Subscribe to Our Youtube Channel
Summary of Contents for Trianco TRH 45 MK4
- Page 1 TRH 45 MK4 SOLID FUEL ROOM HEATER USER AND INSTALLATION INSTRUCTIONS To be retained by the householder...
- Page 2 HEALTH AND SAFETY INFORMATION FOR THE INSTALLER AND SERVICE ENGINEERS Under the Consumer Protection Act 1987 and the Health And Safety At Work Act 1974, it is a requirement to provide information on substances hazardous to health (COSHH Regulations 1988). TR Engineering takes every reasonable care to ensure that these products are designed and constructed to meet these general requirements, when properly used and installed.
-
Page 3: Table Of Contents
CONTENTS Page 1. USER INSTRUCTIONS Fuels to Use Operating Tool Lighting Control Settings Refuelling Ash Removal Overnight Burning To Revive the Fire 2. CLEANING Enamelled Parts Chimney Sweeping Grate Removal Shaker Rod Removal 3. MAINTENANCE Shutting Down Assembly 4. INSTALLATION INSTRUCTIONS General Description Specification Installation... -
Page 4: User Instructions
USER INSTRUCTIONS Fuels to use: IMPORTANT Sunbrite Singles and Doubles WHEN DE-ASHING AND REFUELLING THE BOILER A Small size Rexco. HEAT RESISTANT GLOVE MUST BE WORN WHEN OPENING AND CLOSING THE DOOR. Coalite. Anthracite Stove Nuts. Ash Removal Welsh Dry Steam Coal Small Nuts. COAL SHOULD NOT BE USED. -
Page 5: Cleaning
CLEANING Grate Removal The glass in the fire door has special heat resisting qualities This appliance is fitted with a reciprocating shaker grate and will adequately withstand the operating temperatures having ten individual bars fitted alternately on two rods, five reached by the appliance. -
Page 6: Assembly
WARNING Before re-lighting the appliance and in particular at the start Open all doors and windows to ventilate the room. of the heating session it is important to check the flue outlet Let the fire out or safely dispose of the burning has not become blocked by a fall of deposits from the fuel. - Page 7 AIR CONTROL ASSEMBLY Item Part Description Item Part Description 32750 AIR CONTROL ASSEMBLY 32753 Air Control Flap W.U. 32751 Thermostat, Rathgebar or Teddington 32756 Flap Gasket 32752 Thermostat Fixing Bracket 32786 Control Knob 91184 MX5X10 Pan Hd Pozi Setscrew 32758 Shroud, Brown 91321 M5X50 Pan Hd Pozi Setscrew...
-
Page 8: Assembly
SPARES BOILER BODY ASSEMBLY Size in mm unless otherwise stated SURROUND ASSEMBLY Item Part Description Item Part Description 30500 COMPLETE BOILERBODY ASSY,TRH45 91021 M5X12 PAN HD POZI SETSCREW 30510 BODY BOILER W.U. TRH45 Mk 3 32661 DOOR PIN 32878 THROAT PLATE (MK 1 & MK 2) 94257 M8 HEX NUT FULL 30525... -
Page 9: Installation Instructions
INSTALLATION INSTRUCTIONS BS 5449:1977 – Forced circulation hot water systems. GENERAL DESCRIPTION The Building regulations. TR Engineering TRH Range of Room heaters has been approved by the DSFAAS for burning smokeless solid fuels and is in the list of Approved Domestic Solid Fuel Local Authority Bye Laws. -
Page 10: Domestic Hot Water System
Fig. 4 Fig. 5 RECOMMENDED METHOD FOR FLUE CONNECTION Domestic Hot Water System there is always adequate supply of air to the room from adjacent rooms or passages. It is essential that a double feed indirect cylinder complying with BS. 1566:Part 1 is used for a domestic hot water An extractor fan must not be used on the same room as supply. -
Page 11: Flue Connections
The hearth should be flat and comply with the Building Regulations viz. a minimum project of 420mm. (16 ½”) from AIR DAMPER SETTING AIR DAMPER SETTING the face of the surround to the front edge of hearth. Any kerb on front edge must not be more than 25mm. (1”) to allow the appliance door to open fully. -
Page 12: Boiler Dimensions
TRH MK4 ROOMHEATER... - Page 14 Tel: (0114) 2572300 Fax: (0114) 2571419 www.trianco.co.uk © TR Engineering Ltd. Copyright in this brochure and the drawings or illustrations contained within are vested in TR Engineering Ltd and neither the brochure or any part thereof may be reproduced without prior written consent.
Need help?
Do you have a question about the TRH 45 MK4 and is the answer not in the manual?
Questions and answers