructions for future reference.
IMPORTANT: The installer must leave these instructions with
the owner. Only those who are certified to do so should
perform service on these heaters.
111 Progress Ave.
New Castle, PA 16101
www.berner.com
PARASOL
DANGER
gas supplier.
FOR YOUR SAFETY
non-residential
™
March, 2013
Advertisement
Table of Contents
Related Manuals for Berner PARASOL
Summary of Contents for Berner PARASOL
- Page 1 PARASOL Radiant Patio Heater Manual for Installation, Operation & Maintenance A PATIO HEATER LIKE NO OTHER DANGER If you smell gas: 1. Shut off gas to appliance. 2. Extinguish any open flame. 3. If odor continues, immediately call your gas supplier.
- Page 2 March, 2013 BERNER PATIO+ Parasol Page 2...
-
Page 3: Table Of Contents
8 - LIGHTING & SHUTDOWN INSTRUCTIONS ............29 ..........................29 IGHTING ..........................29 9 - MAINTENANCE AND TROUBLE SHOOTING ............. 30 ......................... 30 AINTENANCE ........................30 ROUBLE HOOTING 10 - PARTS LIST ....................31 12 - WARRANTY ....................33 March, 2013 BERNER PATIO+ Parasol Page 3... -
Page 4: Caution And General Safety
Children should be strictly supervised when in the area of this heating appliance. Playing • or running around the structure should be strictly forbidden. Clothing or other flammable materials should not be hung on or near this heater. • March, 2013 BERNER PATIO+ Parasol Page 4... -
Page 5: Pre-Installation Overview
2 - Pre-installation Overview What You Will Receive Top Reflector Heater head Assembly Pole Assembly Hardware March, 2013 BERNER PATIO+ Parasol Page 5... -
Page 6: Mounting Plate Hole Pattern
2 - Pre-installation Overview Mounting Plate hole Pattern (Full size) 6.30" Ø0.42" March, 2013 BERNER PATIO+ Parasol Page 6... -
Page 7: What You Need To Supply
National Fuel Gas Code, ANSI Z.223.1 (NFPA 54) in the US and Natural Gas and Propane Installation Code, CSA B149.1 or Propane Storage and Handling Code, B149.2 in Canada. 4. Electrical supply rated at 24 Vac with two stage control. March, 2013 BERNER PATIO+ Parasol Page 7... -
Page 8: Location Planning
3 - Location Planning General Location Layouts One Parasol heater, at high fire and in windless conditions, has a comfort radius of about twelve feet (24 ft. circle). A series of heaters providing area heat should be placed about 14-20 feet apart. -
Page 9: Clearance To Combustible Materials
Appliance must be electrically grounded in accordance with local codes or, in their absence; the National Electrical Code, ANSI/NFPA 70 in the USA, CSA C22.1 Canadian Electrical Code in Canada. NOTE: Some materials deteriorate or soften at sustained temperatures below 160°F. Consult material manufacturer for recommendations March, 2013 BERNER PATIO+ Parasol Page 9... -
Page 10: Installation Instructions
National Electrical Code, ANSI/NFPA 70 in the USA, CSA C22.1 Canadian Electrical Code in Canada. Equipment Dimensions Floor mount models Model BPP-E301NUB Model BPP-E301NTB Model BPP-E301PUB Model BPP-E301PTB 39.5" 39.5" 101.7" 89.7" 75.0" 63.0" 5.1" 5.1" 8" 8" March, 2013 BERNER PATIO+ Parasol Page 10... -
Page 11: Installation Instructions
Installation Instructions Hanging TEAR-DROP Model BPT-E301 / NHB BPT-EPHB 1.13" 17.95" Ø39.50" 47.98" 46.81" 6 Feet Minimum Clearance Below March, 2013 BERNER PATIO+ Parasol Page 11... -
Page 12: Power / Gas Specification
The appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressures in excess of ½ psig (3.5 KPa) March, 2013 BERNER PATIO+ Parasol Page 12... -
Page 13: Assembly
The pole base could also be mounted on wood decks with 3/8” bolts and lock washers on the underside of the deck. Periodically check for tightness when mounted to a wood deck. March, 2013 BERNER PATIO+ Parasol Page 13... - Page 14 Firmly tape the pull wire to the power wires. Lower the assembly into place while pulling the wires. Two people may be necessary for this operation. March, 2013 BERNER PATIO+ Parasol Page 14...
- Page 15 6 - Assembly c. Secure burner head to pole with three #10 screws provided. March, 2013 BERNER PATIO+ Parasol Page 15...
- Page 16 6 - Assembly d. Push the gas connection into the slot buy slightly pushing on the gas line through the electrical box. The gas fitting should be positioned as illustrated below. March, 2013 BERNER PATIO+ Parasol Page 16...
