Polaris ATV 2002 Owner's Manual page 95

MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
Due to the nature of the adjustments marked with a J on the
following chart, it is recommended that service be performed by
an authorized Polaris dealer.
" More often under severe use, such as dirty or wet conditions to
purge water or dirt contamination from grease fittings and other
critical components.
L Emission Control System Service (California - 4-Cycle) NOTE:
Some 4-Cycle models may have an additional California -only
emissions warranty. Please refer to your owner's manual supplement
to determine if this applies to your vehicle.
Item
Ignition Timing
J
L
Fuel System
J
L
Fuel Filter
J
Radiator
Cooling System
hoses
Spark arrestor
Front hubs/fluid
"
change (AWD)
Clutches (drive and
J
driven)
92
CAUTION
Hours or When
Miles
100 hrs 12
months
100 12
hours months
100 hrs 12
months
100 hrs 12
months
100 hrs 12
months
100 hrs 12
months
100 hrs 12
months
100 hrs 12
months
Remarks
Inspect and adjust as
needed
Check for leaks at tank
cap, lines, fuel valve, filter,
pump and carburetor. Re-
place lines every two
years.
Replace annually
Inspect/clean external sur-
face
Inspect
Clean out
Inspect, clean