Summary of Contents for Ransomes Parkway 2250 Plus LGNN040
Page 1
24286G-GB (rev.6) ® Maintenance Manual Parkway 2250 Plus Series: WB - Engine type: Kubota V1505 Product code: LGNN040 Series: CT - Engine type: Ford VSG413 Product code: LGNN100 WARNING: If incorrectly used this machine can cause severe injury. Those who use and maintain this machine should be trained in its proper use, warned of its dangers and should read the entire manual before attempting to set up, operate, adjust or service the machine.
CONTENTS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL INTRODUCTION PRODUCT IDENTIFICATION ..................2 SPARES STOCKING GUIDE ..................2 HOW TO USE THE PARTS MANUAL ................3 SAFETY INSTRUCTIONS OPERATING INSTRUCTIONS ..................4 SAFETY SIGNS ......................4 STARTING THE ENGINE ....................4 DRIVING THE MACHINE ....................
Machine Weight Engine Power Spares Stocking Guide To keep your equipment fully operational and productive, Ransomes suggests you maintain a stock of the more commonly used maintenance items. We have included part numbers for the additional support materials and training aids.
It may not be possible to illustrate every item. With certain items purchased from outside suppliers some component parts may not be available from Ransomes and may need to be specially ordered from the supplier e.g. Volvo hydraulic motor components.
SAFETY INSTRUCTIONS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL • Remember that some people are deaf or blind and that children and animals can be unpredictable. This safety symbol indicates important safety • Keep travelling speeds low enough for an messages in this manual. When you see this...
RANSOMES PARKWAY 2250 PLUS SAFETY INSTRUCTIONS MAINTENANCE MANUAL change the engine governor settings or 3.7 SLOPES overspeed the engine. Operating the engine TAKE EXTRA CARE WHEN WORKING ON at excessive speed may increase the hazard SLOPES of personal injury. •...
Page 8
If it vents when static the machine should not be started, all potential sources of ignition should be inhibited until the venting has stopped and the local Ransomes Jacobsen dealer should be contacted. • Where practical LPG fuelled vehicles should be parked in the open air, in a well ventilated position.
Page 9
SAFETY INSTRUCTIONS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL WARNING WARNING California Proposition 65 Batteries produce explosive gases and Engine Exhaust, some of its constituents, contain corrosive acid and supply levels and certain vehicle components contain of electrical current high enough to cause or emit chemicals known to the state of burns.
SPECIFICATIONS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL VIBRATION LEVEL 4.7 CUTTING PERFORMANCE The machine was tested for whole body and hand/ arm vibration levels. The operator was seated in the 47 cuts per meter at 12 km/hr with 8 knife floating normal operating postion with both hands on the head units.
RANSOMES PARKWAY 2250 PLUS LUBRICATION AND MAINTENANCE MAINTENANCE MANUAL 5.1 LUBRICATION AND MAINTENANCE CHART DEISEL POWERED MACHINES l i f l i f l i f l i f l i f l i f & & t t i...
LUBRICATION AND MAINTENANCE RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL 5.2 LUBRICATION AND MAINTENANCE CHART LPG POWERED MACHINES / y l y l i l l i l i o t l i f t l i f l i o...
LUBRICATION AND MAINTENANCE RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL LUBRICATION. ENGINE - Diesel: First 50 working hours and every 200 working hours. Change Engine Oil. Warm up the engine first and then shut it off. Remove oil drain plug from the bottom of the crankcase and wipe it off.
LUBRICATION AND MAINTENANCE RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL LUBRICATION. MACHINE: Lubricate the following points.Weekly or every 40 working hours. 1. Lubricate the following with Shell Darina R2 grease. Lift arm pivots (A). Cutting unit pivots (B). Axle centre pivot (C).
LUBRICATION AND MAINTENANCE RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL LUBRICATION. MACHINE: Every 400 Working Hours. unit by removing the two screws and washers holding Lubrication of Direct Drive Hydraulic Motor (Every 400 the motor to the bearing housing. Carefully withdraw...
LUBRICATION AND MAINTENANCE RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL MAINTENANCE ENGINE MAINTENANCE - DIESEL Every 100 hrs Fuel System. Use Diesel fuel No.2-D (ASTM D975) See engine manufacturer's manual for additional information. Water Separator - If water is not removed from the fuel, extensive damage can be done to the fuel injection system.
LUBRICATION AND MAINTENANCE RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL MAINTENANCE 5.9 ENGINE MAINTENANCE - DIESEL Every 400 hrs Replace In-line fuel (C) Cleaning the air filter Remove loose dirt from element with compressed air working from the clean to dirty side, using compressed air max 6 bar , with nozzle 5cm from element.
LUBRICATION AND MAINTENANCE RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL MAINTANACE 5.10 ENGINE MAINTENANCE - DIESEL Every 400 hrs Changing fuel filter Unscrew filter (A) from filter head. Remove water (B) separator from filter and discard filter. Fit water separator to new filter and refit filter to head.
RANSOMES PARKWAY 2250 PLUS LUBRICATION AND MAINTENANCE MAINTENANCE MANUAL MAINTENANCE 5.12 END OF SEASON or when required Change Hydraulic filter. Lower the centre cutting unit to improve access. Wipe filter bowl (A) and housing to remove any dirt present. Place a suitable drip tray on top of the centre cutting unit.
