Yamaha F80B Service Manual page 241

A.
Adjusting the float .....................................4-17
Adjusting the throttle link and
throttle cable .............................................3-8
Adjusting the trim sensor ..........................7-21
After test run ...............................................1-9
Applicable model.........................................1-5
Assembling the drive shaft........................6-20
Assembling the forward gear ....................6-19
Assembling the fuel pump...........................4-6
Assembling the gear pump .......................7-33
Assembling the lower case .......................6-19
Assembling the oil pan..............................7-14
Assembling the oil pump...........................7-12
Assembling the power trim and
tilt motor ..................................................7-29
Assembling the power trim and
tilt unit......................................................7-41
Assembling the power unit........................5-50
Assembling the propeller shaft
assembly.................................................6-12
Assembling the propeller shaft housing ....6-13
Assembling the tilt cylinder .......................7-39
Assembling the upper case.......................7-15
Assembling the vapor separator ...............4-17
B.
Backlash ...................................................6-28
Bleeding the power trim and tilt unit..........7-43
Bleeding the power trim and tilt unit
(built-in) ...................................................7-44
Bottom cowling............................................7-3
Bow view.....................................................8-5
Bracket unit ..................................... 3-11
Break-in.......................................................1-9
C.
Canister.....................................................4-19
Changing the engine oil by draining it.........3-4
Changing the engine oil using
an oil changer ...........................................3-4
Changing the gear oil................................3-12
Charging system .......................................8-16
Checking the anodes ................................3-14
Checking the armature..............................8-15
Checking the battery ......................... 1-7
Checking the bearings ..............................6-18
Checking the brushes ...............................8-16
Checking the camshafts............................5-32
Checking the canister ...............................4-20
Checking the compression pressure...........5-3
6D93G11
Checking the connecting rod big end side
clearance ................................................ 5-43
Checking the cooling water passage.......... 3-8
Checking the cooling water pilot hole ......... 1-9
Checking the cooling water temperature
sensor....................................................... 8-9
Checking the crankpin oil clearance......... 5-44
Checking the crankshaft ........................... 5-44
Checking the crankshaft journal
oil clearance ........................................... 5-47
Checking the cylinder bore ....................... 5-42
Checking the cylinder head ...................... 5-32
Checking the diaphragm and valves .......... 4-6
Checking the drive shaft ........................... 6-18
Checking the drive shaft bushing ............. 7-13
Checking the ECM...................................... 8-8
Checking the electric fuel pump ............... 8-10
Checking the electrical components........... 8-2
Checking the engine idle speed ................. 3-8
Checking the engine oil .............................. 3-4
Checking the engine oil level...................... 1-6
Checking the engine start switch
and engine stop lanyard switch ................ 1-8
Checking the fuel filter ................................ 3-3
Checking the fuel joint and fuel hoses
(fuel joint-to-fuel injector) .......................... 3-3
Checking the fuel pump.............................. 4-5
Checking the fuel system ........................... 1-6
Checking the fuse..................................... 7-45
Checking the fuses ................................... 8-11
Checking the gear oil level ................1-7
Checking the gear pump .......................... 7-33
Checking the gear shift and throttle
operation................................................... 1-8
,
9-13
Checking the gear shift operation............. 3-10
Checking the idle speed control ................. 4-9
Checking the ignition coils .......................... 8-7
Checking the ignition spark ........................ 8-7
Checking the injectors .............................. 8-10
Checking the lower case .......................... 6-18
Checking the lower unit for air leakage .... 3-13
Checking the magnet switch..................... 8-16
Checking the main and fuel pump relay
(fuel control)............................................ 8-11
Checking the main and fuel pump relay
(main control).......................................... 8-10
Checking the oil pressure ........................... 5-3
,
3-14
Checking the oil pressure switch ................ 8-9
Checking the oil pump .............................. 7-12
Checking the oil strainer ........................... 7-14
Checking the outboard motor
mounting height ........................................ 1-7
Checking the pinion and forward gear...... 6-18
Index
1
2
3
4
5
6
,
3-12
7
8
9
i-1