- Page 17 6 - Assembly e. Place gas connection cover onto the fitting and install the nut to fasten the cover assuring the nut is properly seated. See below. March, 2013 BERNER PATIO+ Parasol Page 17...
- Page 18 6 - Assembly f. Install reflector using the four carriage bolts, nuts and washer provided. g. Connect gas supply and electric power following all local codes. Pressure test all gas connections. March, 2013 BERNER PATIO+ Parasol Page 18...
-
Page 19: Ceiling Mount
6 - Assembly Ceiling Mount 1. Assemble 4 gusset plates to the base as illustrated. Use 5/16” carriage bolts with washers and nuts. March, 2013 BERNER PATIO+ Parasol Page 19... - Page 20 6 - Assembly 2. Assemble angular arms to the base. 3. Assemble vertical arm to angular arm using two gusset plates and 5/16” carriage bolts with nuts and washers. Repeat this for the other side. March, 2013 BERNER PATIO+ Parasol Page 20...
- Page 21 Caution: To prevent possible head injury provide pedestrian protection if lowest point of the heater is less than 7 feet in height. The heater must have a minimum clearance of 6 Feet below. March, 2013 BERNER PATIO+ Parasol Page 21...
- Page 22 6 - Assembly 6. Install heater assembly into the base assembly allowing the gas line and wires through the bottom. Use three #8-32 type F to secure heater head to the base. March, 2013 BERNER PATIO+ Parasol Page 22...
- Page 23 6 - Assembly 7. Feed the gas line and control wires through either side of the assembly. March, 2013 BERNER PATIO+ Parasol Page 23...
- Page 24 6 - Assembly 8. Install the heat shields as illustrated using the #8-32 type F screws supplied. 9. Install the bottom cover to complete the assemble using 4 #8-32 type F screws. March, 2013 BERNER PATIO+ Parasol Page 24...
- Page 25 6 - Assembly 10. Installation of reflector support brackets. 1. After putting on heat shields, screw reflector brackets to frame upright. 2. Secure reflector by screwing the reflector to the reflector support brackets. March, 2013 BERNER PATIO+ Parasol Page 25...
-
Page 26: Wiring
The switching mechanisms may also be Timers The supply cord shall be kept away from heated surfaces. Blue To Patio Heater Green 20VA 120V Ensure a good ground source March, 2013 BERNER PATIO+ Parasol Page 26... -
Page 27: Wiring Diagrams
électrique fait de la température évaluation with wiring material having a temperature rating d'au moins 105°C. EL013 01/08 of at least 105°C. March, 2013 BERNER PATIO+ Parasol Page 27... -
Page 28: External Wiring Options
Ground Source Back Box Front Cover Option 2: Using 2-Stage Switch (SRP P/N EE020) NC 1 NO 3 Blue (Hi) 24 VAC (Low) 24 Volt AC Supply To Patio Grounded Neutral Heater Green March, 2013 BERNER PATIO+ Parasol Page 28... -
Page 29: Lighting & Shutdown Instructions
Electronic control of heater can be re-set by de-energizing and re-energizing electric power. Shut Down 1. Turn off power to electronic control. 2. For longer periods of shut down, also close manual gas supply valve. March, 2013 BERNER PATIO+ Parasol Page 29... -
Page 30: Maintenance And Trouble Shooting
Flame Lights but Will Not Stay Lit • Ensure there is no overpowering wind. • Ensure sense electrode is not corroded, is not grounded or has a cracked insulator. Electrode position is radially across face of burner. March, 2013 BERNER PATIO+ Parasol Page 30... -
Page 31: Parts List
EG008 Spark Electrode EE001 Pole Package Black 63” ES114 Electronic Control Module EE009 Pole Package Black 75” ES131 Pole Package S/S 63” ES081 Pole Package S/S 75” ES132 Ignition wire (not shown) EE005 March, 2013 BERNER PATIO+ Parasol Page 31... - Page 32 Orifice - NAT Gas EG002 Orifice - LP Gas EG022 Gas Valve - NAT Gas EG001 Gas Valve - LP Gas EG023 Indicator Light EE004 Burner assembly EG008 Ignition wire (not shown) EE005 March, 2013 BERNER PATIO+ Parasol Page 32...
-
Page 33: Warranty
12 - Warranty BERNER PATIO+ PARASOL PORTABLE, FIXED AND TEAR-DROP BPP-E201, BPP-E301 & BPT-E301 WARRANTY The Manufacturer warrants to the original owner that the product will be free of defects in material and workmanship for a period of 5 years from the date of purchase, for everything except the electronic control module, spark electrode, and sense electrodes which have a replacement warranty period of 3 years.
Need help?
Do you have a question about the PARASOL and is the answer not in the manual?
Questions and answers