LUBRICATION AND MAINTENANCE RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL MAINTENANCE 5.12.1 END OF SEASON or when required LPG Engine Change Spark Plugs Remove the lead from each spark plug by grasping, twisting and then pulling the moulded boot on the end of the lead.
ADJUSTMENTS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL ADJUSTMENTS 6.1 SPEED LIMITER. The transport and mow speeds of the machine are factory set and should not be altered. Textron Turf Care cannot be held responsible for loss of performance or machine damage if these speeds are altered.
ADJUSTMENTS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL ADJUSTMENTS BACKLAPPING Ransomes Jacobsen grinding paste: This mower is fitted with a device to allow the reels 80 grit grinding paste, 4.5kg tin, to be driven in reverse for backlapping. Part number 5002488 •...
MAINTENANCE MANUAL 7.1 TROUBLESHOOTING - DIESEL The troubleshootijng chart below lists basic problems that may occur during start-up and operation. For more detailed information regarding the hydraulic and electrical systems contact your area Ransomes Distributor. o l l l l i...
MAINTENANCE MANUAL 7.1 TROUBLESHOOTING - LPG The troubleshootijng chart below lists basic problems that may occur during start-up and operation. For more detailed information regarding the hydraulic and electrical systems contact your area Ransomes Distributor. y t l c t i .
Page 26
7 TROUBLESHOOTING RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL n i l y l t i f s y t l e l t i t s y t l n i l l l i f i t s l l u e l t .
Page 27
7 TROUBLESHOOTING RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL , s l . s l l i f e l l . y r g i l e t l t l e e t l . l e . y r...
SCHEMATICS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL ELECTRICAL CIRCUIT ENGINE AND SAFETY DIESEL Starter Relay 1 Relay 2 Heater Relay Heater Plugs Backlap Switch Diff Lock Solenoid Run Solenoid Starter Back Connection 2 WD Solenoid Diverter Solenoid Mow Solenoid Temperature Sender...
Page 33
SCHEMATICS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL CABLE COLOUR CODE Black Black Orange Violet Green White Brown Blue Yellow Orange Pink White Green Blue Grey Black Green White Yellow Brown GB-31...
SCHEMATICS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL ELECTRICAL CIRCUIT MAIN LPG CABLE COLOUR CODE Black Black Orange Violet White Brown Blue Yellow Green Pink White Green Blue Orange Black Green White Yellow Brown Grey GB-32...
Page 35
SCHEMATICS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL Relay 1 Relay 2 Backlap Switch Diff Lock Solenoid 2 WD Solenoid Diverter Solenoid Mow Solenoid Lamp Timer Front Lights Binnacle Connector B Binnacle Connector A Binnacle Connector C Binnacle Connector D Rear Lights...
SCHEMATICS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL ELECTRICAL CIRCUIT ENGINE LPG-1 Temperature Sender Engine Over Temperature Switch Oil Pressure Switch Alternator Alternator Fuse Fuse to Other Circuits Connector 1 to Engine Harness Connector 2 to Engine Harness Connector 3 to Engine Harness...
SCHEMATICS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL ELECTRICAL CIRCUIT INSTRUMENTS & CONTROLS CABLE COLOUR CODE Yellow Green Blue Orange Brown Grey Black Green Black Black Orange White Brown Blue Pink White Green Violet White Yellow GB-36...
Page 39
SCHEMATICS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL ELECTRICAL CIRCUIT INSTRUMENTS & CONTROLS Connector B Connector A Connector C Connector D Mow Switch Indicator Switch Lamp Switch Beacon Switch Hazard Illumination Hazard Switch Mow Switch Illumination Fuel Gauge Hour Meter Engine Tenperature Gauge...
SCHEMATICS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL ELECTRICAL CIRCUIT FUSES AND RELAYS - DIESEL Fuse A – 20 Amp (Ignition) Wire colours Green & White. Fuse B – 20 Amp (Starter Soleniod) Wire colours White/Green & White/Orange Fuse C – 10 Amp (Cab Supply) Wire colours White &...
Page 41
SCHEMATICS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL FUSE S(TOP) – Brown wire to here will have an ‘H’ identification tag, this is the circuit for the Glow Plug Heaters (Pre’Heat) FUSE T (MIDDLE) – Brown wire to here will have an ‘A’...
SCHEMATICS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL ELECTRICAL CIRCUIT FUSES AND RELAYS - LPG Fuse A – 20 Amp (Ignition) Wire colours Green & White. Fuse B – 20 Amp (Starter Soleniod) Wire colours White/Green & White/Orange Fuse C – 10 Amp (Cab Supply) Wire colours White &...
Page 43
SCHEMATICS RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL FUSE T (Top) – Brown wire to here will have an ‘A’ identification tag, this is the circuit for the Alternator. FUSE U (Middle) – Brown wire to here will have an ‘S’ identification tag, this is the circuit for the Safety system.
Page 44
RANSOMES PARKWAY 2250 PLUS MAINTENANCE MANUAL NOTES GB-42...
Page 46
® Ransomes Jacobsen Limited Jacobsen, A Textron Company West Road, Ransomes Europark, Ipswich, IP3 9TT 11108 Quality Drive, Charlotte, English Company Registration No. 1070731 NC 28273, USA www.ransomesjacobsen.com www.Jacobsen.com...