Table of Contents
Advertisement
GASOLINE WATER PUMP
IMPORTANT – Please make certain that
persons who are to use this equipment
thoroughly read and understand these
instructions and any additional instructions
provided prior to operation.
NOTE:
No refund or exchange once gasoline is placed
into the fuel tank.Warranty registration must be
complete within 30 days of purchase with proof
of purchase.
MBP15G
MBP20G
MBP30G
MBP40G
MBP20H
MBP30T
Operator's Manual
Advertisement
Table of Contents
Summary of Contents for Mitsubishi MBP15G
- Page 1 NOTE: No refund or exchange once gasoline is placed into the fuel tank.Warranty registration must be complete within 30 days of purchase with proof of purchase. MBP15G Operator’s Manual MBP20G MBP30G MBP40G MBP20H MBP30T...
-
Page 2: Table Of Contents
TABLE OF CONTENTS SAFTEY INSTRUCTIONS ● Warning Labels FEATURES, ASSEMBLY AND ACCESSORIES BEFORE OPERATION OPERATING THE WATER PUMP MAINTENANCE STORAGE TROUBLE SHOOTING SPECIFICATIONS PERFORMANCE CURVE LIMITED WARRANTY... -
Page 3: Saftey Instructions
SAFETY INSTRUCTIONS DANGER WARNING CAUTION DANGER indicates a potentially WARNING indicates a potentially CAUTION indicates a potentially hazardous situation which, if not hazardous situation which, if not hazardous situation which, if not avoided, WILL result in death or avoided, could result in death or avoided, may result in minor or serious injury. -
Page 4: Warning Labels
NOTICE CAUTION Improper treatment can damage the unit and shorten its life Engine oil is hazardous to the environment Be sure pump chamber is filled with water before starting the Be very careful when changing the oil to prevent spilling onto the engine. -
Page 5: Features, Assembly And Accessories
FEATURES, ASSEMBLY AND ACCESSORIES STOP SWITCH FUEL TANK OIL DRAIN PLUG FUEL TANK CAP OIL GAUGE DISCHARGE OUTLET SUCTION INLET PRIMING PLUG WATER DRAIN PLUG CHOKE LEVER SPARK PLUG FUEL COCK AIR FILTER SPEED LEVER MUFFLER RECOIL STARTER Assembly Main Accessories Inlet/Outlet O-Ring Hose Clamp Nut (X 4) -
Page 6: Before Operation
BEFORE OPERATION Fill the tank with clean, fresh unleaded Check Engine Oil Fuel Level automotive gasoline WARNING - Check fuel level. - If fuel level is low, refill with unleaded DO NOT attempt to start this engine without filling the crank case automotive gasoline. -
Page 7: Operating The Water Pump
OPERATING THE WATER PUMP Attach Suction Hose pump output, and moving the engine speed lever in the “Slow” Use a commercially available hose with hose connector and fixtures. direction will decrease pump output. The suction hose must be reinforced with a non-collapsible wall or e. -
Page 8: Maintenance
MAINTENANCE 1. Maintenance Schedule (daily) PRE INITIAL EVERY EVERY EVERY ITEM REMARKS OPERATION 25HR 50HR 100HR 300HR Check condition adjust gap ● Spark Plug and clean. Replace if necessary ● Check oil level Engine Oil ● ● replace ● ● Air Filter Clean, replace if necessary Clean and adjust. -
Page 9: Storage
Clean Air Filter 2. “How-To” Maintenance 1. Unscrew the air filter cover; Element Holder Engine Oil Change 2. Remove filter element and wash Element well in solvent; 1. Drain oil by removing the drain Oil Gauge 3. Pour a small amount of oil onto the plug and the oil gauge while filter element and gently squeeze out engine is warm. -
Page 10: Trouble Shooting
TROUBLE SHOOTING Problem Cause Correction 1. Pump not primed. 1. Fill pump chamber with water and prime pump. 2. Suction hose restricted, collapsed, damaged, 2. Replace suction hose. too long, or diameter too small. 3. Sink the strainer and the end of suction hose 3. -
Page 11: Specifications
SPECIFICATION MODEL NO. MBP15G MBP20G MBP30G Engine Brand: MITSUBISHI MITSUBISHI MITSUBISHI Engine Model NO.: GT241 GT400 GT600 Type: OHV, 4 Stroke, Air cooled OHV, 4 Stroke, Air cooled OHV, 4 Stroke, Air cooled Displacement: 79.6 cc 126 cc 181 cc Fuel Tank Size: 0.423 Gallon/Unleaded Gasoline... -
Page 12: Performance Curve
PERFORMANCE CURVE MBP30T Flow Flow MBP20H Flow - 11 -... -
Page 13: Limited Warranty
LIMITED WARRANTY This Mitsubishi engine product carries a guarantee of 24 months. If 1. Problems caused by parts that are not original parts. your product develops a fault within this period, DO NOT return to store, you should, in the first instance contact our customer service.