Caution; Safety; Maintenance - Pacific energy Broadway Installation And Operating Instructions Manual

Caution

FOR YOUR SAFETY - Do not install or operate your
Pacific Energy Broadway Direct Vent Gas Insert
without fi rst reading and understanding this manual. Any
installation or operational deviation from the following
instructions voids the Pacific Energy warranty and may
prove hazardous.
This appliance and its individual shutoff valve must be
disconnected from the gas supply piping system during
any pressure testing of that system at test pressures
in excess of 1/2 psig (3.5 kPa).This appliance must be
isolated from the gas supply piping system by closing
its individual manual shutoff valve during any pressure
testing of the gas supply piping system at test pressures
equal to or less than 1/2 psig (3.5 kPa).
Note: When lit for the fi rst time, the appliance will emit
a slight odour for a couple of hours. This is due to the
curing of paints, sealants, and lubricants used in the
manufacturing process. This condition is temporary;
Open doors and windows to ventilate the area. Smoke
and fumes caused by the curing process may cause
discomfort to some individuals.

Safety

Due to high temperatures, this gas appliance should
be located out of traffi c and away from furniture
and draperies.
Children and adults should be alerted to the hazards
of high surface temperature and should stay away
to avoid burns or clothing ignition.
Young children should be carefully supervised when
they are in the same room as the appliance.
Clothing or other fl ammable material should not be
placed on or near the appliance.
Any grill, panel or door removed for servicing the
unit must be replaced prior to operating. Failure to
do so may create a hazardous condition.
Installation and repair should be done by a
qualifi ed service person. The appliance should
be inspected before use and at least annually by
a professional service person.
cleaning may be required due to excessive lint from
carpeting, bedding material, etc. It is imperative that
control compartments, burners and circulating air
passageways of the appliance be kept clean.
It is Pacifi c Energy's policy that no responsibility is
assumed by the Company or by any of its employees
or representatives for any damages caused by an
inoperable, inadequate, or unsafe condition which
is the result, either directly or indirectly, of any
improper operation or installation procedures.
161204-24

Maintenance

Caution: Turn off gas and electrical power supply
and allow ample time for unit to cool before servicing
appliance. It is recommended that this appliance and
venting should be inspected at least once a year by a
qualifi ed service person.
Do not use this heater if any part has been under water.
Immediately call a qualifi ed service technician to inspect
the heater and to replace any part of the control system
and any gas control which has been under water.
Annual Inspection:
a) Clean louvers and air passage ways of excessive
lint buildup from carpeting, bedding material, etc. The
fl ow of ventilation air must not be obstructed.
b) Inspect logs and burner assembly for lint and soot
buildup. If excessive buildup of soot is present, have
a qualifi ed service person inspect and adjust unit for
proper combustion. Clean logs and burner with a vacuum
cleaner, paying close attention to burner ports.
c) Check the pilot system for proper fl ame size and
operation. Clean pilot free of lint or soot (See Fig. #1).
d) Check that the vent pipe and vent terminal are
open and free from blockage or debris. If the venting
system is disassembled for cleaning, it must be properly
assembled and re-sealed.
e) Check glass panel gasket, replace if necessary. It
is important that the glass seal be maintained in good
condition.
Note: The appliance area must be kept clear and
free from combustible materials, gasoline and other
fl ammable vapours and liquids.
Periodically:
a) Viewing glass may be cleaned with fi replace glass
cleaner.
b) Exterior porcelain enamel fi nish may be cleaned
with soap and water.
Note:
appliance.
More frequent
Never use abrasive cleaner to clean this
Do not clean glass when hot
Fig. # 1
THERMOCOUPLE
PILOT
FLAME
ELECTRODE
# 5055.6591
3